2023 RAM Promaster Steering Problems

The contact owns a 2023 Ram Promaster 3500. The contact stated that while driving 60 MPH, the steering wheel failed to turn in the intended direction. The dealer was contacted by phone and made aware of the failure. The vehicle was taken to the dealer where it was diagnosed with electronic power steering module failure. The contact was informed that the electronic power steering module needed to be replaced. The vehicle was not repaired. The contact was informed that the parts to repair the vehicle were on back order. The contact stated that the failure was a known failure with the vehicle. The failure mileage was approximately 10,000.

NHTSA ID

11765069

Incident

Jul 28, 2026

Mileage

10,000 mi

The contact owns a 2023 Ram ProMaster 2500. The contact stated that the emergency control system was inoperable. While driving 3 MPH over a bump in the roadway, the steering wheel locked up. While driving 65 MPH, the failure recurred. Additionally, while reversing, the vehicle stopped suddenly. Prior to and after the failures, an unknown yellow warning light illuminated accompanied by an abnormal dinging sound. Additional warning lights illuminated associated with the steering, hill assist, and emergency control system, and an abnormal brake odor emanated from the vehicle. The contact stated that the failure was scary and dangerous. The vehicle was taken to a local dealer, where the contact was informed that there was a reset switch, and that the contact might have jerked the steering wheel. The dealer informed the contact that the vehicle was fully inspected. The approximate failure mileage was 5,604.

NHTSA ID

11764906

Incident

Jul 31, 2026

Mileage

5,604 mi

The steering wheel bucks and becomes immovable when I’m steering. The problem is intermittent and happens primarily when driving slowly, such as getting maneuvered at a gas pump or parking. It has also happened at highway speeds when there are rumble strips, in construction zones, or broken concrete that jars the vehicle.

NHTSA ID

11763838

Incident

Sep 11, 2026

Total sudden loss of power steering

NHTSA ID

11763576

Incident

Sep 1, 2026

The contact owns a 2023 Ram ProMaster 3500. The contact stated that while driving at various speeds, the power steering suddenly failed, causing the steering wheel to jerk unexpectedly and pull out of the contact's grip. No warning lights illuminated. The dealer was notified of the failure; however, the vehicle was not taken to the dealer, diagnosed, or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 30,000.

NHTSA ID

11760012

Incident

Aug 24, 2026

Mileage

30,000 mi

While at the dealership service center, the "service electronic power steering" warning light illuminated on the dash and when driven the steering wheel began snapping back, making driving very difficult. The garage informed us that the van is considered unsafe/undriveable until fixed due to the high risk of causing an accident. Upon inspection by the service center, they stated that the steering pump was filled with water from an unknown source and that the harnesses were completely corroded. The wiring/connectors were also completely corroded and appeared to be causing the issues with steering.

NHTSA ID

11759574

Incident

Aug 17, 2026

Vehicle wheel would suddenly jerk when driving. Video of steering wheel doing this was taken while parked. The suddenness of this created immediate dangers to the driver and any around due to the unpredictability of the steering. Vehicle was brought to a dealer/service center where they diagnosed a corroded wire harness that required the entire steering rack to be replaced. There were no warnings or dash lights on. Vehicle is still at the service center four weeks later because the wire harness is unavailable and the vehicle cannot be safely driven.

NHTSA ID

11758012

Incident

Jul 16, 2026

The Electronic Power Steering (and EPS Module) failed, making it incredibly hard to steer especially at low speeds. Dealer confirmed that the power steering rack has failed. All power steering features and lights came on, rendering the vehicle inoperable while driving doen the road. This is a serious safety concern.

NHTSA ID

11757934

Incident

Aug 11, 2026

Power steering electrical connector(s) completely corroded from moisture intrusion, while driving ps shut down and warning light flashed. Had to suddenly correct in a corner without ps, almost had an accident. It is available for inspection, as I cannot afford to fix this yet. Dealer inspected problem, ps rack and harness need replacement at a cost of appr. CAD $4000-5000. Have not contacted manufacturer yet, but will now. Vehicle warranty just expired and has only 26 k km on it.

NHTSA ID

11757498

Incident

Aug 3, 2026

Sometimes while driving I experienced my powered steering cut out while taking a ramp on/off of the highway, and sometimes when i was trying to park and back up into a parking space while steering at the same time. When the power steering cut out I got lights for "Service Power Steering", "Service ESC", and "Service Hill Assist" all at the same time, and once i got a power steering light. I looked up the issue and found that there is an active preliminary investigation going on for the same issue on the same vehicle, the investigation coded PE26002. Once I handed the vehicle over to the dealer, they found that the power steering had an open circuit on the steering gear. Once they took the connector off they found that the connector was corroded and the wires were burned on the steering gear and main harness side. I had to have them replace both the steering rack, and the main harness.

NHTSA ID

11756825

Incident

Jul 21, 2026

As I was driving, the steering wheel just jerk and the anti-slide feature came on and swerved me into another lane without me wanting to do so

NHTSA ID

11754283

Incident

Aug 1, 2026

Due to the loss of power steering the tech at Rainier Dodge of Olympia performed electrical testing per diagnostic chart and found water intrusion into steering harness that has corroded wiring from the body harness into electric steering gear motor/module unit. The electric power steering gear assembly and harnesses must be replaced. The vehicle recieved a fault code U0140 stating loss of communication with body control module.

NHTSA ID

11753058

Incident

Jul 21, 2026

Power steering failure. Power steering comes and goes while driving creating a crash risk. Yes, the problem has been confirmed by dealer Only inspection by dealership No warning lamps or messages.

NHTSA ID

11752569

Incident

Jul 1, 2026

The contact owns a 2023 Ram Promaster 2500. The contact stated that while driving approximately 65 MPH, the message “Power Steering Service” was displayed with a high-pitched whining sound coming from underneath the hood and the dashboard. The vehicle was taken to the dealer, who diagnosed that the steering gear EPS module and jumper harness needed to be replaced, and the vehicle needed an alignment. The vehicle was not repaired. The contact researched online and associated the failure with NHTSA Action Number: PE26002 (Steering, Electrical System). The manufacturer was not informed of the failure. The failure mileage was approximately 40,000.

NHTSA ID

11751462

Incident

Jul 9, 2026

Mileage

40,000 mi

Steering Rack and Pinion failure due to corroded electrical connection plug. This occurred in april, 2025, when the van had less than 15,000 miles on it. Took the van to Blue Ridge Chrysler Dodge dealership in Abingdon Va .for Warranty repair. Plug was taken off another vehicle to put on mine aaaand dielectric grease added to hopefully keep the replacement plug from corroding too. Location of plug makes it susceptible to water infiltration, a definite design flaw that is likely to cause trouble again in the future.

NHTSA ID

11751417

Incident

Apr 14, 2025

While driving, a “Service ESC” warning message appeared and the vehicle suddenly lost power steering assist, causing the steering to become extremely difficult and creating a serious safety risk while the vehicle was in motion. The vehicle was taken to a service center, where technicians found multiple loss-of-communication codes involving the electronic power steering system. Further inspection found the main electronic power steering connector full of water and corroded. The technician documented that water intrusion caused excessive damage to the electronic power steering terminals at the rack-and-pinion assembly. The water intrusion appears consistent with a failure or inadequacy of the sealing intended to protect the electronic power steering connection from moisture. Due to the extent of the corrosion and damage, the affected wiring harnesses and rack-and-pinion assembly had to be replaced, followed by a wheel alignment. This failure resulted in a sudden loss of power steering assist while the vehicle was being driven.

NHTSA ID

11750986

Incident

Jun 15, 2026

I started having issues with the power steering. It started when I was leaving work about a month ago. Pulling out of the parking lot,it starting pulling to the left, when I was turning right. I got home and started looking for the power steering fluid tank, and couldnt find it. It was fine for a few days after that. Then I was making a right hand turn, it felt like it starting resisting the turn and tried to straighten out halfway through the turn. Another time, I was going around a left hand curve, maybe 45 mph, it fought back and pulled to the right. I have had a couple other issues, along the same lines over the last month between 5 and 45 mph. I was looking up information on the power steering, finally found it in the owners manual, that I have electric power steering.

NHTSA ID

11748387

Incident

Jun 10, 2026

The contact owns a 2023 Ram Promaster 2500. The contact stated that while driving at various speeds, the vehicle lost power steering assist with several unknown warning lights, and the check engine and parking assist warning lights were illuminated. The contact was forced to restart the vehicle to resume normal operation. The vehicle was initially taken to the dealer where the wiring harness was replaced; however, the failure returned soon after the repair. The vehicle was taken back to the dealer where several parts including the steering sensor and steering column were replaced; however, the failure returned weeks later after the repair. The manufacturer was notified of the failure. The vehicle was not repaired and remained with the dealer. The failure mileage was approximately 33,000.

NHTSA ID

11744172

Incident

Feb 1, 2026

Mileage

33,000 mi

Power steering harness has leak. Wiring is faulty

NHTSA ID

11742542

Incident

May 28, 2026

Loss of power steering while driving vehicle at different speeds ( when starting from a stopped position, also at speeds from 20 to 40 mph ) when trying to turn vehicle. Steering wheel pulses and shakes and is extremely hard to turn.

NHTSA ID

11742464

Incident

Jun 4, 2026

I was driving on the highway when my steering wheel pulled to the right and almos made me crash into the concrete retainer, i had to fully stop my van in the middle of the highway The steering wheel locks and pulls to the opposite side where you wanna turn i cant use my vehicle like this i seen that a lot of people are dealing with this problem and is not safe!

NHTSA ID

11741049

Incident

May 29, 2026

Intermittent failure of the electronic power steering

NHTSA ID

11740200

Incident

May 8, 2026

The vehicle's power steering does not work properly, especially at slow speeds and when attempting to back up. However, it has also failed while traveling on the interstate highway at high speeds. When you attempt to make a turn, the power steering feels like it is fighting you and wants to pull the vehicle back in the opposite direction. I took the vehicle in to be serviced, and they replaced the battery which removed previous warning messages. On two occasions, while traveling at slow speeds and making a turn into a shopping center parking lot, the vehicle resisted my attempt to make the turn such that had a car been coming out of the parking lot, rather than complete the turn, I would have run directly into the side of the other vehicle. While travelling on the interstate at 70 mph, I momentarily lost steering and had there been vehicles behind or beside me at the time, I believe it would have resulted in an accident. Fortunately, the cruise control simultaneously shut off.

NHTSA ID

11739818

Incident

Apr 19, 2026

The vehicle experienced a loss or severe reduction of power steering assist. The steering became very difficult to turn, creating a safety concern while operating or maneuvering the vehicle. The issue appears to involve the electric power steering system, steering rack/rack-and-pinion, and/or related electrical harness or connector. The problem occurred on or about 05/21/2026 at approximately 49000 miles.While driving. The vehicle was inspected by dealer, The diagnosis was harness/connector issue, corrosion/water intrusion, power steering module connector issue. The repair estimate/repair involved $4800. I am concerned this may be related to NHTSA investigation PE26002 involving 2022–2023 Ram ProMaster power steering assist failure and possible water intrusion into the power steering module connector.

NHTSA ID

11739513

Incident

May 21, 2026

Steering system failed while driving. Mechanic reported corrosion in wiring caused multiple failures in steering system and will cost $4800 to repair.

NHTSA ID

11732476

Incident

Apr 10, 2026