RoadVitals

2001 Pierce Custom Chassis Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Newest Oct 5, 2007
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

2 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

07V470000

SUSPENSION:FRONT:CONTROL ARM

Oct 5, 2007
2,604 units potentially affected
The defect: ON CERTAIN FIRE TRUCKS EQUIPPED WITH AN INDEPENDENT FRONT SUSPENSION, A PITMAN ARM MIGHT FRACTURE UNDER SEVERE LOAD CAUSED BY THREE LOADING CONDITIONS. IN ALL CASES, THE FRONT AXLE MUST BE TURNED FULL LEFT OR RIGHT WHILE (1) SIMULTANEOUSLY BACKING UP AND BRAKING HARD, (2) DRIVING ONE WHEEL OVER OR AGAINST A CURB OR (3) STEERING THE FRONT AXLE FULL LEFT OR RIGHT WHEN THE VEHICLE IS STATIONARY WITH THE SERVICE BRAKE APPLIED. THESE ARE ALL LOW OR NO -SPEED EVENTS.
The risk: SUCH A BREAK COULD LEAD TO THE SUSPENSION LOSING ONE OF ITS ANCHOR POINTS, THEREBY POTENTIALLY CAUSING LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNING WHICH COULD RESULT IN A CRASH.
The remedy: DEALERS WILL REPLACE THE ORIGINAL PITMAN ARMS WITH PITMAN ARMS MADE OF HIGHER STRENGTH MATERIAL. THE RECALL BEGAN ON OCTOBER 29, 2007. OWNERS MAY CONTACT PIERCE AT 920-832-3000.
PIERCE MANUFACTURINGView on NHTSA.gov
03V380000

STEERING:LINKAGES:TIE ROD ASSEMBLY

Oct 8, 2003
202 units potentially affected
The defect: ON CERTAIN FIRE TRUCKS WITH TANDEM STEER AXLES. THE TRW TIE-ROD ON THE REAR-MOST AXLE OF A TANDEM AXLE IS RESTRAINED FROM ROTATIONAL MOVEMENT BY A PAIR OF ANTI-ROTATION SEALS LOCATED AT THE BALL SOCKET JOINTS. THESE ANTI-ROTATION SEALS WILL COMPRESS OVER TIME. IF THE ANTI-ROTATION SEAL ALLOWS TOO MUCH MOTION, THE SEALS CAN DETERIORATE, ALLOWING CONTACT BETWEEN THE BALL SOCKET AND THE BALL SHAFT. THIS METAL-TO-METAL CONTACT WILL TRANSMIT FORCES INTO THE TIE-ROD TUBE, CAUSING FATIGUE FAILURE INITIATING AT THE ROOT OF THE FEMALE TREADS.
The risk: FAILURE OF THE TIE-ROD WILL ALLOW ONE OF THE WHEELS TO SWING TO THE LIMIT OF ITS STEERING STOP, POTENTIALLY CAUSING A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL REPLACE THE TIE ROD. NOTIFICATION TO OWNERS BEGAN NOVEMBER 7, 2003. OWNERS SHOULD CONTACT PIERCE AT 1-888-974-3723.
PIERCE MANUFACTURINGView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources