2019 Porsche Cayenne Problems

The dashboard is peeling up and is unsafe due to airbag being underneath the leather dash. If airbag was to blow it would not function correctly due to dashboard leather peeling. Could potentially injur passenger or not deploy at all.

Porsche leather dashboard shrunk and staples pulled out. I was told if the vehicle was in an accident the airbag may not deploy properly. The Porsche dealer looked at it recommend that it be replaced. This is a known manufacturer defect that has been occurring with many of Porsche leather dashboards in different models. The manufacture is not taking responsibility in repairing or recalling this dangerous situation and putting the cost onto the customer. The fact that this is an option they offer as an additional cost on their vehicles , knowing this is a dangerous defect. This alone should automatically issue recall to fix before someone gets seriously injured.

The contact owns a 2019 Porsche Cayenne. The contact stated that while the vehicle was in reverse(R), the back-over prevention camera failed to provide a rear-view image. The contact received notification of NHTSA Campaign Number: 25V896000 (Back Over Prevention); and associated the failure with the recall. The local dealer was contacted; however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 105,000.

The contact owns a 2019 Porsche Cayenne. The contact received notification of NHTSA Campaign Number: 25V896000 (Back Over Prevention). The contact called a local dealer and the manufacturer but was advised that the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

The hybrid cooling system on my 2019 Porsche Cayenne E-Hybrid repeatedly displayed a red dashboard warning while the vehicle was in motion: "Hybrid coolant level too low / Park vehicle safely / Let vehicle cool down." This warning appeared on multiple occasions at speeds of approximately 22 mph, 38–40 mph, and 47 mph, as documented in timestamped photos and videos taken in November 2025. A separate warning in July 2025 read: "Engine cannot be started / Remove charger plug." The warnings indicate a potential thermal management or hybrid cooling system failure. A moving vehicle being instructed to park and cool down presents a safety risk to the driver and others, particularly if the condition causes sudden power loss or thermal event. The vehicle was serviced at an authorized Porsche dealer in 2025. Despite that service activity, the hybrid coolant warning recurred while driving in November 2025, suggesting the underlying condition was not fully resolved. The issue was reported to the manufacturer (PCNA), who acknowledged it under a case number and offered a service voucher. The selling dealer attributed the concerns to a manufacturer charging-cable campaign. Neither response addressed the recurring in-motion warning or confirmed the hybrid cooling system was repaired. Timestamped photo and video evidence is available showing the dashboard warnings and vehicle speed at time of occurrence. Complete repair orders have been requested but not yet provided. The component may be available for inspection upon request.

2019 Porsche Cayennes (and other Porsche models) have LiFe P04 lithium batteries that have an internal Battery Control Module that causes a "Battery Low " indication. Porsche has been updating the software/ firmware for this module, only for it to fail again. Eventually, the battery will fail, lose charge, and become dead. There are no after market batteries available and if you are 1 mile out of the warranty period, Porsche forces you to buy a new replacement battery from them for over $2,000.00 USD plus labor. This battery failure condition for vehicles with this type of battery is well known by Porsche and they now use a completely different type of battery in their newer models. This failure should be considered a Safety issue and concern since the battery powers every safety feature the vehicle has to offer. There are pages upon pages of testimonies on the Rennlist forum website for Porsche owners and all have been advised to contact Porsche Cars North America and only a small percentage have had any luck with that. Porsche should release a recall to modify the system to the newer, more dependable battery for affected vehicles.

The hybrid cooling system on my 2019 Porsche Cayenne E-Hybrid repeatedly displayed a red dashboard warning while the vehicle was in motion: "Hybrid coolant level too low / Park vehicle safely / Let vehicle cool down." This warning appeared on multiple occasions at speeds of approximately 22 mph, 38–40 mph, and 47 mph, as documented in timestamped photos and videos taken in November 2025. A separate warning in July 2025 read: "Engine cannot be started / Remove charger plug." The warnings indicate a potential thermal management or hybrid cooling system failure. A moving vehicle being instructed to park and cool down presents a safety risk to the driver and others, particularly if the condition causes sudden power loss or thermal event. The vehicle was serviced at an authorized Porsche dealer in 2025. Despite that service activity, the hybrid coolant warning recurred while driving in November 2025, suggesting the underlying condition was not fully resolved. The issue was reported to the manufacturer (PCNA), who acknowledged it under a case number and offered a service voucher. The selling dealer attributed the concerns to a manufacturer charging-cable campaign. Neither response addressed the recurring in-motion warning or confirmed the hybrid cooling system was repaired. Timestamped photo and video evidence is available showing the dashboard warnings and vehicle speed at time of occurrence. Complete repair orders have been requested but not yet provided. The component may be available for inspection upon request.

At approximately 52,000 miles, the vehicle experienced a sudden catastrophic transmission / driveline failure while in use. The failure created serious concern about safe operation and reliability and left the vehicle disabled or unsafe to continue driving normally. An authorized Porsche dealer evaluated the vehicle and stated that the repair would require replacement of the entire transmission assembly at very high cost. No practical parts-level repair option has been provided. I am reporting this because a sudden major powertrain failure at this mileage may indicate a safety-related defect.

2019 Porsche Cayenne Turbo (EA825 4.0L V8, VIN [XXX]). Vacuum-actuated water pump seal failure caused coolant infiltration of the vacuum system on two separate occasions during the CPO warranty period. The vacuum system on this engine supplies the brake servo (brake booster) — a safety-critical connection documented in Porsche and Audi's own engineering literature for this engine (NHTSA document MC-XXX). First failure: XXX (92,916 miles, RO XXX). Towed in overheating. Technician documented coolant infiltrating vacuum system. Coolant pump replaced. Vacuum lines not inspected or replaced. Vacuum pump not inspected or replaced. PCNA's own ATI 2235.1 (NHTSA MC-XXX) required vacuum line inspection — not performed. Second failure: October 3, 2025 (103,904 miles, RO 207205). Coolant documented at timing chain cover. Coolant pump replaced. Change-over valve not replaced — required unconditionally by ATI 2235.1. Vacuum lines not inspected or replaced. No PQIS fault code logged — required by PCNA TSB 2307 (NHTSA MC-XXX). No oil analysis performed. No timing chain cavity inspection. Service visit performed one month before CPO expiration. Third visit: XXX (103,988 miles, RO XXX). Cracked breather hose found 84 miles after second service. Vacuum system still unremediated. Current failure: March 2026. Severe valvetrain noise on cylinder bank 2. Engine-out diagnosis required. Estimate $13,286.57. Vehicle currently at Porsche Novi/Farmington Hills. PCNA denied coverage June 25, 2026 without referencing a single technical bulletin, repair order, or published protocol from the documented record. The brake servo vacuum supply connection — documented in PCNA and Audi's own engineering literature — makes this a safety matter. PCNA's own TI 173/21 (NHTSA MC-XXX) explicitly covers the V8 Biturbo variant and was not followed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The hybrid cooling system on my 2019 Porsche Cayenne E-Hybrid repeatedly displayed a red dashboard warning while the vehicle was in motion: "Hybrid coolant level too low / Park vehicle safely / Let vehicle cool down." This warning appeared on multiple occasions at speeds of approximately 22 mph, 38–40 mph, and 47 mph, as documented in timestamped photos and videos taken in November 2025. A separate warning in July 2025 read: "Engine cannot be started / Remove charger plug." The warnings indicate a potential thermal management or hybrid cooling system failure. A moving vehicle being instructed to park and cool down presents a safety risk to the driver and others, particularly if the condition causes sudden power loss or thermal event. The vehicle was serviced at an authorized Porsche dealer in 2025. Despite that service activity, the hybrid coolant warning recurred while driving in November 2025, suggesting the underlying condition was not fully resolved. The issue was reported to the manufacturer (PCNA), who acknowledged it under a case number and offered a service voucher. The selling dealer attributed the concerns to a manufacturer charging-cable campaign. Neither response addressed the recurring in-motion warning or confirmed the hybrid cooling system was repaired. Timestamped photo and video evidence is available showing the dashboard warnings and vehicle speed at time of occurrence. Complete repair orders have been requested but not yet provided. The component may be available for inspection upon request.

2019 Porsche Cayenne Turbo (EA825 4.0L V8, VIN [XXX]). Vacuum-actuated water pump seal failure caused coolant infiltration of the vacuum system on two separate occasions during the CPO warranty period. The vacuum system on this engine supplies the brake servo (brake booster) — a safety-critical connection documented in Porsche and Audi's own engineering literature for this engine (NHTSA document MC-XXX). First failure: XXX (92,916 miles, RO XXX). Towed in overheating. Technician documented coolant infiltrating vacuum system. Coolant pump replaced. Vacuum lines not inspected or replaced. Vacuum pump not inspected or replaced. PCNA's own ATI 2235.1 (NHTSA MC-XXX) required vacuum line inspection — not performed. Second failure: October 3, 2025 (103,904 miles, RO 207205). Coolant documented at timing chain cover. Coolant pump replaced. Change-over valve not replaced — required unconditionally by ATI 2235.1. Vacuum lines not inspected or replaced. No PQIS fault code logged — required by PCNA TSB 2307 (NHTSA MC-XXX). No oil analysis performed. No timing chain cavity inspection. Service visit performed one month before CPO expiration. Third visit: XXX (103,988 miles, RO XXX). Cracked breather hose found 84 miles after second service. Vacuum system still unremediated. Current failure: March 2026. Severe valvetrain noise on cylinder bank 2. Engine-out diagnosis required. Estimate $13,286.57. Vehicle currently at Porsche Novi/Farmington Hills. PCNA denied coverage June 25, 2026 without referencing a single technical bulletin, repair order, or published protocol from the documented record. The brake servo vacuum supply connection — documented in PCNA and Audi's own engineering literature — makes this a safety matter. PCNA's own TI 173/21 (NHTSA MC-XXX) explicitly covers the V8 Biturbo variant and was not followed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I purchased a Used Porsche Pre-Owned Certified 2019 Porsche Cayenne Turbo SUV on February 22, 2025, and within 4 to 6 weeks, the front brakes started to squeal very loudly when the vehicle comes to a near- stop. The dealership (Porsche River Oaks, 4007 Greenbriar Dr, Houston, TX 77098) tells me that this is normal squealing due to the type of brakes that this car has (PSCB). The squeal is louder than typical brake squealing and shouldn't appear on such a newly purchased certified car. I am reading multiple complaints on the internet about the squealing problems with the Porsche Surface Coated Brakes (PSCB) that I have on my vehicle. I am also seeing that. Porsche Cars North America, Inc has issued a Technical Service Bulletin 120/22ENU 4652 published on Sept 9, 2022, on how to fix this problem for its customers with a special brake disc and brake pad with better acoustical properties. The parts for this repair are extremely expensive. My car is supposed to be under warranty, but the service technician has offered to only clean the brake pads which the service advisor tells me should suppress the brake squeal for a short period of time, but then told me that the noise will come back due to the type of PCSB brakes this car has. I feel like I have been tricked into buy a car with defective squealing brakes and Porsche Cars of North America knew about the problem with these PSCB brakes. My worry is that Porsche Dealerships, know how to temporarily fix this squealing problem when they sell these vehicles by cleaning the brake pads.

Seals around both headlights appear to be improperly/weakly sealed. Water intrusion is coming in from light rain or even a car wash causing entire headlight system to shut off until the moisture dries up often while driving. This vehicle has matrix adaptive led headlights and there is no self service bulb to replace since they’re leds. Local Porsche dealer service advisors appear to know this is a common issue but state Porsche has yet to do a recall and they have no fix option and only offer to sell me a full headlight assembly replacement.

TAILLIGHTS GETTING CONDENSATION

SEVERAL TIMES A MONTH WHEN MY CAR COMES TO A STOP THE BRAKES MALFUNCTION AND THE BRAKE PEDAL GOES TO THE FLOOR AND THE POWER STEERING STOPS WORKING. IT TAKES UP TO ANOTHER CAR LENGTH TO FULLY STOP WHEN THIS HAPPENS - SOMETIMES JUST A FEW EXTRA FEET. IT HAS CAUSED ME TO DAMAGE THE FRONT END BY DRIVING INTO A BUSH. THE DEALER REFUSES TO DO ANYTHING BECAUSE THEY CAN'T REPLICATE THE BRAKE PROBLEM AND THEY STATE THE STEERING PROBLEM IS NORMAL. I HAVE BEEN ABLE TO REPLICATE THE STEERING PROBLEMS TO THEM BUT BECAUSE THE BRAKE ISSUE HAPPENS ONLY A FEW TIMES A MONTH I WAS NOT ABLE TO.

SAFETY ASSESSMENT: 2019 Porsche Cayenne S Dashboard Material Failure Vehicle Identification: VIN [XXX] , Current Odometer: 46639 Assessment Date: 12/11/2025 Evaluator: [XXX] , Registered Owner/Operator ________________________________________ EXECUTIVE SUMMARY The dashboard upper assembly in this vehicle exhibits progressive adhesive delamination and synthetic leather separation (colloquially “bubbling”) across the instrument cluster housing and passenger airbag deployment zone. This defect, while initially cosmetic, presents measurable safety risks under Federal Motor Vehicle Safety Standards (FMVSS) by compromising passive restraint systems, driver visibility, and interior structural integrity during collision events. The failure pattern is consistent with documented manufacturing defects affecting 2018-2022 Cayenne production units. ________________________________________ TECHNICAL ANALYSIS Defect Manifestation: •Multi-point adhesive failure between dashboard substrate and synthetic leather wrap •Bubbles ranging 2-8cm diameter directly above passenger-side airbag module •Progression rate: 15% surface area increase over 4-month observation period •Material: Thermoplastic olefin (TPO) substrate with polyurethane coating exhibiting UV-degradation and outgassing Root Cause: Inadequate adhesive curing during manufacturing combined with incompatible material expansion coefficients, resulting in progressive de-lamination under thermal cycling. ________________________________________ SAFETY CONCERNS 1. PASSENGER AIRBAG DEPLOYMENT (FMVSS 208 Violation Risk) 2. DRIVER VISIBILITY IMPAIRMENT (FMVSS 101 Violation Risk) 3. INTERIOR STRUCTURAL INTEGRITY (FMVSS 201/214) 4. SECONDARY PROJECTILE HAZARD 5. OCCUPANT HEALTH & COGNITIVE LOAD This defect constitutes a latent safety hazard that degrades over time, not a static cosmetic issue. The combination of airbag deployment trajectory interference, driver visibility impairment, structural integrity compromise. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FO