2017 Nissan Rogue Suspension Problems

Component: Suspension: Front: Control Arm: Left Lower Arm Description: While operating the vehicle at approximately 5 mph, the left (drivers' side) front lower control arm suffered a catastrophic structural material failure, snapping completely into two parts by the ball joint without warning. The structural failure caused the front wheel assembly to collapse outward, ripping the axle out of the transmission and immediately severing steering control and braking. The vehicle immediately pulled to the left and came to a complete stop. The sudden loss of vehicular control created an immediate, severe safety hazard on a public roadway. Considering that 10 minutes prior, the vehicle was traveling at interstate highway speeds; lives were possibly saved by the failure at the point in time it did fail. The left fender was also damaged and blocked, exiting from the driver's side door. There was also damage to the struts as well as damage to the stabilizer bars on the struts. The axle was also disengaged from the transmission as well. Inspection of the failed component reveals a complete cross-sectional fracture of the metal housing, which represents a severe structural manufacturing or metallurgical defect. The failed component and photographic evidence have been preserved for engineering analysis. The AAA Service Center confirmed the issue in the repair invoice and a secondary email from the service center elaborated on the issue. No other representatives have inspected the component since the incident. There were no issues prior to the failure, but the vehicle had to be previously towed on 06/02/2026 due to a battery fuse assembly that was preventing the vehicle immobilizer from disengaging. The tow required skids since the front wheels were locked in place and there was no way to disable them. The tow was provided by AAA on 6/1/26 to my local Nissan Dealership. On 6/2/26 a diagnostic and a multipoint inspection was completed and the fuse assembly was replaced.

NHTSA ID

11753300

Incident

Jul 5, 2026

Mileage

121,902 mi

Shortly after purchasing the vehicle, the airbag warning light illuminated. I took the vehicle to a Nissan dealership in Texas for diagnosis. The technician confirmed that the airbag fault was present before the vehicle was sold to me. According to the diagnostic records, the selling dealer (Kelly Nissan in Oak Lawn, Illinois) had previously scanned the airbag system, identified an airbag fault code, cleared the code without performing the repair, and then proceeded to sell the vehicle. This means the airbag defect existed at the time of sale and was intentionally or negligently undisclosed. The system continues to show a malfunction indicator, and the Clay Cooley Nissan dealership in Richardson, Texas identified the issue as an electrical airbag system failure requiring a repair estimated at $2,304.15. This defect affects the Supplemental Restraint System (SRS), which may result in: Airbags failing to deploy during a crash Improper deployment Increased risk of injury or death The vehicle is unsafe to drive in its current condition. The selling dealer refuses to authorize repair outside Illinois, leaving me with an unsafe vehicle that cannot be feasibly transported. Nissan Corporate states this is the dealer's responsibility and will not intervene. Given that this defect relates directly to the federally regulated airbag safety system, I am requesting NHTSA’s investigation into whether this represents a broader issue of airbag system defects or improper clearing of airbag fault codes prior to sale by the dealer.

NHTSA ID

11704078

Incident

Dec 2, 2025

Car was hit

NHTSA ID

11690055

Incident

Apr 9, 2021

I was informed by a Nissan dealership over 3 years ago that both inner tie rods on my 2017 Nissan Rogue have play in them. The vehicle had less then 30,000 miles on it and was never in an accident nor was it ever driven off roads. They told me it would cost over $2,000.00 to make the repair because the tie rods were part of the power steering rack. In other words to replace the inner tie rods they had to replace the power steering rack as well. The vehicle was manufactured in Korea. I complained that this failure in the tie rods had to be a manufacturing defect but Nissan refused to cover the repair because my three year new car warranty expired. I just recently read that the NHTSA in August 5th of 2024 began an investigation on this matter with the 2021 model year Nissan Rogue SUV. I believe this matter is just not for the 2021 model year but at least model year 2017.

NHTSA ID

11614423

Incident

Jul 15, 2021

Check engine light P0776 Pressure control sol B. Recommend replace CVT unit due to internal failure. Mileage: 109,422 This vehicle was covered by the extended warranty to 84 months or 84,000 miles. It failed at 109.422 miles. This is shocking and unacceptable and expensive! Approximately $6,000 to repair/replace transmission which made the vehicle more costly than its trade in value. Repair estimate performed by South Austin Nissan. Contacted manufacturer and was referred to the Kbb class action website for information.

NHTSA ID

11536761

Incident

Jul 31, 2023

The front engine sub-frame bushings separated at 63,339 miles. No warning just vibration in engine compartment. This could potentially affect handling steering. The subframe has been replaced by a Nissan dealership.

NHTSA ID

11476500

Incident

Jul 23, 2022

Heat shield over muffler fell of vehicle (from corrosion of bolts and nuts) exposing rear cargo area (contains spare tire and other components) to excessive heat.

NHTSA ID

11474185

Incident

Jun 30, 2022

The contact owns a 2017 Nissan Rogue. The contact stated that while driving at an undisclosed speed, the vehicle made abnormally loud sounds. The vehicle was taken to an independent mechanic, who diagnosed that the lower control arm bushings and the front driver's side shocks were faulty. The lower control arm bushings and the front driver's side shocks needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but informed the contact that the VIN was not included in any recalls and that the suspension was not under warranty. The failure mileage was approximately 55,000.

NHTSA ID

11441455

Incident

Nov 23, 2020

Mileage

55,000 mi

IF THIS FEEDBACK GOES TO MAIN CORPORATE I WILL BE GLAD TO SHARE MY EXPERIENCE.I HAVE BEEN TRYING TO GET A BETTER SERVICE FROM NISSAN. BOUGHT MY NEW NISSAN 2017 ON DECEMBER 29TH 2017 AND I HAVE BEEN TO THE SERVICE DEPARTMENT SEVERAL TIME IN 2018 AND 2019 AND FOR A PROOF YOU GUYS CAN ACCESS THE REPAIR LOG. EVERY TIME THEY HAVE BEEN CHANGING PARTS AND I FEEL THAT THIS CAR IS HAS RECALL OR THEY HAVE SOLD ME THE WORST DEFECTIVE ONE. AFTER TALKING TO WARRANTY DEPARTMENT AS IT HAS BEEN 14000 MILES SERVICE DUE, REQUESTED THEM ALSO TO PROVIDE APPRAISAL. IT WAS DEVASTATING AND UPSETTING ON TALKING TO THE SALES DIRECTOR HE HAS APPRAISED MY CAR $17000 , AS I HAVE PAID $31000 LESS THAN 15K MILES ASKED HIM HOW COME THAT UPSETTING PRICE. HE TOLD ME THATS WHAT THEY CAN OFFER. LEARNED LESSON THAT NISSAN CARS ARE THE WORST AND THEY HAVE NO VALUE EVEN THOUGH THE CAR IS BRAND NEW LESS THAN A YEAR MODEL. NEVER EVER RECOMMEND TO ANYONE

NHTSA ID

11186337

Incident

Feb 1, 2019

Mileage

13,500 mi

MY VEHICLE EVERYTIME I MAKE A STOP THE SEAT MOVES . ALSO WHEN I WANT TO CHANGE LANENS FAST THE CAR GOES CRAZY . ALSO WHEN DRIVING YOU COULD HEAR A NOISE IN TBE WHEELS .

NHTSA ID

11165545

Incident

Jan 18, 2018

MY ROUGE HAS HAD VIBRATION PROBLEMS SINCE MY FIRST OIL CHANGE. I BOUGHT THE CAR NEW IN DEC.. 2017. TODAY 10/ 26/ 2018 I SMELL SOMETHING BURNING THREW MY VENTS, & WHEN IT RAINS OR THE AIR IS DAMP MY BRAKES WHISTLE. IS A NEW CAR NEW ANYMORE? PLEASE MAKE NEW, NEW. NO SURE ON DATES. & MILES.

NHTSA ID

11143011

Incident

May 8, 2018

Mileage

1,220 mi