2015 RAM 5500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2015 RAM 5500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine526.3%
- Electrical421.1%
- Tires & wheels210.5%
- Other / unspecified210.5%
- Powertrain (other)210.5%
- Brakes15.3%
- Steering15.3%
- Fuel system15.3%
- Suspension15.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
Intake air grid heater nut came off and blew the #6 piston and engine needs to be replaced.
Vehicle is 2015 and has 44.4k miles on it. Had it in for a routine oil change and the mechanic showed me that the oil pan is in extremely poor condition with multiple rot spots all over and could fail at anytime. Mopar extended warranty covers oil pans, but they dont cover rust. An oil pan is a static part, the only way it could fail is from rust or a catastrophic engine failure where a connecting rod may protrude through it. Seems to be a common problem with these oil pans failing at a high rate. I have a 1977 chevy 289k miles with no problems on that oil pan. Perhaps the metal used in production was of poor quality which caused premature and expedited corrosion.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
HAVE HAD SHIFTING ISSUE'S IN THE PAST, REPAIR UNDER WARRANTY WAS TRANS SOLENOIDS. NOW, OUT OF WARRANTY, IT'S THE TRANS WIRING HARNESS.
THE DPF FILTER IS SAYING THAT ITS CLOGGED AND IT WON'T REGIN. CODES: P0234, P24A2,P0420,P0087,P2228,P1193,P243F,P0102,P203F,P2280
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
The contact owns a 2015 Ram 5500. The contact stated while driving 69 MPH, the vehicle started vibrating abnormally with abnormal sounds coming from the vehicle. There was no warning light illuminated. The contact was able to park on the side of the road, exited the vehicle, and noticed transmission fluid leaking underneath the vehicle. The contact stated that the transfer case was fractured. The contact was unable to restart the vehicle. The contact stated that the fuel rail, Service 4-WD, and the braking system messages were displayed. The vehicle was not drivable. The contact towed the vehicle to an independent mechanic and was informed that the transfer case needed to be replaced. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 137,000.
FRONT TIRES. TIRES WEAR UNEVEN. MOSTLY PASSENGER SIDE. CUPPING OF OF BOTH. NOTICEABLE VIBRATION. SAME THING HAPPENED WITH MY 2011 MODEL OF THE SAME VEHICLE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
While traveling on a highway at speeds in excess of 50mph the 2015 Ram 5500 lost the rear set of dual tires on the passenger side. The wheels came off after all 10-wheel studs failed and broke off. This is the second incident on this same truck despite going through the warranty process and procedures through Stellantis/Ram. No incident or injuries resulted from the failure.
FRONT TIRES UNEVEN WEAR, TIRE CUPPING. VIBRATION AND NOISY!
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
HAVE HAD SHIFTING ISSUE'S IN THE PAST, REPAIR UNDER WARRANTY WAS TRANS SOLENOIDS. NOW, OUT OF WARRANTY, IT'S THE TRANS WIRING HARNESS.
TRUCK WAS ON HIGHWAY GOING 70 MPH. DRIVER SAID IT STARTED SHAKING VERY HARD AND THEN HEARD A VERY LOUD BANG. WAS ABLE TO KEEP IT UNDER CONTROL AND BRING IT TO A STOP. THERE WERE PARTS OF THE TRANSFER CASE ALL OVER THE ROAD. DRIVE SHAFT WAS BENT AT A 45 DEGREE ANGLE. WIRING WAS WRAPPED AROUND YOKE, UNDERNEATH OF CAB IS DAMAGED, BRAKE SYSTEM DAMAGED, DEF SYSTEM DAMAGED, ALONG WITH OTHER PROBLEMS THAT CANT BE SEEN.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
TRUCK WAS ON HIGHWAY GOING 70 MPH. DRIVER SAID IT STARTED SHAKING VERY HARD AND THEN HEARD A VERY LOUD BANG. WAS ABLE TO KEEP IT UNDER CONTROL AND BRING IT TO A STOP. THERE WERE PARTS OF THE TRANSFER CASE ALL OVER THE ROAD. DRIVE SHAFT WAS BENT AT A 45 DEGREE ANGLE. WIRING WAS WRAPPED AROUND YOKE, UNDERNEATH OF CAB IS DAMAGED, BRAKE SYSTEM DAMAGED, DEF SYSTEM DAMAGED, ALONG WITH OTHER PROBLEMS THAT CANT BE SEEN.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
STEERING DRAG LINK BROKEN OFF ON PASSENGER (LONG ARM) SIDE OF ADJUSTMENT SLEEVE. NO IMPACT DAMAGE. PART APPEARS TO HAVE BEEN IMPROPERLY MANUFACTURED. ONLY APPROX 1/3 TO 1/2 OF THE ROD WAS FUSED TOGETHER (SEE PICTURE). VEHICLE WAS BACKING UP AND TURNING IN A PARKING LOT, SLIGHTLY DOWNHILL WITH SERVICE BRAKES LIGHTLY APPLIED. VEHICLE IS HEAVILY LOADED (ELECTRICAL BUCKET TRUCK)
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
The contact owns a 2015 Ram 5500. The contact stated while driving 69 MPH, the vehicle started vibrating abnormally with abnormal sounds coming from the vehicle. There was no warning light illuminated. The contact was able to park on the side of the road, exited the vehicle, and noticed transmission fluid leaking underneath the vehicle. The contact stated that the transfer case was fractured. The contact was unable to restart the vehicle. The contact stated that the fuel rail, Service 4-WD, and the braking system messages were displayed. The vehicle was not drivable. The contact towed the vehicle to an independent mechanic and was informed that the transfer case needed to be replaced. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 137,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
FRONT TIRES UNEVEN WEAR, TIRE CUPPING. VIBRATION AND NOISY!
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .