2016 Nissan Frontier Owner Complaints

OUR 2016 NISSAN FRONTER HAS A SLOW AIR LEAK ON THE TIRES AFTER HAVEING THEM CHECKED BY A TIRE DEALER IT WAS FOUND THE TIRE PRESSURE SENSOR (TPS) WAS LEAKING AT THE CORE DEALER WAS UNABLE TO REMOVE THE CORE OR THE NUT THAT HOLDS THE TPS ON THE WHEEL. GALVONIC REACTION HAD WELDED ALL IN PLACE . DEALER CUT THE VALVE OFF AND REPLACED WITH A NEW TPS (NON METAL) AS IS THERE PRATICE AS THEY HAVE HAD PROBLEMS WITH METAL ONES IN THE PAST . I THINK THIS COULD BE A PROBLEM WITH OTHER TPSs AND COULD HAVE LOSS OF AIR PRESSURE OR AT LEAST THE OWNER WOULD BE UNABLE TO ADD AIR TO TIRE THE TPS IS A STOCK NISSAN SCHRADER ELECTRONICS RTPMS 40700 1AA0B BLUE IN COLOR

NHTSA ID

11753328

Incident

Jul 28, 2026

I am experiencing a fuel pump issue that stalls the engine while driving. The issue will sometimes go away if I first loosen the fuel cap on the gas tank to relieve built up pressure but after driving for 10 to 15 minutes or so the vehicle will begin to jerk while accelerating then it will stall and cut off. I have to wait a few minutes once it cuts off and then I can start the engine up again and drive for another 10 to 15 minutes before the issue occurs again. The vehicle has over 120,000 miles on it and all parts are original to the vehicle.

NHTSA ID

11694089

Incident

Oct 17, 2025

A loud squeaking has developed during every day driving. After inspecting - the front right truck bed mounting location has cracked and failed.

NHTSA ID

11624547

Incident

Aug 1, 2024

WHILE FUELING AT DIFFERENT GAS STATIONS THE TANK SPILLS/BELCHES GAS ALL OVER. THIS IS A MAJOR SAFETY ISSUE AND NEEDS RECALLED. THERE ARE ENDLESS COMPLAINTS ON [XXX] OF SIMILAR ISSUES OCCURRING TO OTHER FRONTIER OWNERS. I TOOK IT TO MY LOCAL MECHANIC AND WAS QUOTED OVER $800 TO REPLACE ALL 5 COMPONENTS OF THE SYSTEM AS NISSAN HAS SUGGESTED IN A BULLETIN FOR MECHANICS. IF NISSAN IS AWARE OF THIS ISSUE ENOUGH TO ISSUE A TECHNICAL BULLETIN THEN THE ISSUE NEEDS TO BE RECALLED AND REPAIRED FOR FREE BECAUSE GAS SPILLING/SPRAYING ALL OVER ME EVERY TIME I FILL UP MY VEHICLE IS OUT RIGHT DANGEROUS AND UNSAFE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11614337

Incident

Sep 12, 2024

The airbag warning light is blinking and has been for approximately 9 months. I live in Salida, CO which does not have a Nissan Dealership to take my vehicle into for servicing. I recently saw an article on Fox 31 News pertaining to the same airbag malfunction and would like to know what to do about my problem.

NHTSA ID

11608384

Incident

Dec 1, 2023

Head gasket blew and it warped the heads at 98,000 miles Replace motor with a 51,000 mile motor and less than 2 months later, motor is knocking inside with broken peices of the motor. I have to replace it again.

NHTSA ID

11597546

Incident

Jun 26, 2024

The issues iw with the lug nuts expanding locking on the tire so it cannot be takeoff for rotation or replacement or if you have a flat tire tout on the spare. Went to BJ's tire in Pasadena, MD (1-410-647-6600) to have a rotation and they said they could not do it the lug nuts expanded to larger size and it could cross thread if they got them off and tried tout them back on. AS WELL THEY MIGHT NOT BE SECURED TIGHT ENOUGH THAT THEY WOULD NOT FALLOFF WHILE DRIVING. A SAFTY ISSUES WITH BJ'S. BOTH MECHANICS VERIFIED IT AND THE TWO MANAGERS OF THE STORE AS WE.. I did not believe them so I took it to Sheehy Nissan in glen Burnie where the two top managers verified that the lug nut expanded so large they had to be replaces OR IT WOULD BE A SAFTY ISSUE with me driving with he old one on as they cannot be safely tightened down and may come off during driving. So I need all 24 lug nuts replaced. I think he said they expanded from 21 mm (or cm) to 22.5 mm (or cm).the manager has been doing this for over 30 years and his assistant said the same who has been doing it for over 25 years. Mr Brian Jordan at 1-410-760-3500 ext #81052) So I need all 24 replaced as the rest could expand. The real cost is over $800 but willing to do it for like $550 plus tire rotation. As both BJ's managers and tire people and Nissan managers are saying thesis a serious safety issue I believe them. They say unless proper tools used other issues can occur. And ALMOST IMPOSSIBLE TO REMOVE BY THE OWNER OF THE VECHILE. Especially if the person icon the road replacing the tier with the spare. They showed me on the internet the issues with ford and other manufactures from before 2000 having this issue. As I am [XXX] it would be really hard to deal with if an emergency came up o the road. You need look into this issue. IT IS A REAL SAFETY ISSUE esp. for older folks. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11592565

Incident

Jun 4, 2024

My 2016 Nissan Frontier is leaking axle grease from the driver side rear tire. The grease/oil got all over the brake pads, rotor, and emergency brake. This seems to be a very common issue that was supposed to have been resolved several models prior.

NHTSA ID

11562865

Incident

Dec 31, 2023

Airbags didn’t deployed when the incident of the the truck crashed at the time. (April 05,2023)

NHTSA ID

11519626

Incident

Apr 5, 2023

The contact owns a 2016 Nissan Frontier. The contact stated that while operating the vehicle air bags warning light remained illuminated. The vehicle was taken to the local dealer who determined that the air bag system was disconnected under the passenger’s side dashboard. The system was reconnected, and the failure was remedied. The contact stated that the failure had recently reoccurred. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 90,632.

NHTSA ID

11519270

Incident

Dec 15, 2022

Mileage

90,632 mi

All glass in vehicle showing spotted areas with factory tinting

NHTSA ID

11517510

Incident

Apr 17, 2023

The contact owns a 2016 Nissan Frontier. The contact stated that while driving approximately 60 MPH, the vehicle lost motive power and stalled. There were no warning lights illuminated. The contact was able to restart the vehicle. The vehicle was taken to the local dealer but was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 90,000.

NHTSA ID

11466030

Incident

Nov 1, 2021

Mileage

90,000 mi

I HAVE A 2016 NISSAN FRONTIER WITH ONLY 68,000 MILES ON IT. THE AIRBAG LIGHT ON THE DASH STARTED FLASHING. I TOOK IT TO ANY MOHR NISSAN AND THEY DIAGNOSED THAT THE SENSOR INSIDE THE PASSENGER SEAT THAT TELLS THE SYSTEM IF SOMEONE IS SITTING THERE HAS FAILED AND THAT IT IS AN $1800 REPAIR, BECAUSE THE ONLY WAY TO FIX IT IS TO REPLACE THE WHOLE SEAT. THEY SAID THEY COULDN'T SAY WHETHER THE AIRBAG WOULD DEPLOY OR NOT IN AN ACCIDENT IF I DIDN'T FIX THE SENSOR.

NHTSA ID

11389453

Incident

Jan 1, 2021

Mileage

68,400 mi

WHILE FUELING AT DIFFERENT GAS STATIONS THE TANK SPILLS/BELCHES GAS ALL OVER. THIS IS A MAJOR SAFETY ISSUE AND NEEDS RECALLED. THERE ARE ENDLESS COMPLAINTS ON WWW.CLUBFRONTIER.ORG OF SIMILAR ISSUES OCCURRING TO OTHER FRONTIER OWNERS. I TOOK IT TO MY LOCAL MECHANIC AND WAS QUOTED OVER $800 TO REPLACE ALL 5 COMPONENTS OF THE SYSTEM AS NISSAN HAS SUGGESTED IN A BULLETIN FOR MECHANICS. IF NISSAN IS AWARE OF THIS ISSUE ENOUGH TO ISSUE A TECHNICAL BULLETIN THEN THE ISSUE NEEDS TO BE RECALLED AND REPAIRED FOR FREE BECAUSE GAS SPILLING/SPRAYING ALL OVER ME EVERY TIME I FILL UP MY VEHICLE IS OUT RIGHT DANGEROUS AND UNSAFE. BULLETIN NUMBER NTB16-122

NHTSA ID

11385655

Incident

Nov 24, 2020

Mileage

36,000 mi

ENGINE VIBRATION AT LOW RPM THAT CAN'T BE EXPLAINED BY SEVERAL MECHANICS.

NHTSA ID

11375755

Incident

Jul 15, 2020

ENGINE HESITATES OR STALLS ON ACCELERATION. WHEN PULLING OUT FROM A STOP ENGINE HESITATES TO NEAR STALL NO MATTER HOW HARD OR FAR YOU PRESS GAS PEDAL. EXTREMELY DANGEROUS. INTERMITTENT ISSUE, NO FAILURE CODES WHEN TESTED. IF ENGINE DOESN'T STALL, VEHICLE IS AT A STAND STILL EVEN WITH GAS PEDAL TO FLOOR OR PUMPING GAS PEDAL. IS HAPPENING ALL THE TIME, EXTREMELY DANGEROUS. NEARLY HIT BY ONCOMING TRAFFIC SEVERAL TIMES. DEALERSHIP HAS HAD MANY REPORTS OF SAME ISSUE, BUT NO SOLUTION. I AM AFRAID TO DRIVE VEHICLE.

NHTSA ID

11373557

Incident

Nov 6, 2020

Mileage

63,000 mi

KEY LOCKED IN IGNITION THEN STEERING WHEEL LOCKED. CAR WAS PARKED AT A PUBLIC BEACH PARKING LOT BEFORE THE ISSUE OCCURRED.

NHTSA ID

11352922

Incident

Aug 24, 2020

TRANSMISSION AND BRAIN REPAIR BY DEALERSHIP UNDER WARRANTY 20017, AND OVERHEATING PROBLEM DUE TO RADIATOR IN 2020 AFTER EXPIRE OF WARRANTY, $1000 OUT OF POCKET REPAIRS.

NHTSA ID

11349599

Incident

Aug 1, 2020

Mileage

35,000 mi

THE YAWRATE SENSOR AND ABS DIAGNOSTIC MODULE HAD TO BE REPLACED TO KEEP MY VEHICLE FROM GRABBING THE BRAKES AS I STARTED DRIVING

NHTSA ID

11328733

Incident

Jun 10, 2020

Mileage

38,700 mi

HESITATION FROM IDLE TO TAKE OFF-NEVER KNOW WHEN IT IS GOING TO ACT UP,FOR EXAMPLE TURNING IN FRONT OF ANOTHER VEHICLE-- WILL I MAKE IT THIS TIME WITHOUT AN ACCIDENT? *TR

NHTSA ID

11325444

Incident

Dec 30, 2019

Mileage

17,000 mi

MY VEHICLE WAS BURGLARIZED. THE THIEVES GOT IN THROUGH THE REAR SLIDING GLASS. THE LATCH DOES NOT LOCK AND IS FAULTY. IF THE LATCH WAS FULLY FUNCTIONAL, NOBODY WOULD HAVE GONE IN AND STOLEN EVERYTHING I OWNED.

NHTSA ID

11229697

Incident

Jun 24, 2019

Mileage

72,000 mi

WAS DRIVELING DOWN A STRAIGHT CITY STREET ON A CLEAR SPRING DAY AT ABOUT 30 MPH AND THE CAR TURNED OFF INCLUDING ALL ELECTRICAL DEVICES WITHOUT WARNING. THEN ABOUT 1.5 SECONDS LATER THE CAR TURNED BACK ON.

NHTSA ID

11206271

Incident

May 5, 2019

TAKATA RECALL AIR BAG DISPLAY LITE FLASHES ON AND OFF ! NOT SAFE IN MOTION

NHTSA ID

11203149

Incident

Apr 15, 2019

Mileage

52,000 mi

ONGOING DISPUTE WITH MANUFACTURER AND DEALER. THE VEHICLE HAS NO LOWER LATCH BRACKETS TO ATTACH A CHILD SEAT . THE DEALER SERVICE MANAGER STATED THAT THE VEHICLE WAS EXEMPT FROM THE REGULATION. THE ONLY EXEMPTIONS I SEE IN THE STATUTE ARE FOR SCHOOLBUSES. CONVERTIBLES, AND VEHICLES WITH A GVR OF 8500 LBS OR OVER. MY FRONTIER HAS A GVR OF ABOUT 6500 LBS. PLEASE ADVISE ME IF THIS IS CORRECT.

NHTSA ID

11179952

Incident

Oct 30, 2016

IN MOTION, PULLING INTO PARKING STALL, WHEN SOMETHING STARTED TO SMELL LIKE IT WAS ON FIRE, STARTED TO SEE FLAMES COMING FROM MOTOR. CAR CAUGHT ON FIRE. POLICE CASE #19-0773 *DT *DT*JB

NHTSA ID

11170646

Incident

Jan 17, 2019