2007 RAM 3500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2007 RAM 3500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical337.5%
- Steering225.0%
- Engine112.5%
- Fuel system112.5%
- Exterior lighting112.5%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
Steering components broke when turning the truck around, this happened 30 miles up a Forest service rd. while out sightseeing. Had to be towed a long way ($1200) for the towing. and the steering repair for $1150.00, if this would have happened at speed when we were towing our camper it would have been terrible. This truck has no off-road usage other than for snow. Head light low beam on the drivers side stopped working, traced the wire back to the TIPM and there is no power coming out for this wire. Reading up on this issue it seems to be a very standard problem in 2006 and above trucks. This should be a recall item as it can cause serious problems when driving at night or in bad weather. I have seen that the Tipm has been recalled on only certain models, this makes no sense to me. There were no warnings on either of these failures. The TIPM headlight problem is in the Dodge shop now trying to be resolved, the steering was repaired at another shop as we were out of town.
Check engine light has gone on intermittently. Have had it checked with no reason for the code. No sign that it was the engine harness. Contacted dealership and they explained they couldn't look at it for 3 weeks. Brought it to another mechanic and replaced computer. a week later it damaged that computer. I called dealership and they again advised there wad no way to have it towed in for at least 3 weeks. Only 1 diesel mechanic present. Had diagnostics run again and was diagnosed as engine wiring harness. Engine wire harness has damaged 5 computers. While driving vehicle, it suddenly cuts off, with warning lights on, power steering will not work. There is no warning to this happening. It has happened several times on the road, but would restart while still rolling. Now, there are no replacement wiring harness available to purchase. This is only a 2007.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
Steering components broke when turning the truck around, this happened 30 miles up a Forest service rd. while out sightseeing. Had to be towed a long way ($1200) for the towing. and the steering repair for $1150.00, if this would have happened at speed when we were towing our camper it would have been terrible. This truck has no off-road usage other than for snow. Head light low beam on the drivers side stopped working, traced the wire back to the TIPM and there is no power coming out for this wire. Reading up on this issue it seems to be a very standard problem in 2006 and above trucks. This should be a recall item as it can cause serious problems when driving at night or in bad weather. I have seen that the Tipm has been recalled on only certain models, this makes no sense to me. There were no warnings on either of these failures. The TIPM headlight problem is in the Dodge shop now trying to be resolved, the steering was repaired at another shop as we were out of town.
TL* THE CONTACT OWNS A 2006 (NA) RAM 3500. WHILE THE VEHICLE WAS MAKING A RIGHT TURN AT A TRAFFIC LIGHT, THE PASSENGER SIDE TIE ROD SNAPPED OUT OF THE SOCKET. AS A RESULT, THE VEHICLE LOST STEERING ABILITY. THE VEHICLE WAS TOWED TO BOULDER CHRYSLER DODGE RAM (3200 28TH ST, BOULDER, CO 80301, (303) 442-1687) AND THE FAILURE WAS CONFIRMED. THE DEALER REPLACED ALL OF THE STEERING COMPONENTS FOR $1,500. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE WARRANTY WAS EXPIRED. THE CONTACT WAS REFERRED BACK TO THE DEALER. THE FAILURE MILEAGE WAS 56,256.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
Check engine light has gone on intermittently. Have had it checked with no reason for the code. No sign that it was the engine harness. Contacted dealership and they explained they couldn't look at it for 3 weeks. Brought it to another mechanic and replaced computer. a week later it damaged that computer. I called dealership and they again advised there wad no way to have it towed in for at least 3 weeks. Only 1 diesel mechanic present. Had diagnostics run again and was diagnosed as engine wiring harness. Engine wire harness has damaged 5 computers. While driving vehicle, it suddenly cuts off, with warning lights on, power steering will not work. There is no warning to this happening. It has happened several times on the road, but would restart while still rolling. Now, there are no replacement wiring harness available to purchase. This is only a 2007.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
NO THROTTLE, TPS CHANGED OUT 4 TPS S MERGING INTO INTERSTATE, THROTTLE FAILED- 18 WHEELER UP MY @$$. MATTER OF TIME, SERIOUS CHAIN OF EVENTS...NO THROTTLE, NO POWER,NO GO PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Too few reports in this category for a page of its own — they appear in the full complaint list.
Exterior lighting
Reports naming headlights, tail lights, turn signals and other exterior lighting.
From owner reports, verbatim
Steering components broke when turning the truck around, this happened 30 miles up a Forest service rd. while out sightseeing. Had to be towed a long way ($1200) for the towing. and the steering repair for $1150.00, if this would have happened at speed when we were towing our camper it would have been terrible. This truck has no off-road usage other than for snow. Head light low beam on the drivers side stopped working, traced the wire back to the TIPM and there is no power coming out for this wire. Reading up on this issue it seems to be a very standard problem in 2006 and above trucks. This should be a recall item as it can cause serious problems when driving at night or in bad weather. I have seen that the Tipm has been recalled on only certain models, this makes no sense to me. There were no warnings on either of these failures. The TIPM headlight problem is in the Dodge shop now trying to be resolved, the steering was repaired at another shop as we were out of town.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .