RoadVitals

2008 Orion Vii Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
11
Newest May 15, 2015
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
1 investigation on file

Recall campaigns

11 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

15V288000

ENGINE AND ENGINE COOLING:ENGINE

May 15, 2015
455 units potentially affected
The defect: Daimler Buses North America (DBNA) is recalling certain model year 2007-2012 Orion VII natural gas-powered transit buses manufactured January 1, 2007, to October 1, 2012. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces.
The risk: If the engine oil comes into contact with hot surfaces, it can increase the risk of a vehicle fire.
The remedy: Cummins will notify owners on behalf of DBNA, and dealers will secure the ends of the 90-degree elbow. In addition, the electronic control module (ECM) will be reprogrammed with software that can adjust the engine output under misfire conditions to limit crankcase pressures. These repairs will be performed free of charge. The recall began on June 12, 2015. Owners may contact DBNA at 1-905-403-7807 or Cummins Inc. at 1-800-343-7357.
Daimler Buses North AmericaView on NHTSA.gov
14V106000

ENGINE AND ENGINE COOLING:ENGINE

Mar 5, 2014
455 units potentially affected
The defect: Daimler Buses North America (DBNA) is recalling certain model year 2007-2012 Orion VII transit buses manufactured January 2007 through October 2012 equipped with certain Cummins Westport Model ISL G engines. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor.
The risk: The improper operation of the sensor could induce elevated exhaust temperatures or flames from the exhaust pipe, increasing the risk of a vehicle fire or burn injury to a person near the exhaust pipe.
The remedy: Cummins Inc. and Cummins Wesport Inc. will notify owners, and authorized Cummins service facilities will upload a new ECM calibration, free of charge. The recall began on April 12, 2014. Owners may contact DBNA at 1-905-403-7807 or Cummins Inc. at 1-800-343-7357. Cummins' number for this recall is C1462 (for ISL G engines) or C1461 (for ISX12 G) engines.
Daimler Buses North AmericaView on NHTSA.gov
13V476000

ELECTRICAL SYSTEM

Sep 27, 2013
3,009 units potentially affected
The defect: Daimler Buses North America Ltd. (DBNA) is recalling certain model year 2003-2008 Orion V and model year 2002-2010 VII buses equipped with Sure Power equalizers and DC-DC Converters. The specific potting compound used in the equalizers and convertors for insulation was found to be capable of conducting electricity after being exposed to heat.
The risk: Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.
The remedy: DBNA will notify owners and Sure Power representatives will change out the equalizer and/or convertor, free of charge. The recall is expected to begin during November 2014. Owners may contact DBNA at 1-905-403-1111.
Daimler Buses North AmericaView on NHTSA.gov
11V214000

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Apr 1, 2011
2 units potentially affected
The defect: DAIMLER BUSES IS RECALLING CERTAIN MODEL YEAR 2008 ORION VII TRANSIT BUSES MANUFACTURED FROM JUNE 13-16, 2008, AND EQUIPPED WITH TEETER LEVER ASSEMBLIES. THERE IS INSUFFICIENT ENGAGEMENT BETWEEN THE TEETER LEVER BASE AND THE CAM PLATE.
The risk: FAILURE OF THE TEETER LEVER ASSEMBLY WILL CAUSE THE REAR SIDE EXIT DOOR TO OPERATE IMPROPERLY. A PASSENGER LEANING ON OR FORCED AGAINST THE DOOR COULD FALL THROUGH THE DOOR AND SUSTAIN INJURIES.
The remedy: DAIMLER BUSES IS WORKING WITH VAPOR BUS TO REPAIR THE AFFECTED BUSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 29, 2011. OWNERS MAY CONTACT DAIMLER BUSES AT 1-800-716-7566.
DAIMLER BUSES NORTH AMERICA, INC.Manufacturer number VBI # 2011-01View on NHTSA.gov
10V015000

POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)

Jan 21, 2010
426 units potentially affected
The defect: DAIMLER BUSES IS RECALLING CERTAIN ORION TRANSIT BUSES EQUIPPED WITH THE MORSE REMOTE THROTTLE CONTROL. THE MORSE REMOTE THROTTLE CONTROL PANEL IS LOCATED IN THE ENGINE COMPARTMENT AND A SWITCH ON IT IS LABELED, "THROTTLE"; "OFF" OR "FRONT" AND "ON" OR "REAR" SELECTING THE ACTIVE ENGINE CONTROL STATION. IF A PERSON OPERATING THE ENGINE FROM THE "REAR" POSITION (AT THE ENGINE) FAILS TO PLACE THE SWITCH IN THE "OFF" OR "FRONT" POSITION AND THE ENGINE RPM WAS SET TO ABOVE IDLE DURING MAINTENANCE FOR EXAMPLE, WHEN THE BUS IS STARTED FROM THE DRIVER'S STATION THE ENGINE COULD CHANGE TO THE HIGHER RPM RESULTING IN UNWANTED ENGINE POWER.
The risk: THE BUS COULD ACCELERATE AT A HIGHER RATE THAN ANTICIPATED INCREASING THE RISK OF A CRASH.
The remedy: DAIMLER WILL PROVIDE INSTRUCTIONS TO MODIFY THE WIRING TO THE MORSE THROTTLE CONTROL SWITCH. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 1, 2010. OWNERS MAY CONTACT DAIMLER BUSES AT 1-800-716-7466.
DAIMLER BUSES NORTH AMERICA, INC.View on NHTSA.gov
09V413000

INTERIOR LIGHTING

Oct 20, 2009
368 units potentially affected
The defect: DAIMLER BUSES OF NORTH AMERICA IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 ORION TRANSIT BUSES EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.
The risk: A SHORT COULD OCCUR, POSSIBLY CAUSING SMOKE AND A FIRE.
The remedy: ORION WILL NOTIFY OWNERS AND THE BUSES WILL BE REPAIRED BY LUMINATOR FREE OF CHARGE. PLEASE SEE LUMINATOR'S DEFECT REPORT 09E-054. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2009. OWNERS MAY CONTACT LUMINATOR AT 1-972-516-3033 OR ORION AT 1-800-716-7466.
DAIMLER BUSES NORTH AMERICA, INC.View on NHTSA.gov
09V318000

VISIBILITY:GLASS, SIDE/REAR

Aug 7, 2009
824 units potentially affected
The defect: DAIMLER BUS NORTH AMERICA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 ORION VII TRANSIT BUSES MANUFACTURED FROM DECEMBER 2007 THROUGH JULY 2009. THE PASSENGER WINDOWS HAVE A TIP-IN TRANSOM WINDOW WHICH IS ATTACHED BY SCREWS. THESE SCREWS MAY LOOSEN AND THE WINDOW MAY DISLODGE AND FALL INTO THE BUS.
The risk: A COLLAPSING WINDOW COULD INJURE PASSENGERS.
The remedy: AN INTERIM NOTICE WAS SENT TO OWNERS ON OCTOBER 21, 2009 INSTRUCTING THEM TO CHECK THAT THE SCREWS ARE PROPERLY TIGHTENED AND TO INSPECT THEM PERIODICALLY. A PERMANENT REPAIR IS NOW AVAILABLE AND OWNERS WILL BE PROVIDED INSTRUCTIONS TO REPAIR THE BUSES FREE OF CHARGE. AN OWNER NOTIFICATION ADVISING OWNERS ABOUT THE PERMANENT FREE REMEDY WILL BE MAILED ON OR ABOUT AUGUST 27, 2010. OWNERS MAY CONTACT DAIMLER BUSES NORTH AMERICA AT 1-800-716-7466.
DAIMLER BUSES NORTH AMERICA, INC.View on NHTSA.gov
09V215000

VISIBILITY:GLASS, SIDE/REAR

Jun 11, 2009
286 units potentially affected
The defect: ORION IS RECALLING 286 MODEL YEAR 2007 THROUGH 2009 TRANSIT BUSES MANUFACTURED BETWEEN DECEMBER 2007 AND APRIL 2009. THE BOND OF THE GLASS TO THE ALUMINUM FRAME OF THE PASSENGER WINDOWS IS NOT ADEQUATE ENOUGH TO HOLD THE WINDOW ATTACHED TO THE FRAME.
The risk: THE WINDOW COULD DISLODGE FROM THE BUS WHILE IN OPERATION, POSSIBLY BECOMING A ROAD HAZARD TO OTHER MOTORISTS WHICH COULD RESULT IN A VEHICLE CRASH.
The remedy: ORION WILL NOTIFY OWNERS AND THE MOVING WINDOW PORTION WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JULY 15, 2009. OWNERS MAY CONTACT HEHR INTERNATIONAL AT 1-989-845-3067 OR ORION AT 1-800-716-7466.
DAIMLER BUSES NORTH AMERICA, INC.Manufacturer number 09-182View on NHTSA.gov
09V121000

ELECTRICAL SYSTEM

Apr 15, 2009
380 units potentially affected
The defect: DAIMLER BUSES IS RECALLING 380 MY 2008-2009 VII BUSES CONFIGURED WITH A MOBILE CLIMATE CONTROL (MCC) HEATER AND THOSE WITH A MCC DEFROSTER MANUFACTURER FROM OCTOBER 2008 - MARCH 2009 ONLY. THE BLOWER MOTOR MOUNT SCREWS MAY NOT HAVE THE PROPER TORQUE. IF THE FOUR BLOWER MOTOR MOUNT SCREWS DISCONNECT, THE BRACKET CAN MOVE POSSIBLY CAUSING AN ELECTRICAL TERMINAL SHORT CIRCUIT.
The risk: A SHORT CIRCUIT CAN RESULT IN A FIRE.
The remedy: MCC WILL INSPECT THE BUSES FOR INCORRECT TORQUE ON BLOWER MOUNTS AND TORQUE THE SCREWS CORRECTLY AS REQUIRED FREE OF CHARGE. IF THE INSPECTION REVEALS ANY DAMAGE TO THE AFFECTED COMPONENTS, ADDITIONAL REPAIRS WILL BE MADE AS NECESSAY. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT DAIMLER BUSES AT 905-403-7807.
DAIMLER BUSES NORTH AMERICA, INC.View on NHTSA.gov
09V099000

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Mar 25, 2009
804 units potentially affected
The defect: DAIMLER BUS IS RECALLING 804 MY 2006-2009 TRANSIT BUSES EQUIPPED WITH A NEW YORK CUSTOM SEAT HEATER. CURRENTLY, THE TERMINAL CONNECTION OF THE SEAT HEATER IS IMMEDIATELY LOCATED NEXT TO THE SEAT BUS BAR. SHOULD CONDUCTIVE MATERIAL OR DEBRIS, SUCH AS A WASHER, ENTER BETWEEN THE TERMINAL CONNECTION AND THE SEAT BUS BAR, A SHORT CIRCUIT COULD OCCUR.
The risk: A SHORT CIRCUIT BETWEEN THE SEAT BUS BAR AND THE ADJACENT TERMINAL CONNECTION COULD OVERHEAT THE WIRE, POSSIBLY RESULTING IN A FIRE.
The remedy: DEALERS WILL INSPECT BUSES FOR DEBRIS AND WILL RELOCATE THE TERMINAL CONNECTION AWAY FROM THE BUS BAR. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT DAIMLER BUSES AT 905-403-7807.
DAIMLER BUSES NORTH AMERICA, INC.View on NHTSA.gov
08V480000

ENGINE AND ENGINE COOLING:ENGINE:DIESEL

Sep 29, 2008
175 units potentially affected
The defect: DAIMLER BUSES IS RECALLING 175 MY 2004-2008 ORION V AND VII BUSES EQUIPPED WITH A CUMMINS ISL DIESEL ENGINES. DUE TO VARIOUS ALTERNATOR CABLE ROUTING CONFIGURATIONS, IT MAY BE POSSIBLE FOR THE CABLE TO RUB ON ENGINE COMPONENTS.
The risk: WHEN THE CABLE RUBBING IS NOT DETECTED DURING REGULAR MAINTENANCE INSPECTIONS, THE INSULATION CAN RUB TO EXPOSE THE ELECTRIFIED CABLE. ARCING CAN CAUSE A FIRE TO OCCUR.
The remedy: DAIMLER BUSES WILL REROUTE THE ALTERNATOR CABLE TO ENSURE THAT THE CABLE DOES NOT CONTACT ENGINE COMPONENTS. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 2009. OWNERS MAY CONTACT DAIMLER BUSES AT 1-800-716-7466.
DAIMLER BUSES NORTH AMERICA, INC.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

EQ09007ClosedInvestigation

FALLING BUS WINDOWS

Opened Aug 18, 2009
Closed Nov 24, 2009

THE PURPOSE OF THIS INVESTIGATION WAS TO DETERMINE WHETHER THE TIP-IN STYLE TRANSOM WINDOWS SUPPLIED TO DAIMLER BUSES FOR USE ON BUSES IT MANUFACTURED, AND CONCERNING WHICH THAT COMPANY MADE A DEFECT DETERMINATION, WERE SUPPLIED TO ANY OTHER VEHICLE MANUFACTURERS OR AS REPLACEMENT EQUIPMENT AND, IF SO, TO PROMPT ADDITIONAL SAFETY RECALLS IF AND WHERE NEEDED.RMD ISSUED A REQUEST FOR INFORMATION TO THE WINDOWS' MANUFACTURER, HEHR INTERNATIONAL, INC. (HEHR) ON SEPTEMBER 2, 2009, INQUIRING ABOUT ITS DISTRIBUTION OF THE WINDOWS AND SOLICITING ITS OPINION AS TO WHETHER A SAFETY DEFECT EXISTED IN THOSE WINDOWS.HEHR RESPONDED ON OCTOBER 28, 2009, THAT IT HAD NOT SUPPLIED THE WINDOWS TO ANYONE OTHER THAN DAIMLER BUSES.IT ALSO OPINED THAT THE WINDOWS DID NOT CONTAIN A SAFETY DEFECT AND THAT ANY SCREW LOOSENING, AND CONSEQUENTIAL WINDOW COLLAPSE, WOULD BE DUE TO A FAILURE TO PROPERLY RETIGHTEN A SCREW AFTER MAINTENANCE, AS OPPOSED TO A DEFECT INHERENT TO THE DESIGN OR MANUFACTURE OF THE SCREWS OR WINDOWS.IN SUPPORT OF ITS OPINION, IT PROVIDED A SUMMARY OF HISTORICAL FIELD DATA AND ITS FIELD INSPECTION INVESTIGATION, NEITHER OF WHICH DEMONSTRATED ABERRANT PERFORMANCE.IT ALSO PROVIDED A SUMMARY OF TESTING CONDUCTED BY AN INDEPENDENT TESTING FACILITY DEMONSTRATING THAT THE SCREWS WOULD NOT LOOSEN AS MANUFACTURED. IN VIEW OF HEHR'S RESPONSE AND THE INFORMATION PROVIDED THEREIN, THIS INVESTIGATION IS CLOSED.

VISIBILITY:GLASS, SIDE/REAR

Elsewhere on this vehicle

Data sources