2018 Porsche Macan Owner Complaints

The contact owns a 2018 Porsche Macan. The contact stated that while the contact's wife was driving at an undisclosed speed, the contact's wife noticed an unusual odor in the interior and the exterior of the vehicle. In addition, the contact inspected the vehicle and noticed a fuel leak on the ground underneath the vehicle. The contact stated that the failure was persistent. The contact stated that the vehicle was a fire hazard and unsafe to drive. The dealer was made aware of the failure. The contact was informed of NHTSA Campaign Number: 20V077000 (Fuel System, Gasoline) however the VIN was not included. The contact was advised to contact the NHTSA Hotline to report the failure. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 44,920.

NHTSA ID

11742714

Incident

May 25, 2026

Mileage

44,920 mi

My fiancé was driving the car normally on the elevated interstate at about 130 in the morning central time on Monday, April 20 when the suddenly burst into flames! The entire vehicle is destroyed bumper-to-bumper the fuel pump on these models are apparently reason for recalls because of this exact reason.my fiancé's life was endangered because of this fire.thank Goodness there was no collision.police inspected and towed the vehicle

NHTSA ID

11732582

Incident

Dec 31, 1969

Air bag light turns to "off" despite passenger sitting in seat. Took car to dealer (Bill Pearce Motors) who "verified customers concern" and "found fault present for passenger seat mat resistance to high" with a recommendation to replace "seat mat and module." This is at our expense (quote of $3700) and two trips to the dealer, being charged diagnostic fee each time. It is noted that a previous recall exists for this issue, however, it did not cover this vehicle. NHTSA ID 21V-131

NHTSA ID

11721323

Incident

Feb 18, 2026

I am writing to formally submit a safety complaint regarding my 2018 Porsche Macan. I have experienced a significant issue with the vehicle’s headlights, which I believe poses a serious safety risk. Description of the Issue: The headlights on my 2018 Porsche Macan have failed without any prior warning or indication. There were no dashboard alerts or error messages to notify me of a problem. The failure occurred suddenly while driving at night, resulting in a complete loss of forward illumination. This created a hazardous situation, as I was unable to see the road ahead and other drivers were unable to see my vehicle clearly. Safety Concerns: The headlight failure happened unexpectedly and without any warning. This issue significantly increases the risk of a crash, especially when driving at night or in low-visibility conditions. Upon inspection, I was told the entire headlight assembly would need to be replaced, which is costly and concerning for a relatively new vehicle. Request for Investigation: I am aware that other owners of the 2018 Porsche Macan have reported similar headlight failures. I urge NHTSA to investigate this matter, as it appears to be a widespread and potentially dangerous defect. Reliable headlight operation is essential for safe driving, and sudden failure without warning is unacceptable. Thank you for your attention to this matter. Please let me know if you require any additional information or documentation.

NHTSA ID

11719315

Incident

Dec 11, 2025

Engine failure

NHTSA ID

11718308

Incident

Feb 2, 2026

The Macan engine cooling system is defective and dangerous. It is made with a plastic cooling lines that are poorly placed (and concealed) where they are subject to high heat and pressure and therefore break suddenly. The danger is that it happens suddenly and you have to pull over right away even in dangerous road situations to avoid complete engine damage/failure. My husband and I drove the Macan to Mammoth Lakes for instance for the holidays and had to pull over in a dangerous side of a windy cliff, which posed great risk to our safety. Not to mention the difficulty and danger for a tow truck to access us. It was further pitch dark and snowing. We waited hours for the tow truck which thankfully came but we easily could have had to spend the night in a dangerous spot. Porsche should have let its customers know about this vulnerability so we could have changed these plastic lines even at our cost to avoid such a possible situation. They were sued for this same defect on the Cayenne. It's something I would have paid for and changed but they are not wanting to publicize this dangerous issue. They are putting customers' lives at risk. When we were (luckily) towed to Mammoth, Mammoth does not have the Porsche parts nor many mechanics so the mechanic (who was booked out for weeks) there did a temp fix and we risked our lives on the way back as well. We paid around $700 for the temporary repair and maybe another $1341 for the permanent change of the lines when we returned. This is a serious problem. We need to be able to trust otherwise reputable manufacturers like Porsche and our government entities. Happy to provide receipts. This vehicle needs to be recalled. At very least, the customers need to know about the issue because the plastic cooling tubes are concealed and not obvious. Further the lines cannot be replaced where the vehicle stalled and have to be towed to a mechanic.

NHTSA ID

11707892

Incident

Oct 30, 2025

Upon routine 80k service, discovered that steering wheel column loose due to faulty bushings. Individual bushings could be replaced but manufacturer insists that entire steering column needs replacement. Manufacturer should provide replacement bushings for technician to replace instead of entire column. This is simply an 8mm plastic piece!

NHTSA ID

11683624

Incident

Aug 28, 2025

My vehicle is experiencing the following fuel system issue listed below in the NHTSA campaign. Porsche will not recognize my vehicle as being part of this recall issue, and this is a significant safety issue for my family. Your help in rectifying this situation would be greatly appreciated. NHTSA CAMPAIGN ID: 20V077000 Report Date: FEB 11, 2020

NHTSA ID

11623254

Incident

Nov 2, 2024

OIl leak from "Brocken aluminum bolts" that do not hold up and are failing to hold up from basic car use. A safety recall on this manufacturing parts issue should have been mandatory back in 2015. When this issue started and Macan 2015-2022 all have this issue and are now been replaced with steel bolts. It is costing consumers $2000-$8000 in repairs do the safety issues of bad manufacturing of bolts used . [XXX] Sounds similar to the fiasco with the 958.1 gen Cayenne V8s using aluminum bolts for the Variocam adjusters in the engine which eventually resulted in a NHTSA mandated recall due to the bolt heads sometimes shearing off and causing all sorts of nastiness (my Cayenne Turbo had this recall). Of course the Cayenne's instance of using inappropriate aluminum bolts/fasteners resulted in much more serious consequences \than a just slow oil leak/seepage as is the case as its not been totally documented with the Macan V6s yet , but not good in either case. <sigh> should have recalled on all V6 MACANS also! A partial repair was done by Porsche in Sep 2023 and in [XXX] I have another oil leak from another aluminum bolt breakage . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11609210

Incident

Aug 28, 2023

265/45ZR20 104Y Tire shop has been unable to balance tire since there's a defect with the brand new tire itself. Vehicle vibrates excessively at highway speeds, feels unsafe to drive. I've reached out to vendor for tire replacement and hasn't made an effort to replace tire in a timely manner. I use my vehicle everyday. Tires were purchased from tireagent.com

NHTSA ID

11604472

Incident

Jul 24, 2024

The leather on the dash board shrunk and the glue failed allowing the leather to buckel and block the passenger air bag top of the dash board. Porsche knows if this and refused to repair except at my costof $9,000. Also the flap of rhe dash block visibility forward

NHTSA ID

11597554

Incident

Jun 7, 2024

Rear camera and vehicle proximity sensors are not working Due A Flaw with water moisture entering the rear cabin where modules are located. This us a common problem with this vehicle.

NHTSA ID

11575493

Incident

Feb 10, 2024

The airbag light came on in the vehicle. We took it into the dealership, they said we need a passenger airbag sensor mat and seat cushion for the passenger seat airbag system. This item was recalled in 2018 Porche Macon NHTSA Campain ID 21V131000/Recall AMA2. Porche said since our VIN was not included in the recall we have to pay to fix it. They said the only way to get our VIN added was to contact NHTSA. The quote to fix an item that has been recalled was over $1,800. It doesn't seem fair to have to pay for something that has been recalled for this car and is known to be defective. The vehicle is ready for inspection anytime. The passenger safety is at risk as defined by the recall. "The air bag will not deploy during a crash if a front passenger is undetected, increasing the risk or injury." The problem first appeared last year around May 2023 and it took a while to get an appointment at the dealership. I was not aware of this recall until today when I did a Kelly Blue Book value on the vehicle. I just called Porche and they said there is nothing they can do and to contact NHTSA to get our VIN added to the recall list. Attached is the repair estimate from the Porche dealership.

NHTSA ID

11573773

Incident

May 20, 2023

The passenger airbag light always indicates that no one is sitting in the passenger seat even when it is occupied. This is apparently the same issue other 2018 Porsche Macan's have had but for some reason my car is not included. This is the same as the AMA2 airbag/SRS Fault - DTC B102204. recall.

NHTSA ID

11570051

Incident

Feb 5, 2024

The contact owns a 2018 Porsche Macan. The contact stated that while driving at an undisclosed speed, the front passenger’s side seat belt alert was inoperable. The contact stated that while a passenger was seated in the front passenger’s side seat without the seat belt buckled, the seat belt alert failed to activate. The vehicle was taken to the dealer and the contact was informed that the feature was not installed in the vehicle when the vehicle was manufactured. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 27,000.

NHTSA ID

11566957

Incident

Jul 22, 2020

Mileage

27,000 mi

The contact owns a 2018 Porsche Macan. The contact stated that there was an abnormally strong fuel odor coming from the vehicle while driving and while the vehicle was parked. The vehicle was taken to the dealer, where it was diagnosed that fuel was leaking from the fuel pump. The dealer drained the fuel tank and replaced the fuel pump. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 94,000.

NHTSA ID

11563157

Incident

Dec 15, 2023

I own a 2018 Macan GTS and the passenger airbag sensor was defective. My VIN was not covered by the NHTSA’s recall (21V131000) thought it is the same part that was defective and is the same make/model/year. I have submitted a request to Porsche for reimbursement for the repair, but they have denied my request without explanation.

NHTSA ID

11558577

Incident

Nov 17, 2023

Forgot case number with Porsche it is 800053607 Porsche says car is unsafe to drive. My case number with NHTSA is 11522971

NHTSA ID

11522972

Incident

Feb 20, 2023

While in Dallas TX on Feb 23 2023 I took my car to dealer air bag light came on. Issue was seat belt sensor defective part number 95B 881 256 BA repair set seat occupancy sensor. Found out there are several Macan GTS 2018 same problem.

NHTSA ID

11522971

Incident

Feb 20, 2023

I’m filing this complaint because I signed a contract for the purchase of my second vehicle (a Porsche Macan 2018) using my own financing on August 23rd 2022 with a auto dealership (“Ocean Mazda”) and the auto dealership waited 3 months to submit the final required bank “Dealer Funding” document necessary for funding in order to force me to secure dealer financing. In August of 2022 I purchased 2 vehicles with Ocean Mazda of Doral, Florida. I purchased a Maserati on August 4th 2022 and a Porsche Macan on August 23rd 2022. During the time of purchasing the vehicle Ocean Mazda representatives continuously asked if i was interested in securing dealer financing instead of using my own financing for both vehicles. On August 4th 2022 i signed a contract for the purchase of a 2019 Maserati using my own financing with Ocean Mazda successfully submitting the required dealer fund bank document in order to secure funding; while continuously questioning if i was interested in deal funding throughout the process. On August 23rd 2022 i signed a contract for the purchase of a 2018 Porsche. Ocean Mazda did not submit the dealer funding document and waited 3 months in to secure dealership financing for the purchase of the vehicle. The dealership called to say that the financing fell through, and dealership financing was the only other option too sign a dealership financing agreement or return the vehicle back to Ocean Mazda; if not, then the vehicle would be report stolen. I’m filing this complaint because I signed a contract for the purchase of a vehicle using my own financing and the auto dealership waited 3 months to submit the final required bank “Dealer Funding” document necessary for funding in order to force me to secure dealer financing.

NHTSA ID

11494272

Incident

Aug 4, 2022

The steering of the vehicle completely failed while driving. The steering column detached from the steering rack and steering the vehicle was no longer possible. There was no warning and its only by luck that nobody was killed. The defect was confirmed and repaired by the dealer. There is a single bolt that attaches the column to the rack, which if not torqued properly can fall out and lead to this complete failure of steering. I reported to incident to the manufacturer, but they have not responded to my case at all. Please also see: NHTSA Campaign Number: 21V493000 for exact same issue with different model/year. This is a much larger issue that originally thought and has a very high chance of death or injury especially for a high performance vehicle.

NHTSA ID

11494148

Incident

Oct 3, 2022

On November 26, 2021 I brought the vehicle in for service due to an airbag warning light. The dealer informed me that the front seat passenger occupancy sensor mat was faulty and must be replaced. The dealer disconnected the seat sensor, thus removing the air bag safety protection system for front seat passenger as the instrument panel shows no occupant in front passenger seat. I have repeated called the dealer only to be told the part was on back-order, but that was four months ago. I have also reached out to Porsche and they where not helpful. My concern is, in the vent of an accident, that the front seat passengers injuries could be fatal.

NHTSA ID

11456608

Incident

Nov 26, 2021

The contact's wife owns a 2018 Porsche Macan. The contact received notification of NHTSA Campaign Number: 21V131000 (Air Bags). The dealer was contacted and informed the contact that the parts were unavailable despite having received a letter stating otherwise. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect. Consumer has stated since March 24th,2022 nothing has been done.

NHTSA ID

11446123

Incident

Apr 30, 2021

I purchased this vehicle from The Collection Dealer Coral Gables, Florida. I brought the car in to have them check the brake pedal travel. It seems to me that the brake pedal response to applying the brakes is spongy or too much travel. It feels like the lines have air in them. The Service advisor says it is normal for this Macan S to feel that way. I still don't think is right. Also, it has been a few times when I am parking the car seems like it wants to accelerate all by itself and I have to apply the brakes not to go over the parking spot stopper or if inside my garage, not to go thru the wall and end up inside my living room.

NHTSA ID

11444460

Incident

Apr 1, 2021

I cannot use my car for fearing of legal actions if I put anybody onto the front passenger seat. This recall has been on since April this year— that’s almost 5 months. I’ve contacted the Porshe dealership so many times and they still haven’t received the parts from the manufacturer.

NHTSA ID

11434375

Incident

Jun 22, 2021