Owner-reported complaints naming the electrical system, filed with NHTSA
Data refreshed
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories. Every record below is an owner-reported complaint about the 2000 Pontiac Sunfire submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 22 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
"TAKATA RECALL" WHILE DRIVING AT NIGHT ON A COUNTY ROAD AND SWITCHING FROM LOW BEAMS TO HIGH BEAMS, THE HEADLIGHTS WENT COMPLETELY DARK AND DID NOT COME BACK ON UNTIL SWITCHING BACK TO LOW BEAMS. AFTER INSPECTION, NOTICED THE DAY RUNNERS ALSO WERE NOT WORKING. ALL FUSES WERE PLUGGED IN AND GOOD. REPLACING THE RELAY DID NOT FIX THE PROBLEM DESCRIBED HEREIN.
TL* THE CONTACT OWNS A 2000 PONTIAC SUNFIRE. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED AND UNOCCUPIED, A SMALL FIRE OCCURRED IN THE STEERING COLUMN AND INSTRUMENT PANEL. IN ADDITION, THE FRONT DRIVER'S SIDE WINDSHIELD WAS CRACKED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS NOT REPAIRED. IN 2005, THE VEHICLE WAS REPAIRED UNDER A RECALL RELATED TO THE MOST RECENT FAILURE UNDER NHTSA CAMPAIGN ID NUMBER: 04V036000 (ELECTRICAL SYSTEM: IGNITION: SWITCH). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT PROVIDED NO ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000. UPDATED 08/07/12*LJ UPDATED 08/15/2012 *JS
REAR PASSENGER SIDE TURN SIGNAL SOCKET IT IS GETTING VERY HOT AND IS MELTING BULBS AND SOCKET. HAVE REPLACED BULBS VARIOUS TIMES WITH AND WITHOUT PROPER GREASE AND NO CHANGE. *TR
TL*THE CONTACT OWNS A 2000 PONTIAC SUNFIRE. UPON STARTING THE ENGINE AT NIGHT, THE INSTRUMENT PANEL WOULD NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER BUT THERE WERE NO REPAIRS MADE TO THE VEHICLE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 130,000.
TL* THE CONTACT OWNS A 2000 PONTIAC SUNFIRE. THE IGNITION SWITCH HAS MELTED,WHICH DISABLED VEHICLE OPERATION. THE DEALER AND THE MANUFACTURER WERE CONTACTED. HE WAS REFERRED TO THE DEALER FOR DIAGNOSTIC TESTING. THE WARRANTY EXPIRED, AND THERE WERE NO RECALLS THAT ADDRESSED THE FAILURE. THE FAILURE MILEAGE WAS 125,000.
PASSENGER TAIL LIGHT OR BRAKE LIGHT HAVE BEEN REPLACED SEVERAL TIMES. FUSES REPLACED SEVERAL TIMES. ONCE REPLACED BULBS DEFECT WITHIN AN HOUR OR SO. DOME LIGHT OR OVER HEAD LIGHT REPEATS SAME PROCESS. VEHICLE'S BATTERY AND TERMINALS REPLACED WITH NO CHANGE. $$$ *TR
MY TURN SIGNALS HAVE BEEN ACTING UP LATELY. AFTER DOING SOME RESEARCH ONLINE, I DECIDED TO FILE THE CLAIM-SEEMS I AM NOT THE ONLY ONE HAVING THE SAME PROBLEM. WHEN I USE MY LEFT TURN SIGNAL, MORE OFTEN THEN NOT IT DOESN'T WORK, MY DASH LIGHTS FLASH AND MY WINDSHIELD WIPERS WILL NOT SHUT OFF. WHEN I USE MY RIGHT SIGNAL, THE DASH LIGHTS FLASH BUT MY WINDSHIELD WIPERS ONLY STAY ON FOR ABOUT A MINUTE. IF I HAVE MY HEADLIGHTS ON (FOR NIGHT DRIVING) THE WIPERS ARE ON CONSTANTLY. ALSO, MY WINDSHIELD FLUID DOES NOT SPRAY. I HAD THE WIRING REPLACED SOME TIME AROUND WHEN I PURCHASED IT 4 YEARS AGO (OLD PART NOT AVAILABLE). IT CORRECTED THE PROBLEM FOR ABOUT A YEAR, HOWEVER SINCE THEN IT HAS BEEN A COME AND GO ISSUE. *NM
MY CAR IS A 2000 PONTIAC SUNFIRE, AND TWICE WITHIN 12 MONTHS I HAVE HAD THE SAME PROBLEM WITH THIS VEHICLE. THE DAY TIME RUNNING LIGHTS AND THE BRIGHT LIGHTS QUIT WORKING , THE 1ST TIME THE DEALERSHIP SAID IT WAS A BAD WIRE AND REPLACED IT, WITHIN ONE YEAR IT HAPPENED AGAIN, BUT THE DEALERSHIP SAID THAT THE PART WAS ONLY WARRANTED FOR 1YR OR 12,000 MILES OF WHICH THE VEHICLE HAD BEEN DRIVEN OVER THE 12,000 MILES,THEREFORE I AM HAVING TO PAY AGAIN (TWICE IN ONE YEAR ) FOR THE SAME PROBLEM. THIS IS RIDICULOUS! *JB
WHILE ON ACTIVE DUTY IN THE ARMY, I PURCHASED A USED 2000 PONTIAC SUNFIRE IN GEORGIA. THE CAR BEGAN GIVING ME PROBLEMS ONLY 6 MONTHS AFTER THE PURCHASE. LUCKILY, I FORCED THE DEALERSHIP TO PAY FOR A WARRANTY BECAUSE I HAD TO HAVE 3 MAJOR REPAIRS WITHIN A 11/2 AFTER THAT. UNFORTUNATELY, SHORTLY AFTER THE WARRANTY WAS UP, I DISCOVER NUMEROUS OTHER PROBLEMS WITH THE AUTOMOBILE, INCLUDING THE RECALL. THIS CAR IS TRULY A LEMON! I DO NOT BELIEVE I SHOULD HAVE TO SUFFER WITH THIS DEFECTIVE CAR. I OWE OVER 3 TIMES THE VALUE OF THE CAR. EVEN THOUGH I HAVE ALL THE DOCUMENTATION TO SUPPORT MY GOOD CARE AND MAINTENANCE, NO ONE WILL TOUCH THIS CAR BECAUSE IT HAS SO MANY OTHER DEFECTS BESIDES THE RECALL (FRONT END SUSPENSION ISSUES, FUEL TANK). I AM A DISABLED VETERAN NOW WITH ONLY A SMALL PENSION TO SUPPORT MYSELF AND TWO CHILDREN. THIS CAR HAS BEEN A NIGHTMARE SINCE I BOUGHT IT AND FIXING THE IGNITION SWITCH IS NOT GOING TO FIX THIS LEMON. I HAVE PUT OVER $3000 IN REPAIRS ON THIS CAR OVER THE LAST FEW YEARS ASIDE FROM THE MONTHLY FINANCED PAYMENTS OF $282 X 3YRS=$10,152 AND I STILL OWE $7800. THE CAR IS ONLY VALUED AT $2150. AND WHEN DEALERS LOOK AT THE HISTORY OF PROBLEMS BEHIND THIS CAR, THEY DON'T EVEN WANT TO GIVE ME $2000.*AK
PROBLEMS WITH 2000 PONTIAC SUNFIRE ENGINE. *MR THE VEHICLE WOULD CRANK SOMETIMES BUT NOT START. ON ONE OCCASION THE VEHICLE ATTEMPTED TO CRANK AND STALLED IN THE PROCESS. THE PROBLEM CONTINUED. THE CONSUMER WAS TOLD THAT THE STARTER HAD GONE OUT, MAYBE THERE WAS AN ELECTRICAL PROBLEM, OR THE FUEL PUMP. THE FUEL PUMP AND SENDER RING WAS REPLACED. THERE WAS A BURNT COOLANT SMELL AND THE VALVE COVER GASKET RUPTURED LEAKING OIL. *SC *JB
CAR STOPS ACCELERATING WHILE DRIVING THEN DIES. BEEN GOING ON SINCE AUGUST AND HAVE NOT BEEN ABLE TO FIND THE PROBLEM. GENERATING NUMEROUS COMMUNICATION ERRORS. HAD THE COMPUTER REPLACED THOUGHT THIS WAS THE PROBLEM BUT IT DID NOT FIX THE ISSUE. THE FIRST TIME THIS HAPPENED WAS 8/5/03 AND IT WAS IN THE SHOP FOR A WEEK WITH NO RESOLUTION. IT RAN FOR A COUPLE MORE DAYS THEN DID IT AGAIN THE FOLLOWING WEEK AROUND 8/11/03. THIS WENT ON THROUGH AUGUST IN AND OUT OF THE SHOP AT WHICH TIME I RENTED A CAR TO GET BACK AND FORTH TO WORK SINCE THE PROBLEM WAS GRADUALLY GETTING WORSE AND BEING BROKEN DOWN ON THE FREEWAY WAS GETTING TO BE A DANGEROUS PROBLEM. THE COMPUTER WAS REPLACED ON 10/22/03 AND IT DIED WHEN I DROVE OFF. CAR HAS BEEN TOWED 3 TIMES DUE TO NOT STARTING RIGHT BACK UP AND BEING STRANDED ON THE FREEWAY. IT HAS BEEN IN THE SHOP FOR OVER A WEEK AS OF TODAY 10/29/03 AND DEALER IS TELLING ME THAT IT IS THE OXYGEN SENSORS BUT CANNOT GUARANTEE THE WORK. *AK
CAR HAS HAD NUMEROUS PROBLEMS SINCE DAY ONE. BRAKES CHATTER, OVERHEATING, SERVICE ENGINE LIGHT, CD PLAYER AND SPEAKERS DID NOT WORK. NOW IT STALLS WITH NO WARNING AT ALL. STALLS AT 70 MPH GOING DOWN HIGHWAY. HAS STALLED WHILE DRIVING 3 OR 4 TIMES IN THE PAST TWO DAYS. CHECKED OUT AT SERVICE STATION ON COMPUTER, AND SHOWS NO PROBLEMS. HAVE READ MANY COMPLAINTS HERE ABOUT THE EXACT SAME PROBLEM. BAD FUEL PUMP OR SOMETHING IS CAUSING CAR TO STALL. THEN IT TAKES FROM 10 TO 15 MINUTES TO START AGAIN. SOME DAYS IT JUST WON'T START AT ALL. HAVE HAD CAR CHECKED MANY TIMES, AND NO ONE CAN SEEM TO FIND THE PROBLEM. ANYONE THAT CAN HELP HERE??? I THINK GMC OWES MANY, MANY CONSUMERS AN EXPLANATION AND REPAIR OF THIS VERY SERIOUS AND POTENTIALLY DANGEROUS PROBLEM! *PH
I HAVE HAD MY VEHICLE IN FOR BRAKE REPAIR SEVERAL TIMES IN THE PAST 3 1/2 YRS. AT LEAST 5-7 TIMES. MY CAR IS NOW EXPERIENCING SEVERAL ELECTRICAL PROBLEMS WITH A PLUG UNDER THE HARNESS AND WITH THE COMPUTER SYSTEM AND WIRING. MY CAR WILL NOT START FOR SEVERAL DAYS AND THEN IT WILL START, ONLY TO BREAKDOWN AGAIN WHEN IT HEATS UP. IT HAS ALSO CUT OFF WHILE I WAS DRIVING 70 MPH ON THE EXPRESSWAY.IT HAS BEEN TOWED 3 TIMES IN THREE WEEKS FOR REPAIR DUE TO THESE PROBLEMS. I'VE SPENT SEVERAL HUNDRED DOLLARS TRYING TO FIX THESE PROBLEMS AND NOTHING SEEMS TO WORK. THE PLUG UNDER THE HARNESS WAS MELTING THROUGH MY BACK FLOORBOARD, MELTING MY CARPET WITH THE POTENTIAL TO CATCH ON FIRE. I WAS INFORMED BY THE SERVICE MEN THAT I'M EXPERIENCING COMPUTER AND WIRING PROBLEMS. THEY ADVISED ME TO CONTACT MY INSURANCE COMPANY REGARDING TOTALING MY CAR OUT BECAUSE IT HAS GREAT POTENTIAL TO CATCH ON FIRE. I CONTACTED GM'S CUSTOMER ASSISTANCE CENTER REGARDING ALL OF THE PROBLEMS I'M HAVING AND THEY ARE NOT WILLING TO HELP DUE TO MY CAR BEING 3 1/2 YRS. OLD. THERE HAVE BEEN SEVERAL OTHER SMALL ISSUES WITH THIS VEHICLE, BUT THIS CAR IS VERY DANGEROUS AND I CANNOT AFFORD TO KEEP WASTING MONEY ON REPAIRS. I THINK A CAR SHOULD LAST MORE THAN 3 1/2 YRS! JULY 26TH 2003 WAS THE LAST TOW DATE AND IT'S STILL IN THE SHOP. CAN YOU HELP? *PH
THE VEHICLE STALLED. THE DEALER STATED THE PROBLEM WAS ELECTRICAL. *JB
CONSUMER STATED VEHICLE WOULD NOT SHIFT OUT OF GEAR, THE DEALER REPLACED THE TRANSMISSION.*JB
WHEN DRIVING HEADLIGHTS, AND EVERYTHING IN DASHBOARD COMPLETELY SHUTDOWN. VEHICLE HAS BEEN TO REPAIR GARAGE A TOTAL OF SEVEN TIMES FOR AN ELECTICAL PROBLEM. HOWEVER, PROBLEM HAS NOT BEEN REMEDIED AS OF YET. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
EXHAUST SYSTEM WAS REPLACED DUE TO IT GETTING HOT MELTING THE CARPET AND PAINT INSIDE TRUNK, FUMES FILLED INTERIOR OF VEHICLE AT THIS TIME EXHAUST SYSTEM IS RUNNING JUST AS HOT AGAIN, DEALER STATED FACTORY REPRESENTATIVE INSTRUCTED HIM NOT TO DO ANYTHING ABOUT THE EXHAUST SYSTEM, THERE WAS NOTHING THAT COULD BE DONE.*AK CONSUMER STATES THE VEHICLE HAS BAD GAS MILEAGE, STARTER MOTOR SEIZED AND FAILED, POWER STEERING FLUID WAS LEAKING, COOLANT WAS LEAKING FROM LEFT FRONT AND BACK OF THE VEHICLE, REPLACED RADIATOR, HEATER BLOWS COLD AIR AT IDLE, TRUNK LEAKS, HEAD LAMP IS OUT OF ADJUSTMENT, GLOVE BOX WILL NOT CLOSE, MUFFLER FELL OFF, KEY COMES OUT OF IGNITION WITH VEHICLE RUNNING, TRANSMISSION HAS NO REVERSE, THERE WAS BRAKE PULSATION AT HIGH SPEED OR WHEN STOPPING, BRAKE PEDAL GOES TO FLOOR, SPEAKERS INOPERATIVE, SEAT SPRING FAILED, SUSPECTED MOTOR OIL SMELL AND REPLACED THERMOSTAT, HORN WAS INOPERATIVE, POWER AND GROUNDS DISTRIBUTION REPLACED, WINDOW WILL NOT GO DOWN ALL THE WAY, FOUND WINDOW REGULATOR FAILED, HAZARD LAMPS AND TURN SIGNAL WERE INOPERATIVE, REPLACED BLOWN FUSE, CIGARETTE LIGHTER INOPERATIVE, REPLACED BLOWN FUSE, TRACTION CONTROL INOPERATIVE, ENGINE LIGHT COMES ON, A/C HOSE LEAKING, REPLACED EVAPORATOR, HARD TO START AND ROUGH IDLE, ENGINE MAKE RATTLING NOISE AND QUIT RUNNING, REPLACED HEAD CYLINDER AND 02 SENSOR, VEHICLE PULLS TO THE LEFT, OVERFLOW BOTTLE MELTED AND 42 GOODYEAR TIRES BLEW OUT, ALSO THE HVAC WAS INOPERATIVE. *YD
SON (DENNY HEROLD) DROVE CAR TO WORK AND TO A FRIENDS HOUSE, SHUT OFF CAR, WENT INSIDE, AND CAME BACK TO FIND HIS CAR FULL OF SMOKE (WINDOWS DOWN) SMOKE ROLLING FROM CAR. FIRE DEPARTMENT, POLICE CALLED JUST MISSED BY 15 MINUTES HAVING HIS PREGNANT WIFE AND 2 YEAR OLD SONE IN THE CAR WITH HIM. GM NOTIFIED, GREEN CHEVROLET NOTIFED, FIRE DEPARTMENT LOOKED AT, STATE FARM LOOKED AT, GM FIRE INSPECTOR LOOKED AT FIRE STARTED ON PASSENGER SIDE OF CAR ON FLOOR NEAR CONSOLE. CAR TOTALLY DESTROYED. FIRE DEPT AND STATE FARM SAID ELECTRICAL. OFFICE OF DEFECTS NHTSA HAS A ODI ID: 717953 ON 1/23/2000 WHICH REPORTED A SIMILAR INCIDENT WHERE FIRE OCCURRED IN CAR BECAUSE OF SHORT IN LEAD WIRE ON PASSENGER SIDE OF CAR AND BURNED THROUGH CARPET.*AK
VEHICLE STALLED TWICE IN THE LAST 6 MONTHS AT ABOUT 45 MPH. VEHICLE TAKEN TO DEALER 4-5 TIMES,COULD NOT LOCATE CAUSE. DEALER REPLACED BATTERY AND ALTERNATOR. CONSUMER REFUSED TO DRIVE VEHICLE. *AK
VEHICLE WAS BLOWING FUSES TO REAR TAILIGHTS. IF VEHICLE COULD BE BE DRIVEN/ TURNED OFF, STARTED BACK UP, AND THERE WILL BE NO LIGHTS IN REAR. DEALER HAS FIXED IT 4 TIMES. THEY HAVE REPLACED FUSES, AND HAS NO OTHER REMEDY. CONSUMER HAS BE STRANDED WITHOUT ANY LIGHTS AT NIGHT.*AK
WHEN DRIVEN AT HIGHWAY SPEED FOR LONG TIME--TURN OFF CAR-- WILL NOT START AGAIN. *AK
BRAND NEW AUTOMOBILE CONTINUED TO BREAKDOWN. CONSUMER WAS TOLD THAT IT WAS AN ELECTRICAL PROBLEM OR COMPUTER PROBLEM. JUST MISSED BEING CRUSHED BY ONCOMING AUTOMOBILES ON HIGHWAY. *AK *ML
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .