2004 Pontiac Montana Problems

HIS NAME AS WELL. *TR

REPEATED DRIVING WITHIN 1/4 MILE OF THE INDIANAPOLIS REGIONAL AIR TRAFFIC CONTROL RADAR ANTENNA CAUSES SOME OF THE INSTRUMENT PANEL FAILURE INDICATORS TO TURN ON FOR SEVERAL SECONDS. THE "BATTERY" AND "AIRBAG" INDICATORS TURN ON AND CLICKING NOISE IS HEARD FROM THE INSTRUMENT PANEL. THE LAMP INDICATIONS ARE ABOUT THE SAME AS WHEN THE ENGINE IS FIRST STARTED. MY CONCERN IS THAT THIS MAY BE DOING DAMAGE TO THE COMPUTER WHICH COULD RESULT IN A FUTURE FAILURE. *TR

PUTTING GAS IN TANK AND IT JUST STARTED POURING OUT FROM UNDER THE VAN. THIS HAPPEN AT A GAS STATION AND I WORRIED ABOUT AN EXPLOSION.

TL* THE CONTACT OWNS A 2004 PONTIAC MONTANA. WHILE DRIVING APPROXIMATELY 25 MPH, A NOISE EMERGED FROM UNDER THE VEHICLE AND A STRONG ODOR OF FUEL WAS PRESENT. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD. WHENEVER THE VEHICLE WAS STARTED, THE STRONG ODOR WAS PREVALENT AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 151,613. UPDATED 09/27/16*LJ *CN

I HAVE A 2004 PONTIAC MONTANA VAN WITH A PASSENGER SIDE POWER SLIDING DOOR. MY GRANDSON PUSHED THE POWER BUTTON WHILE I WAS IN THE DOORWAY AND THE DOOR SQUASHED ME PRETTY HARD, NO BRUISES OR INJURIES THOUGH. IT CONCERNED ME BECAUSE I HAVE YOUNG GRANDCHILDREN. I PLAYED WITH THE DOOR TO SEE HOW MUCH FORCE IT TAKES TO STOP IT WITH MY HAND. I HAD TO PUSH HARD AND IT PUSHED ME BACKWARDS A WAYS BEFORE I COULD STOP IT. I TOOK IT TO THE DEALER AND THEY REPROGRAMMED THE DOOR, WHICH DID NOTHING TO FIX THE PROBLEM. THE NEXT DAY AFTER READING THE MANUAL THAT SAID IT TAKES MORE FORCE TO STOP IT THE MORE CLOSED THE DOOR IS, I PLAYED WITH IT SOME MORE BUT THIS TIME I COULDN'T REVERSE THE DOOR AT ALL WITH MY HAND PUSHING AGAINST IT WITH ALL MY WEIGHT, STARTING WHEN THE DOOR WAS FULLY OPEN. I THEN STUCK A PENCIL IN THE OPENING, WHICH THE DAY BEFORE WAS ABLE TO REVERSE THE DOOR THOUGH IT DID PUT A GOOD DENT IN THE WOOD. THIS TIME IT SNAPPED THE PENCIL IN TWO AND HALF WAS COMPLETELY SHUT INTO THE DOOR. I SHUDDER TO THINK WHAT THIS WOULD DO TO MY LITTLE 18 MONTH OLD GRANDDAUGHTHER'S FINGERS. THE SERVICE CENTER WAS VERY NICE BUT THEIR HANDS ARE TIED BECAUSE SUPPOSEDLY, THIS IS HOW THIS DOOR WORKS. THE SERVICE CENTER TRIED OTHER DOORS OF THE SAME MODEL AS MINE AND THEY ALL WORKED LIKE MINE. I EXPERIMENTED WITH A FRIEND'S HONDA ODYSSEY POWER DOOR AND IT STOPPED MUCH EASIER. THIS IS NOT SAFE! I DISABLED THE DOOR WITH THE OVERHEAD BUTTON FOR THE SAKE OF MY GRANDCHILDREN SO BASICALLY I PAID FOR A FEATURE THAT I DON'T DARE USE.

AUTOMATIC SLIDING PASSENGER DOOR WILL CLOSE ON ANYTHING IN IT'S PATH. IT TAKES WAY TOO MUCH PRESSURE TO FORCE THE DOOR BACK WHEN IT IS CLOSING ON SOMETHING. I'VE HAD IT CLOSE ON MY HAND (VERY PAINFUL) AND MY 5 YR OLD GOT HER ARM CAUGHT IN IT, SHE HAD A VERY BAD BRUISE ACROSS THE UPPER PART OF HER ARM. JUST GRATEFUL IT WASN'T BROKEN. I CAN'T BELIEVE THIS HAS NOT BEEN PART OF A RECALL. SEEMS TO BE A WHOLE LOT MORE DANGEROUS THAN PREVIOUS RECALLS. DEALERSHIP REALLY HAS NO COMMENT OR SOLUTION WHEN THIS PROBLEM IS MENTIONED TO THEM. *NM

2004 MONTANA AIR BAGS FAILED TO DEPLOY. *TS THE VEHICLE WAS INVOLVED IN A HEAD ON COLLISION. THE CONSUMER SUSTAINED CHEST, LEG, AND CHEST INJURIES. *NM

I WAS STOPPED AT A STOP SIGN AND A TRUCK CAME FLYING AROUND THE CORNER AND HIT ME HEAD ON . MY AIR BAGS FAILED TO OPEN AND THE VAN WAS DEMOLISHED. *NM

INTAKE GASKET GOES BAD. WHILE DRIVING WITH NO WARNING

I HAVE REPLACED THE HEAD GASKET ON MY 2004 PONTIAC MONTANA EVERY YEAR AT THE SAME TIME THIS IS THE 3RD TIME I WILL HAVE TO HAVE THE GASKET REPLACED I DO BELIEVE THIS IS A RECALL ISSUE THAT SHOULD BE CORRECTED BY THE MANUFACTURER SINCE I HAVE REPLACED IT 2 TIMES PRIOR TO THIS. *TR

I PURCHASED A USES 2004 PONTIAC MONTANA ON 1/23/05 AND ON 9/21/05 AS I WAS DRIVING ON A CITY DOWNHILL STREET THE REAR AXEL BECAME DISLODGED FROM THE CAR. PIECES FELL OFF THE CAR AND JUST MISSED ONCOMING TRAFFIC. LUCKILY I WAS ONLY TRAVELING ABOUT 25 MI. PER HR. THE ROAD WAS CLEAR AND DRY. THE CAR STOPPED IMMEDIATELY. IT WAS DETERMINED THAT THE TIE ROD HOLDING THE REAR AXEL LOOKED RUSTED AND IT CRACKED. THE ROD HOLDING THE REAR AXEL IS VERY THIN METAL AND HAS DESIGNED HOLES IN IT. JUST DOESN'T LOOK LIKE WHAT SHOULD BE HOLDING A WHOLE REAR AXEL. THE ENTIRE REAR END OF THE CAR WAS REPLACED AND I HAVE BEEN DRIVING IT. I DON'T FEEL SAFE IN THE CAR. LUCKILY I DON'T LIVE WHERE SALTED ROADS ARE NECESSARY. THE NEWSPAPER ARTICLE RE: 1998-2003 FORD WINDSTAR REAR AXEL CORROSION ALERTED ME TO A CORROSION PROBLEM MAYBE WHAT HAPPENED TO ME. I DID SEND AN EMAIL TO THE NTSB AT THE TIME OF THE ACCIDENT BUT WAS NEVER CONTACTED. *TR

DT*: THE CONTACT STATED WHILE ATTEMPTING TO CLOSE THE REAR DOOR, THE BRACKET HOLDING THE PULL STRAP FRACTURED CAUSING THE CONTACT TO CUT A FINGER. THE DEALER WAS NOT CONTACTED. UPDATED 1/19/2007 -*NM

TL*THE CONTACT OWNS A 2004 PONTIAC MONTANA. THE CONTACT STATED THAT ON APRIL 6, 2010, WHILE SHE WAS DRIVING APPROXIMATELY 40 MPH, THE VEHICLE SUDDENLY ACCELERATED TO ABOUT 70 MPH. THE SERVICE ENGINE LIGHT WAS ALSO ILLUMINATED. THE CONTACT DEPRESSED THE BRAKE PEDAL WHICH STOPPED THE ACCELERATION. THE FAILURE OCCURRED ON TWO OCCASIONS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO INSPECTED THE VEHICLE. THE DEALER THEN CONTACTED THE CORPORATE OFFICE AND REQUESTED THAT AN INSPECTOR DIAGNOSE THE FAILURE. THE VEHICLE WAS AWAITING INSPECTION AT THE DEALER WHEN THE COMPLAINT WAS FILED. THE VIN WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 56,000.

DT*: THE CONTACT STATED WHILE THE VEHICLE WAS IN NEUTRAL, THE THROTTLE ENGAGED AND THE VEHICLE ACCELERATED. THE CONTACT SHIFTED THE GEAR INTO REVERSE AND BACKED INTO A TREE TO GET THE VEHICLE TO STOP. THE VEHICLE DID NOT SUSTAIN ANY DAMAGE AND THE INCIDENT HAPPENED ON PRIVATE PROPERTY, AND THEREFORE NO POLICE WERE ALERTED. THE VEHICLE IS AT THE DEALERSHIP UNDER GOING INSPECTION.

TL*- THE CONTACT OWNS A 2004 PONTIAC MONTANA, AND STATED THAT THE SEAT BELTS FRAYED WHERE THE BUCKLES WERE. CONTACT STATED THAT IT LOOKED LIKE SOMEONE HAS TRIED TO CUT THE SEAT BELTS. THE CONTACT COULD PROVIDE PICTURES IF NEEDED. THE FAILURE MILEAGE WAS 33000 AND THE CURRENT MILEAGE WAS 51000. *AK

SHOULDER CLIPS ON INTEGRATED CHILD SAFETY SEAT PULL APART WITH VERY LITTLE FORCE, WITHOUT DEPRESSING RELEASE TABS. DEALER REPLACE PART, HOWEVER, THE PROBLEM PERSISTS. DEALER STATES THAT THIS IS "NORMAL" AND THAT ALL VEHICLES THEY CHECKED DO THE SAME THING. SIMILAR CLIPS ON OTHER CHILD SAFETY SEATS (NON-INTEGRATED) THAT I CHECKED DO NOT PULL APART WITHOUT DEPRESSING RELEASE TABS. THIS IS MY SECOND COMPLAINT FILED. I WAS TOLD WITH THE FIRST COMPLAINT THAT SOMEONE WOULD FOLLOW-UP. I HAVE HEARD NOTHING IN ALMOST 1 YEAR. I AM UNABLE TO USE SEAT DUE TO FEAR OF FAILURE IF I WERE INVOLVED IN AN ACCIDENT.*AK

REAR TURN SIGNALS WORK INTERMITTENTLY. THERE IS NO DISCERNABLE TREND OR EVENT WHICH CAUSES THEM TO FAIL. BULBS ARE COMPLETELY INTACT.*CN

WHILE DRIVING AT ANY SPEED THE HEADLIGHTS FAILED INTERMITTENTLY.*AK

I PURCHASED A USES 2004 PONTIAC MONTANA ON 1/23/05 AND ON 9/21/05 AS I WAS DRIVING ON A CITY DOWNHILL STREET THE REAR AXEL BECAME DISLODGED FROM THE CAR. PIECES FELL OFF THE CAR AND JUST MISSED ONCOMING TRAFFIC. LUCKILY I WAS ONLY TRAVELING ABOUT 25 MI. PER HR. THE ROAD WAS CLEAR AND DRY. THE CAR STOPPED IMMEDIATELY. IT WAS DETERMINED THAT THE TIE ROD HOLDING THE REAR AXEL LOOKED RUSTED AND IT CRACKED. THE ROD HOLDING THE REAR AXEL IS VERY THIN METAL AND HAS DESIGNED HOLES IN IT. JUST DOESN'T LOOK LIKE WHAT SHOULD BE HOLDING A WHOLE REAR AXEL. THE ENTIRE REAR END OF THE CAR WAS REPLACED AND I HAVE BEEN DRIVING IT. I DON'T FEEL SAFE IN THE CAR. LUCKILY I DON'T LIVE WHERE SALTED ROADS ARE NECESSARY. THE NEWSPAPER ARTICLE RE: 1998-2003 FORD WINDSTAR REAR AXEL CORROSION ALERTED ME TO A CORROSION PROBLEM MAYBE WHAT HAPPENED TO ME. I DID SEND AN EMAIL TO THE NTSB AT THE TIME OF THE ACCIDENT BUT WAS NEVER CONTACTED. *TR

WHEN DRIVING OVER ANY TYPE OF DIP OR POT HOLE IN THE ROAD VEHICLE BOTTOMS OUT. *AK THE CONSUMER STATED THAT EVEN WHEN THE VEHICLE IS NOT LOADED THE INCIDENT OCCURS. *TC

DELAY WITH WINDSHIELD WIPERS, TAKE TOO LONG TO POP UP AND THAN WIPE, DESIGN SHOULD HAVE NEVER BEEN ALLOWED, THE COUPLE OF SECONDS IT TAKES FOR THE WIPERS TO MOVE FROM OFF POSITION TO WHEN YOU TURN THEM ON IS LONG ENOUGH TO CAUSE AN ACCIDENT ON A DAY AFTER IT RAINS WHERE YOU ARE PASSED BY A VEHICLE DRIVING THROUGH A PUDDLE, CANNOT SEE, AND COULD POSSIBLY INJURE SOMEBODY. CONSTANTLY LOSING POWER STEERING FLUID. TRANSMISSION WAS REPLACED ONCE DUE TO SLIPPAGE GOT IT BACK AND STARTED TO DO SO AGAIN THE FIRST 200 MILES. *TR

SAFETY HAZARD WITH 2004 PONTIAC MONTANA WITH SUN VISORS.*MR THE VANITY MIRROR INSTALLED ON THE SUNVISOR DOES NOT HAVE A COVER. WHEN THE VISOR IS USED ON SUNNY DAYS THE GLARE FROM THE SUN INTO THE MIRROR CAUSES REDUCED VISIBILITY. *NM

DELAY WITH WINDSHIELD WIPERS, TAKE TOO LONG TO POP UP AND THAN WIPE, DESIGN SHOULD HAVE NEVER BEEN ALLOWED, THE COUPLE OF SECONDS IT TAKES FOR THE WIPERS TO MOVE FROM OFF POSITION TO WHEN YOU TURN THEM ON IS LONG ENOUGH TO CAUSE AN ACCIDENT ON A DAY AFTER IT RAINS WHERE YOU ARE PASSED BY A VEHICLE DRIVING THROUGH A PUDDLE, CANNOT SEE, AND COULD POSSIBLY INJURE SOMEBODY. CONSTANTLY LOSING POWER STEERING FLUID. TRANSMISSION WAS REPLACED ONCE DUE TO SLIPPAGE GOT IT BACK AND STARTED TO DO SO AGAIN THE FIRST 200 MILES. *TR

THE ANTILOCK BRAKES KEEP GOING OUT. THE DEALERSHIP SAID THAT THIS A DESIGN FLAW AND THAT IF YOU DRIVE IN THE SNOW THE SNOW CAN GET INTO THE ABS WHEEL SENSOR AND DISABLE THE ABS AND ALL WHEEL DRIVE. THE DEALER TOLD ME THERE IS NO FIX FOR THIS AND IS A COMMON PROBLEM WITH THIS VEHICLE. *NM

HIS NAME AS WELL. *TR

I HAD A SCARY MORNING! THE DRIVER'S SEAT IN MY CAR CAUGHT FIRE THIS MORNING. I DROPPED THE KIDS OFF AT THE BABYSITTERS HOUSE AND I LEFT MY CAR RUNNING. I GO BACK OUT AND THOUGHT I SMELLED SMOKE. I THOUGHT WELL MAYBE MY SEAT HAD SOME PAPER OR SOME TRASH ON IT SO I TURNED IT OFF. I DROVE ABOUT 4 BLOCKS AND I FELT LIKE MY LEG WAS ON FIRE. SO I PULLED OVER AND I SAW THIS SMOKE COMING OUT OF MY SEAT AND ABOUT A 1-1 1/2" INCH SLIT WHERE MY SEAT HAD BEEN BURNT! SO I DROVE TO THE CAR DEALERSHIP DRIVING IN AN AWKWARD POSITION. APPARENTLY THIS HAPPENS ALL THE TIME? OR FREQUENTLY ENOUGH THAT THE SERVICE CENTER WASN'T SURPRISED WHEN I TOLD THEM MY SEAT WAS ON FIRE. I DREAD WHAT WOULD HAVE HAPPENED HAD IT BEEN MY PASSENGER SEAT AND HAD BEEN ACCIDENTALLY TURNED ON BECAUSE I HAD A STACK FULL OF PAPERS AND MAGAZINES ON IT. I HAD NOTICED THAT MY SEAT WARMER WAS GETTING EXTREMELY HOT LATELY BUT DIDN'T ATTRIBUTE IT TO A DEFECT BUT MORE TO A SENSITIVITY WITH HEAT DUE TO MY PREGNANCY. *JB

DELAY WITH WINDSHIELD WIPERS, TAKE TOO LONG TO POP UP AND THAN WIPE, DESIGN SHOULD HAVE NEVER BEEN ALLOWED, THE COUPLE OF SECONDS IT TAKES FOR THE WIPERS TO MOVE FROM OFF POSITION TO WHEN YOU TURN THEM ON IS LONG ENOUGH TO CAUSE AN ACCIDENT ON A DAY AFTER IT RAINS WHERE YOU ARE PASSED BY A VEHICLE DRIVING THROUGH A PUDDLE, CANNOT SEE, AND COULD POSSIBLY INJURE SOMEBODY. CONSTANTLY LOSING POWER STEERING FLUID. TRANSMISSION WAS REPLACED ONCE DUE TO SLIPPAGE GOT IT BACK AND STARTED TO DO SO AGAIN THE FIRST 200 MILES. *TR

THIS IS IN REGARDS TO A 2004 PONTIAC MONTANA VAN. ONCE IN A WHILE, THE VEHICLE CAN BE SHIFTED OUT OF PARK WITHOUT HAVING YOUR FOOT ON THE BRAKE, EITHER WITH ENGINE OFF OR RUNNING. EVENTS LEADING UP TO THE FAILURE ARE NORMAL. SITUATION 1: GET IN THE VAN, PUT KEY IN IGNITION, TURN KEY TO RUN POSITION (NOT START POSITION). DO NOT PUT FOOT ON THE BRAKE PEDAL. ENGINE IS NOT RUNNING. TRY TO PUT THE VAN IN GEAR (FROM PARK TO REVERSE - R). SOMETIMES, IT IS POSSIBLE TO PUT THE VAN INTO ANY GEAR EVEN THOUGH THE BRAKE PEDAL IS NOT DEPRESSED. SITUATION 2: SAME AS ABOVE EXCEPT THAT ENGINE IS STARTED NORMALLY USING THE IGNITION KEY. ONCE THE VAN IS RUNNING, TRY TO PUT THE VAN IN GEAR WITHOUT PRESSING ON THE BRAKE PEDAL. SOMETIMES, THE VAN WILL GO INTO GEAR EVEN THOUGH THE ENGINE IS RUNNING AND THE BRAKE IS NOT APPLIED. THIS SEEMS TO BE A RANDOMLY OCCURRING PROBLEM. I CANNOT FIND A PATTERN OF WHEN THIS HAPPENS VERSUS WHEN IT OPERATES PROPERLY (THAT IS, WILL NOT SHIFT INTO GEAR WITHOUT THE BRAKE APPLIED). I HAVE BEEN TESTING THIS BECAUSE I HAVE 2 SMALL CHILDREN AND DON'T WANT THEM TO BE ABLE TO PUT THE VAN IN GEAR. I HAVE BEEN TRYING TO PREVENT AN ACCIDENT BY NEVER LEAVING THE KEYS WHERE THE KIDS COULD GET TO THEM AND ALSO APPLYING THE PARKING BRAKE SO THAT THE VAN WON'T MOVE IN CASE THE KIDS EVER DID TRY TO "DRIVE" THE VAN. *TR