Owner-reported complaints naming the suspension system, filed with NHTSA
Data refreshed
Reports naming suspension components — springs, struts, shocks, control arms and related hardware. Every record below is an owner-reported complaint about the 1996 Pontiac Sunfire submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 10 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
WHEEL BEARING SEEMS TO BE GOING BAD. THE MOTOR HAS BEEN JUMPING WHEN I TAKE OFF FROM A STOP LIGHT. I THINK THE MOTOR MOUNTS MIGHT BE BAD. THE CAR IS A 96 AND IT HAS 109,000 MILES ON IT. *AK
-THE HORN ON 1996 PONTIAC SUNFIRE HAS QUIT WORKING AND BEEN REPAIRED THREE TIMES. THE PEOPLE AT THE SHOP SAID THAT IT WAS GETTING WET APPARENTLY EVERYTIME I WENT THROUGH WATER BECAUSE OF IT BEING POINTED DOWNWARD. -THE MUFFLER HAS BEEN FIXED THREE TIMES -THERE ARE MORE THAT I CAN NOT REMEBER RIGHT OFF HAND -THEIR IS AN ELECTRICAL PROBLEM WITH THE WHOLE CAR. THE LIGHT ON THE RADIO TIME AND STAION DISPLAY HAS NOT WORKED SINCE I BOUGHT IT, THE DRIVER'S REAR DOOR LIGHT HAS NOT COME ON, THE PASSENGER REAR WINDOW LETS DOWN BUT WILL NOT LET UP WHEN NEEDED SINCE RIGHT AFTER I GOT THE CAR, THE LIGHTS IN THE DASHBOARD GO ON AND OFF WITHOUT EVEN BEING TOUCHED, WHILE RIDING DOWN THE ROAD, THE WIDSHIELD WIPERS WILL JUST COME ON WITHOUT BEING TURNED ON AND THEN STOP HALFWAY DOWN IMPAIRING VISION, THE PASSENGER REAR TAIL LIGHT BLOWS ALL OF THE TIME, IT HAS NEVER STAYED WITH A BULB THAT WORKS, ETC. -THE VALVE COVER GASKET LEAKS AND HAS LEAKED SINCE I GOT IT -THE GAS LIGHT WILL NOT TELL YOU WHEN YOU ARE RUNNING LOW ON FUEL -THE RADIO WILL EAT YOUR TAPES SINCE I GOT THE CARTHE TRANSMISSION HAS BEEN REPLACE ON THE CAR WITH LESS THAN 80,000 MILES ON IT -THE RACK AND PINION HAD TO BE REPLACED A FEW YEARS AGO ALONG WITH THE COMPLETE BRAKE SYSTEM THE POWER STEERING HAS LEAKED FLUID AND WILL STOP TURNING IN THE MIDDLE OF A TURN. I HAVE ALMOST WRECKED ON IT SVERAL TIMES BECAUSE OF IT AND THE BRAKES. -THE AIR CONDITIONING COMPRESSOR WORKS WHEN IT GETS READY TO IF EVEN THEN AND HAS ALWAYS DONE THAT.
STRUT BEARING PLATE: SHOULD NOT BE FAULTY ON A 1996, CAN CAUSE LOSS OF STEERING *AK( DOT NUMBER: TIRE SIZE: P195R6515 )
FRONT CONTROL ARMS ON BOTH SIDES CRACKED AND ALMOST FELL OFF, WHICH MAY HAVE CAUSED LOSS OF VEHICLE CONTROL AND A CRASH. PLEASE PROVIDE FURTHER INFORMATION. *AK
WHILE DRIVING AT HIGHWAY SPEEDS VEHICLE COMPLETELY SHUTS DOWN WITHOUT WARNING. DEALER REPLACED THE IGNITION CONTROL MODULE AND THE RIGHT LOWER CONTROL ARM, WHICH DID NOT CORRECT THE PROBLEM. PLEASE GIVE ANY FURTHER DETAILS. *AK
WIPER SWITCH BROKEN.
FRONT WHEEL BEARINGS AND DRIVE AXLES REPLACED TWICE WITHIN ONE YEAR.
THUMPING NOISE IN FRONT OF VEHICLE--WHEEL BEARINGS REPLACED. PAN/OIL GASKET REPLACED. CORRODED WIRING FOR GAS GAUGE. REPAIRED REAR CHASSIS. EXHAUST SYSTEM AND SENDER ASSY REPLACED. HEATER PIPE LEAKING. WORN TENSIONER REPLACED. NEW ENGINE. PISTONS REPLACED.
OWNER STATES THAT HUB WHICH HOLDS THE WHEELS BROKE, DEALERS STATE THAT THERE IS TOO MUCH PLAY IN BALL JOINTS. *AK
WHILE DRIVING VEHICLE PULLS TO THE EXTREME RIGHT, SIX ATTEMPTED FIXES. *AK
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .