1994 Pontiac Bonneville Body & structure Problems

1994 PONTIAC BONNEVILLE. DUE TO CORROSION THE ENGINE CRADLE BOLTS / MOUNTING FAILED AND ENGINE FELL OUT OF CAR. LUCKILY IT WAS WHILE TURNING AROUND IN THE DRIVEWAY, IF IT HAD HAPPENED ON / AT ROAD SPEEDS THERE COULD EASILY HAVE BEEN LOSS OF STEERING CONTROL, MULTI CAR INVOLVEMENT, INJURIES, OR LOSS OF LIFE. GM SERVICE OFFERED ZERO HELP ON RECALL OR SERVICE BULLETIN INFORMATION AND DENIED ANY RESPONSIBILITY FOR DEFECT OR REPAIR. *TR

NHTSA ID

10239501

Incident

Aug 8, 2008

Mileage

150,000 mi

DT*: THE CONTACT STATED WHILE DRIVING AT 25 MPH, THE REAR ENGINE CRADLE BOLT AND RETAINER PULLED THROUGH THE CRADLE. THE REAR CRADLE DROPPED TO THE GROUND AND THE STEERING SEPARATED. THIS RESULTED IN A LOSS OF CONTROL OF THE VEHICLE. IT WAS PUSHED OUT OF THE ROAD, AND TOWED TO THE RESIDENCE. THE CONTACT VERBALLY SPOKE WITH AN INDEPENDENT REPAIR MECHANIC ABOUT THE PROBLEM WHO SUGGESTED THE VEHICLE BE BROUGHT IN FOR INSPECTION. *JB

NHTSA ID

10147708

Incident

Jan 9, 2006

Mileage

160,000 mi

DT: THE CONTACT OWNS A 1994 PONTIAC BONNEVILLE. THE ENGINE FELL OUT OF THE VEHICLE IN JUNE OF 2005 WHILE SLOWLY PULLING OUT FROM A STOP LIGHT. HE HEARD A LOUD CLUNK AND LOST STEERING CONTROL AND THE CAR DRIFTED TO THE CURB AND STOPPED. THE GM MANUFACTURER WANTED TO KNOW HOW THE VEHICLE WAS MAINTAINED. WHEN THE MANUFACTURER FOUND OUT THAT THEY DONE ALMOST ALL THE MAINTENANCE THEY TOLD HER THAT THE VEHICLE WAS TEN YEARS OLD. SHE UNDERSTOOD THIS, BUT SHE STILL FELT THAT AN ENGINE SHOULD NOT JUST FALL OUT OF A VEHICLE. HER PRIMARY CONCERN WAS TO MAKE NHTSA AND THE MANUFACTURER AWARE OF THIS PROBLEM BECAUSE IF DRIVING AT A HIGH SPEED AND THIS HAPPENED THEN YOU WOULD LOSE ALL STEERING CAPABILITIES . THIS WAS A SAFETY ISSUE. THE VEHICLE WAS REPAIRED AT A REPAIR SHOP AND THE REPAIR SHOP TOLD HER THAT THEY HAD A FORD TAURUS THAT HAD THE SAME PROBLEM. ALSO, ANOTHER DEALERSHIP TOLD HER THAT THEY HAD A DODGE INTREPID WITH THE SAME PROBLEM . THERE IS A FRAME THAT HOLDS THE ENGINE AND TRANSMISSION TO THE BODY OF THE CAR. THERE IS A LARGE THREE INCH DIAMETER WASHER THAT IS UNDER A METRIC .5 INCH DIAMETER BOLT. THE BOLT DID NOT FAIL, BUT THE WASHER DID FAIL. THERE ARE FOUR BOLTS IN THE REAR AND TWO BOLTS IN THE FRONT, AND THE TWO IN THE FRONT WERE OKAY, BUT THE FOUR IN THE REAR BROKE AWAY AND FAILED. THE GM BUSHING PART NUMBER IS 25536051 FOR THE FRONT TWO BOLTS.*AK UPDATED 01/19/06. *JB

NHTSA ID

10137249

Incident

Jun 1, 2005

Mileage

14,525 mi

TURNING INTO STREET WHEN THE ENGINE CRADLE FELL OUT IN THE REAR. LOSS OF ALL STEERING. HAD A CUTLASS SUPREME THAT DID THAT ALSO EXCEPT THERE WAS A RECALL. HUGE SAFETY HAZARD, A VEHICLE GOING DOWN THE ROAD NO STEERING??? WHAT WOULD HAVE HAPPENED IF I WAS NOT FAMILIAR WITH THIS IN THE FIRST PLACE. GM NEEDS A RECALL ON THIS. *JB

NHTSA ID

10135775

Incident

Sep 7, 2005

DT: CONTACT STATES: THE CRADLE FELL OFF THE VEHICLE WHICH HELD THE SUSPENSION UP IN THE FRONT. THERE WERE FOUR BOLTS HOLDING IT UP, AND THE WASHERS RUSTED, CAUSING THIS FAILURE. DEALER SAID THEY HAD NOT SEEN THAT HAPPEN. THEY HAVE AGREED TO FIX IT ALL AT CONSUMER'S COST. CONTACT COMPLAINED TO GM, AND WAS TOLD THE CAR WAS TOO OLD.*AK

NHTSA ID

10125860

Incident

Jun 15, 2005

Mileage

150,000 mi

FRAME HAS RUSTED OUT WHERE THE A-FRAME ATTACHES. *AK

NHTSA ID

10102276

Incident

Dec 4, 2004

Mileage

156,000 mi

1. NOISE FROM FRONT END OF VEHICLE 2. BOLTS HOLDING MOTOR TO K FRAME SNAPPED DROPPING MOTOR TO THE GROUND - LOST CONTROL OF STEERING - CAR HAS NEVER HAD SERIOUS PROBLEMS.*AK 3. TOWED FOR SERVICE - COURSE OF ACTION PENDING.

NHTSA ID

10086943

Incident

Aug 15, 2004

Mileage

88,000 mi

I WAS EXITING OFF ROUTE 82 AND HEADING EAST ON RT. 422 GOING ABOUT 30 MPH. EST. WHEN I HEARD A LOUD BANG SOUND. THE STEERING AND THE BRAKES WENT OUT AND THE CAR WAS OUT OF CONTROL. THE CAR CAME TO REST ABOUT 50 FT. AFTER THE CAR HIT A CONCRETE BARRIER. OHIO HIGHWAY STATE PATROL MADE A CRASH REPORT AND THE CAR WAS TOWED TO GREENWOOD AUTOBODY DEALERSHIP. THEY SAID THE ENGINE CRADLE BOLTS BROKE OUT THE FRAME. ALLOWING THE ENGINE AND DRIVE TRAIN TO DROP ON THE ROAD. DAMAGE IS BEING ESTIMATED BY THE AUTOBODY SHOP AND INSURANCE COMPANY. CAR HAS NOT BEEN REPAIRED YET.

NHTSA ID

10073175

Incident

May 25, 2004

Mileage

127,000 mi

TRACTION CONTROL SYSTEM WAS INSTALLED INTO VEHICLE, IT WAS NOT INSTALLED AT TIME OF ASSEMBLY. *YC

NHTSA ID

547891

Incident

Sep 23, 1994