2001 Pontiac Sunfire Electrical Problems

TL* THE CONTACT OWNS A 2001 PONTIAC SUNFIRE. THE CONTACT STATED THAT THE ANTI-THEFT WARNING INDICATOR KEPT RANDOMLY ILLUMINATING. THE VEHICLE WAS ABLE TO START AND, AT TIMES, UPON ENTERING THE VEHICLE, THE KEY WOULD NOT TURN OVER TO START THE VEHICLE FROM THE IGNITION. THE DEALER REPLACED THE BATTERY AND THE IGNITION SWITCH, BUT THE FAILURE CONTINUED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V036000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

10979465

Incident

Mar 3, 2014

TL* THE CONTACT OWNS A 2001 PONTIAC SUNFIRE. WHILE DRIVING 25 MPH, THE IGNITION SWITCHED OFF INDEPENDENTLY AND CAUSED THE STEERING WHEEL TO LOCK WITHOUT WARNING. THE FAILURE CAUSED A FOUR VEHICLE CRASH. THE AIR BAGS FAILED TO DEPLOY AND THE VEHICLE WAS DESTROYED. IT WAS UNKNOWN IF ANY INJURIES WERE SUSTAINED OR IF A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS UNAVAILABLE.

NHTSA ID

10661403

Incident

Jun 5, 2014

CONTACTED A LOCAL AUTO DEALER, CUTTER PONTIAC (WAIPAHU, HAWAII - LEVY, SERVICE AGENT, PH# 808-564-9520) AND INQUIRED ABOUT MY VEHICLES POSTED 3 RECALL ISSUES; IGNITION, FUEL SYSTEM, & STEERING WHEEL. I EVEN EMAILED AN OFFICIAL LIST OF MY VEHICLE'S RECALL ISSUES I WAS TOLD THE FOLLOWING, AFTER LEVY HAD THE OPPORTUNITY TO REVIEW MY EMAIL,WITH MY RECALL LIST: 1. IGNITION - I WAS TOLD THAT MY CONCERN HAD PAST THE ORIGINAL DATE OF RECALL, 2004 ???, SO DEALER IS UNABLE HELP ME RESOLVE THIS ISSUE 2. FUEL SYSTEM - I NOTED THAT I SMELLED FUEL BACK A FEW WEEKS PRIOR, I WOULD NEED TO BRING MY VEHICLE DOWN AND THEY WOULD DIAGNOSE THE PROBLEM, BUT WOULD CHARGE ME FOR THE DIAGNOSTIC CHECK. 3. STEERING WHEEL - AGAIN, I WAS TOLD THEY WOULD NEED TO DO A DIAGNOSTIC CHECK, BUT STILL CHARGE ME. I INFORMED THAT MY VIN, DID NOT SHOW UP ON THEIR COMPUTER LIST I INITIALLY MADE AN A SERVICE APPOINTMENT, BUT CANCELLED ...... AS I WAS NOT PREPARED TO PAY DIAGNOSTIC TESTS TO CONFIRM MY VEHICLE'S RECALL ISSUES. THANK YOU *TR

NHTSA ID

10627127

Incident

Aug 19, 2014

Mileage

65,964 mi

TL* THE CONTACT OWNS A 2001 PONTIAC SUNFIRE. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING WHILE DRIVING AT ANY SPEED. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE CONTACT REPLACED THE FUSES. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC TEST PERFORMED. THE FAILURE AND THE CURRENT MILEAGES WERE 116,000. UPDATED 06/20/12*LJ THE CONSUMER STATED THE FUEL INJECTION WAS NOT REPLACED. HER HUSBAND REPLACED THE FUSES. UPDATED 06/22/12 UPDATED 8/20/12 *CN THE CONSUMER ALSO STATED THE VEHICLE USED AN EXCESSIVE AMOUNT OF FUEL. UPDATED 08/23/12

NHTSA ID

10458915

Incident

Mar 1, 2012

Mileage

116,000 mi

I TOO HAVE A 2001 PONTIAC SUNFIRE SE 2.2 AUTO WITH ABOUT 58,000 MILES ON IT. I BOUGHT THIS CAR IN MARCH OF 2002 WITH ONLY 14,937 MILES ON IT. I HAD NO PROBLEMS WITH THIS CAR TILL NOVEMBER 2004 AT 44,874 MILES, WHEN AN 8 POINT BUCK RAN INTO THE LEFT SIDE FRONT FENDER AND DAMAGED IT, THE HOOD, WINDSHIELD, DRIVER'S DOOR, ROOF, AND BACK DOOR WHILE I WAS DRIVING 55 MPH. THE CAR WAS REPAIRED, THEN SAT OUTSIDE FOR ABOUT 4 1/2 YEARS. HAD TO INSTALL A NEW FUEL PUMP AND BATTERY, THEN I STARTED DRIVING IT AGAIN EVERY DAY IN NOVEMBER 2009. NOW I HAVE NO HIGH BEAM HEADLIGHTS, LIGHTS ARE GOOD. ALSO, WHEN I PUT THE TRANSMISSION INTO GEAR, THE DAYTIME RUNNING LIGHTS FLASH REAL FAST ABOUT 7 OR 8 TIMES, THEN GO OUT, AND THE SERVICE LIGHT COMES ON, BUT IF I TURN ON THE LOW BEAM HEADLIGHTS FIRST, IT IS FINE! SERVICE LIGHT GOES OUT AFTER CAR IS TURNED OFF AND RESTARTED, UNTIL PUT BACK INTO GEAR WITH THE HEADLIGHTS OFF! I HAVE REPLACED THE DAYTIME RUNNING LIGHTS RELAY WITH A NEW ONE, BUT IT STILL DOES THE SAME THING, AND IF I LEAVE THE RELAY OUT, THEN WHEN I TURN ON THE HEADLIGHTS, ONE IS NORMAL AND THE OTHER IS REAL DIM!! THIS HAS BEEN AN ONGOING PROBLEM FOR ABOUT A YEAR NOW. I THOUGHT IT MAY BE A PROBLEM STEMMING FROM THE DEER DAMAGE AND REPAIRS, BUT I SEE FROM ALL OF THE OTHER COMMENTS ON HERE FROM THE PAST 9 OR 10 YEARS OR SO, THAT THIS SEEMS TO BE A COMMON PROBLEM WITH THIS CAR. WOULD THIS BE THE TURN SIGNAL/DIMMER SWITCH IN THE STEERING COLUMN CAUSING ALL OF THESE PROBLEMS?? ANY IDEAS?? THANK YOU!!

NHTSA ID

10393215

Incident

Nov 1, 2009

Mileage

45,750 mi

WE HAVE A 2001 SUNFIRE THAT HAS HORN PROBLEMS. SOMETIMES THE HORN WORKS, SOMETIMES IT DOESN'T. WE HAVE TAKEN IT BY DEALERSHIPS AND THEY SAY THEY CANNOT FIND THE PROBLEM. WE HAD A 1998 SUNFIRE THAT DID EXACTLY THE SAME THING. THIS IS AN OBVIOUS DEFECT AND IT IS A SAFETY ISSUE BECAUSE OF THE LOSS OF THE HORN. *TR

NHTSA ID

10252696

Incident

Dec 23, 2008

HAVE HAD THE VEHICLE TO THE DEALER A NUMBER OF TIMES (3) FOR MULTIPLE FRONT END LIGHTING SYSTEM FAILURES OF VARIOUS COMPONENTS. FAILURE HAS ALWAYS BEEN LINKED TO ISSUES WITH THE WIRING HARNESS. *TR

NHTSA ID

10218935

Incident

Feb 20, 2008

Mileage

84,000 mi

ELECTRICAL SYSTEM FAILURE. UNDER DASH WIRE HARNESS NEEDS REPLACEMENT. SPEEDOMETER, TACH AND ALL OTHER GAUGES FAILED. ALL SAFETY AND DIAGNOSTIC LIGHTS COME ON ... REPUTABLE ELECTRONICS REPAIR SHOP DIAGNOSED PROBLEM AND COST TO REPAIR IN EXCESS $2,000. CAR NOT DRIVABLE, NOT ABLE TO SELL, NOT ABLE TO BE REGISTER IN NY STATE. *NM

NHTSA ID

10169639

Incident

Jun 15, 2006

Mileage

65,000 mi

ODOMETER DISPLAY IS VISIBLE WHEN FIRST STARTING CAR. AS SOON AS YOU BEGIN TO DRIVE, THE ODOMETER READING BEGINS TO FLICKER. DOES NOT APPEAR TO BE GIVING AN ACCURATE READING EITHER. SHOP STATED THAT NEW DASH ASSEMBLY WOULD HAVE TO BE INSTALLED TO CORRECT ISSUE SINCE ACCESS TO WIRING WAS NOT POSSIBLE.

NHTSA ID

10138782

Incident

Oct 5, 2005

Mileage

46,600 mi

THE TRACTION LIGHT ILLUMINATED AND THEN THE VEHICLE SHUT OFF COMPLETELY. THE VEHICLE HAS BEEN TAKEN IN FOR SERVICE, BUT THE PROBLEM COULD NOT BE DUPLICATED. *JB

NHTSA ID

10112939

Incident

Feb 5, 2005

Mileage

144,600 mi

NHTSA RECALL CAMPAIGN #04V036000; PONTIAC ISSUED AN IGNITION SWITCH RECALL. THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN ALTHOUGH THE CONSUMER EXPERIENCED THE SAME PROBLEM AS THOSE VEHICLE'S THAT CAUSED THE WINDSHIELD TO CRACK AND 2700 HUNDRED DOLLARS WORTH OF DAMAGE TO THE VEHICLE. THE REAR SEAT BELTS DID NOT WORK. *SC *JB

NHTSA ID

10101792

Incident

Nov 21, 2004

Mileage

48,547 mi

CONTINUATION OF ODI 10093259: REPEATED INAPPROPRIATE ACTIVATION OF PASS LOCK 2 ANTI-THEFT SYSTEM. THE PASS LOCK ACTIVATES WITHOUT WARNING RESULTING IN STRANDING OF MOTORIST. GM DENIES DEFECT IN PASS LOCK. HOWEVER, DEALER SERVICE MANAGER STATES THAT, "I KNOW THAT IT WILL HAPPEN SOMEDAY, THAT I'LL GO TO START MY (GM PRODUCT) AND THE PASSLOCK WON'T LET ME." THE SERVICE MANAGER STATED THAT "IT'S NOT A MATTER OF IF, IT'S A MATTER OF WHEN" (THE DEFECT OCCURS). THE DLR REFERS TO THE PROBLEMS WITH THE SYSTEM AS "AN ACCEPTABLE PRICE TO PAY FOR HAVING A THEFT PREVENTION SYSTEM. INAPPROPRIATE ACTIVATION OF THE PASSLOCK SYSTEM IS LIKELY TO RESULT IN INCIDENTAL INJURIES TO STRANDED MOTORISTS IF THE INCIDENT OCCURS IN A HIGH CRIME AREA. OWNERS OF VEHICLES EQUIPPED WITH PASSLOCK HAVE NO WARNING OF PENDING FAILURES WHICH ARE EXPENSIVE TO REPAIR. IF THE DEFECT OCCURS WHILE TRAVELING FAR FROM ONE'S HOME, THE MOTORIST WOULD BE STRANDED, QUITE POSSIBLY WITHOUT THE MEANS TO OBTAIN REPAIRS TO CONTINUE THEIR JOURNEY. GM SERVICE REPS BLAME THE FAILURES ON "WEAR AND TEAR" OF THE IGNITION SWITCH. HOWEVER, THIS VEHICLE HAS BEEN SUBJECT TO RECALL FOR OVERVOLTAGE DAMAGE TO THE SWITCH. SUCH OVERVOLTAGES ARE ALSO LIKELY TO DAMAGE COMPONENTS OF THE PASSLOCK SYSTEM (I.E. THE HALL EFFECT SENSOR) WITHIN THE IGNITION SWITCH.*AK

NHTSA ID

10093286

Incident

Sep 14, 2004

Mileage

64,000 mi

LOCK ANTI-THEFT SYSTEM INTERMITTENTLY DISABLES CAR. SOMETIMES THE SYSTEM WILL RESET ITSELF. THE LAST TIME IT WOULD NOT RESET.*AK

NHTSA ID

10093259

Incident

Sep 14, 2004

Mileage

64,000 mi

CONSUMER RECEIVED RECALL 04V036000 CONCERNING IGNITION SWITCH. CONSUMER COMPLAINED THAT RECALL REPAIRS WERE DONE ONCE, BUT THE PROBLEM RECURRED. *AK

NHTSA ID

10083692

Incident

Jun 4, 2004

Mileage

30,000 mi

UPON PULLING HOOD RELEASE LATCH INSIDE THE VEHICLE THE HOOD FAILED TO OPEN TO SECONDARY LATCH. THE MECHANISM WAS INOPERATIVE DUE TO BATTERY ACID LEAKING ONTO HOOD RELEASE CABLE, CORRODING IT. *AK

NHTSA ID

10046542

WHILE DRIVING OR BRAKING VEHICLE WILL CUT OFF WITHOUT WARNING AND WILL NOT RESTART UNTIL SEVERAL MINUTES LATER. *NLM

NHTSA ID

10014141

Incident

Feb 20, 2003

WHILE IN MOTION, THE REAR BRAKES WILL LOCK UP. THIS CAUSED THE VEHICLE TO GO INTO AN UNCONTROLLABLE SKID SIDEWAYS. *JG *TS

NHTSA ID

567748

WHILE TRAVELING ON HIGHWAY TURNED TURN SIGNAL ON AND HEADLIGHTS WILL COME ON INTERMITTENTLY. DEALERSHIP IS AWARE OF PROBLEM.*AK

NHTSA ID

8016245

Incident

Aug 13, 2002

AFTER BEING DRIVEN, VEHICLE WILL SMELL LIKE RUBBER BURNING ON OUTSIDE. WHILE PARKED, VEHICLE CAUGHT ON FIRE. DEALER CONTACTED. *AK *JB

NHTSA ID

8003427

Incident

Jan 4, 2002

PRIOR TO INCIDENT BEING REPORTED, A BURNING RUBBER ODOR COULD BE DETECTED WHILE STANDING BESIDE VEHICLE AFTER NORMAL OPERATION. THEN, ON 04-JAN-2002, VEHICLE WAS PARKED FOR APPROXIMATELY 20 MINUTES WHEN A NEIGHBOR INFORMED OWNER THERE WAS A FIRE UNDERNEATH THE CAR. OWNER STARTED VEHICLE AND MOVED VEHICLE AWAY FROM THE FIRE, LEAVES WERE BURNING. CONSUMER NOTICED THAT A LONG CABLE ATTACHED TO FRONT-AXLE WAS DANGLING FROM UNDERCARRIAGE, AND WAS CHARRED IN MIDDLE FROM THE FIRE. AN INSPECTOR FROM MANUFACTURER EXAMINED VEHICLE AND INFORMED CONSUMER THERE WAS NO PROBLEM WITH CAR. MANUFACTURER REFUSED TO PROVIDE CONSUMER WITH A COPY OF THE REPORT. PLEASE PROVIDE ANY ADDITIONAL INFORMATION / DOCUMENTATION. *AK

NHTSA ID

8003338

Incident

Jan 4, 2002

CAR DIES AFTER BACKING, TAKES SEVERAL TIMES TO START ONCE IN A WHILE. *AK

NHTSA ID

749381

Incident

Jun 22, 2001