2018 RAM 4500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2018 RAM 4500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes758.3%
- Driver assistance18.3%
- Engine18.3%
- Other / unspecified18.3%
- Powertrain (other)18.3%
- Steering18.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
The contact owns a 2018 Ram 4500. The contact received notification of NHTSA Campaign Number: 24V896000 (SERVICE BRAKES, HYDRAULIC). However, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the message to "Check ABS" was displayed with an abnormal beeping sound. The local dealer was contacted and confirmed that the part was not yet available for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 50,000.
The contact owns a 2018 Ram 4500. The contact received notification of NHTSA Campaign Number: 24V896000 (SERVICE BRAKES, HYDRAULIC). However, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. The vehicle was parked and was no longer driven due to safety concerns.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
Nov 27,2024 Manufacturer Recall NumberC4B NHTSA Recall Number24V-896 Recall Status Recall Incomplete, remedy not yet available Still no repair for defective parts. Over years.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
The contact owns a 2018 Ram 4500. The contact stated that while driving 40 MPH, the check engine warning light and other unknown warning lights were illuminated, before the vehicle lost motive power. The vehicle was taken to a dealer, where it was diagnosed that the turbo had failed, and there were 39 diagnostic trouble codes retrieved. The dealer determined that the turbo, the intake manifold sensor, the exhaust pressure sensors, and other unknown parts needed to be replaced. The vehicle was repaired; however, the failure reoccurred four months later. The contact received notification of NHTSA Campaign Number: 24V896000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. Additionally, the contact stated that while driving 15 MPH to park the vehicle, while her husband and dog were occupying the passenger’s side seat, the brake pedal was depressed, but the vehicle failed to respond and struck one of the contact's parked vehicles. The contact stated that the dog sustained injuries after being thrusted forward. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was unknown.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
4X4 DRIVE SHAFT FAILED. WHILE TRAVELING ON INTERSTATE THE FRONT DRIVE SHAFT BROKE AT THE U-JOINT. I'VE ONLY USED THE 4 WHEEL DRIVE OPTION 2-3 TIMES AND THE TRANSFER WAS IN 2H AT TIME OF FAILURE. FRONT ALUMINUM WHEELS FRACTURED. BOTH FRONT WHEELS GOT HAIRLINE CRACKS. ONE AT ABOUT 145K MILES AND THE OTHER AT ABOUT 160K. 90% OF MILES ARE HIGHWAY MILES.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
4X4 DRIVE SHAFT FAILED. WHILE TRAVELING ON INTERSTATE THE FRONT DRIVE SHAFT BROKE AT THE U-JOINT. I'VE ONLY USED THE 4 WHEEL DRIVE OPTION 2-3 TIMES AND THE TRANSFER WAS IN 2H AT TIME OF FAILURE. FRONT ALUMINUM WHEELS FRACTURED. BOTH FRONT WHEELS GOT HAIRLINE CRACKS. ONE AT ABOUT 145K MILES AND THE OTHER AT ABOUT 160K. 90% OF MILES ARE HIGHWAY MILES.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
See attached document for complaint.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .