RoadVitals

2015 Newmar Canyon Star Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1
Latest Mar 3, 2022
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2015 Newmar Canyon Star, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes1100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

1
report

From owner reports, verbatim

I have a 2015 Newmar Canyon Star 3953 (on an F-53 Motorhome Chassis) serial number [XXX] with 57,335 miles. The attached picture does not do justice to what I have to say. The picture is the front rotor of the brake assembly. In between the outer and inner plates of the rotor are two steel rods. The only purpose (that is thought) of the rod is to balance the rotor. The problem is, the rotor heats up as you brake then expands the rotor which loosens the area around the rod. Centrifugal force moves the rod out of the air gap and it starts to hit the caliper (in the picture you can see the top of the rod is shiny) resulting in a thumping sound or what has happened, the rotor cracks. I have had to replace both front calipers and rotors as a result of these rods. Thankfully when the rotor cracked I was only traveling about 30 mph. I can only imagine what would have happened if I was traveling 60 mph. In talking with the mechanic the rod could have jammed on the front edge (worst case) of the rotor then broke all of the fins in the air gap and perhaps stopped the rotation of the tire. These were factory-installed rotors which clearly (in my opinion) a safety hazard and warrants a recall or at least an investigation. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ID 11454972 · filed Mar 3, 2022

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .