2002 Saab 9-5 Owner Complaints

THE ENGINE ON MY 4 CYLINDER SAAB 9-5 (2002) HAS SUDDENLY STOPPED WHILE DRIVING AT LEAST 4 TIMES SINCE OWNING THE CAR, BOTH ON THE HIGHWAY AND IN SLOWER TRAFFIC. THE FIRST TIME I REPORTED OFFICIALLY (2007) TO THE DEALER, "NO CAUSE WAS IDENTIFIED." I NOTICED THE LAST TIME THAT IT HAPPENED (AROUND MAY 2011) THAT IT SEEMED TO COINCIDE WITH INADVERTENTLY BUMPING INTO THE IGNITION SWITCH LIGHTLY WHILE DRIVING. THE SYMPTOMS MATCH THAT OF ANOTHER OWNER'S COMPLAINT ON THIS SITE FOR THE 2002 SAAB 9-5. I EXPECTED MY CAR TO BE INCLUDED IN THE RECENT RECALL INVOLVING THE FAULTY IGNITION SWITCH BUT GOT NO NOTIFICATION. I HAVE ALSO PAID IN JUNE 2008 AND AGAIN IN OCTOBER 2009 AND JANUARY 2013 TO REPLACE/RESET A FAULTY IGNITION CASSETTE, WHICH I BELIEVE SHOULD HAVE BEEN PART OF A RECALL CAMPAIGN AND NOT CHARGED TO ME, BUT THE PARTS WERE NOT INCLUDED IN THE RECALL. IN SUMMARY, DUE TO THE CAR SHUTTING OFF, I FEEL IT IS NOT SAFE AND THAT IT SHOULD BE INCLUDED IN THE RECENT GMC RECALL. AND THAT THE FAULTY IGNITION CASSETTE SHOULD HAVE BEEN RECALLED AND NOT REPLACED AT OWNER EXPENSE MULTIPLE TIMES. I HAVE DOCUMENTED SERVICE RECORDS OF THE ABOVE INCIDENTS. *TR

NHTSA ID

10596487

Incident

Aug 10, 2007

Mileage

53,200 mi

IGNITION SWITCH SHUT OFF WHILE ON A BUSY HIGHWAY TWICE! ONCE IN 2006 AND ONCE LATER ANOTHER YEAR PLUS ONCE IN A DRIVEWAY (CAR PURCHASED USED IN THE FALL OF 2005). THE SAAB SWITCH IS LOCATED IN THE CENTER CONSOLE AND IF IT IS HIT IT SWITCHES OFF AND SHUTS DOWN THE CAR, SAME AS RECALLED SWITCHES IN OTHER GM CARS. VERY DANGEROUS ON THE HIGHWAY, BUT I WAS LUCKY AND ABLE TO STEER TO THE SIDE WITHOUT A CRASH. THERE SHOULD HAVE BEEN A LOCK MECHANISM TO PREVENT IT FROM HAPPENING. IT NEVER OCCURRED TO ME TO REPORT IT THOUGH IT IS DEFINITELY A SAFETY HAZARD IN A WHAT WAS AT THE TIME A GM OWNED PRODUCT. I STILL OWN THE CAR AND DRIVE IT DAILY ON THE SAME HIGHWAY, HOWEVER AM VERY MUCH AWARE OF THE ISSUE. I WASN'T AWARE OF WHAT CAUSED THE SHUT DOWN UNTIL IT HAPPENED THE SECOND TIME A FEW MONTHS AFTER THE FIRST TIME. YOU SHOULD INCLUDE SAAB IN THE RECALL OF GM PRODUCTS. *TR

NHTSA ID

10576665

Incident

Jul 19, 2006

Mileage

40,000 mi

TL* THE CONTACT OWNS A 2002 SAAB 95. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STALLED ON A MAJOR HIGHWAY. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE FAILURE WAS DIAGNOSED BY AN AUTHORIZED DEALER WHO STATED TO REPAIR THE DIRECT IGNITION CASSETTE. THE FAILURE RECURRED MULTIPLE TIMES AFTER IT WAS REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 48000. *TR

NHTSA ID

10568730

Incident

Mar 1, 2004

Mileage

48,000 mi

ON FEB 20, 2013, I WENT TO GILLYS, A LOCAL TIRE COMPANY, SOLD ME TWO TIRES AND WELDED A CRACKED RIM. ON MAR 2, 2013 THE TIRE BLEW OUT AND UPON INSPECTION AT WALMART AUTOMOTIVE. IT WAS DISCOVERED THE TIRE WAS ILLEGALLY PLUGGED ON INNER WALL. THE RIM HAD RECRACKED. THIS VIOLATES 49 CFR 570.10 WHEEL ASSEMBLIES. THE COMPANY THAT SOLD ME THE FAULTY TIRES WITHOUT MY KNOWLEDGE. I BELIEVED I WAS PURCHASING TWO USED TIRES WITHOUT PLUGS, BUT RECEIVED TWO TIRES WHICH SHOULD NEVER BE ON THE ROAD. ONCE I NOTIFIED THE TIRE SHOP, THE OWNER DISPUTED THE FINDINGS DESPITE TWO LETTERS FROM SEPARATE TIRE SHOPS. *TR

NHTSA ID

10503504

Incident

Mar 2, 2013

Mileage

114,580 mi

HELLO...I NEED TO ASK FOR YOUR HELP. I HAVE A 2002 SAAB 9-5 WHICH HAS A PROBLEM WITH THE FRONT PASSENGER SIDE SEAT BELT. IT DOES NOT RETRACT AND THEREFORE THE PASSENGER IS UNPROTECTED. I KNOW THAT SAAB HAS A HISTORY OF THIS BEING A PROBLEM. MY ATTEMPTS TO GET SOME HELP FROM SAAB HAVE BEEN FUTILE. IF THIS WAS A MINOR ITEM, I WOULD JUST PAY TO HAVE IT FIXED. I HAVE BEEN QUOTED $450 TO HAVE THE SEAT BELT FIXED. I CANNOT AFFORD TO PAY THAT. ISN'T THIS THE KIND OF VERY BASIC THING THAT A VEHICLE OWNER SHOULD EXPECT WHEN THEY PURCHASE A CAR? ALSO, ISN'T THIS THE VERY BASIC KIND OF THING THAT A VEHICLE MANUFACTURER IS RESPONSIBLE FOR PROVIDING TO ITS CUSTOMERS, AT A REASONABLE COST? I EXIST ON A VERY LIMITED INCOME (SOCIAL SECURITY) AND CAN'T AFFORD TO PAY $450 TO FIX THIS. IT IS A KNOWN PROBLEM IN OTHER YEARS AND MODELS OF SAAB. CAN I ASK FOR YOUR HELP IN TRYING TO GET SAAB TO CORRECT THIS SITUATION? THANK YOU. *TR

NHTSA ID

10481290

Incident

Aug 1, 2012

Mileage

125,000 mi

HAD A HEAD-ON ACCIDENT, TRAVELING APPROXIMATELY 55MPH, CAR PULLED OUT GOING ACROSS INTERSECTION, HIT HEAD-ON. SLAMMED ON BRAKES NOTICING SHE WAS GOING, AND SLAMMED INTO HER CAR, HER CAR TURNED AROUND 180 DEGS. MY AIRBAGS DID NOT DEPLOY, NOR DID THE SEAT BELT LOCK UP, WHICH ALLOWED ME TO GO FORWARD IN THE ACCIDENT. *TR

NHTSA ID

10359106

Incident

Sep 27, 2010

Mileage

128,000 mi

PASSENGER SIDE SEAT BELT. JUST RIDING DOWN THE ROAD AND HEARD A SPRING POPPING SOUND NEAR PASSENGER DOOR. THEN PASSENGER BELT WENT LIMP WITH PERSON IN THE SEAT. THE BELT HAD NO TENSION AND WOULD NOT RETRACT. CALLED DEALER AND THEY SAID NO RECALL CAMPAIGN FOR THIS PROBLEM AND I HAVE TO PAY TO REPAIR. HUGE SAFETY ISSUE THAT SHOULD BE COVERED BY MANUFACTURER AS THE PART MUST BE DEFECTIVE. *TR

NHTSA ID

10351185

Incident

Aug 17, 2010

Mileage

89,000 mi

TL* THE CONTACT OWNS A 2002 SAAB 9-5. WHILE DRIVING AT SPEEDS OF 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE LOST POWER STEERING AND BRAKING ABILITY. THE CONTACT WAS ABLE TO MOVE THE VEHICLE OFF THE ROADWAY AND RESTART THE VEHICLE. THE VEHICLE RESUMED NORMAL OPERATION UPON RESTARTING. THE DEALER WAS CONTACTED AND ADVISED THAT THE ELECTRICAL IGNITION MODULE WOULD NEED TO BE REPLACED. IN ADDITION, THERE WAS A RECALL FOR THE FAILURE YET HIS VIN WAS NOT INCLUDED IN THE CAMPAIGN (NHTSA CAMPAIGN ID NUMBER 06V410000- ELECTRICAL SYSTEM: IGNITION: MODULE. THE MANUFACTURER CONFIRMED THE DEALER'S ADVICE AND WOULD NOT PROVIDE ANY ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 103,000.

NHTSA ID

10334616

Incident

Jun 4, 2010

Mileage

103,000 mi

CAR JUST CUTTING OFF WHILE DRIVING ALMOST REAR ENDED TWO TIMES, AS HAPPENS WITHOUT NOTICE, TOOK TO SHOP, WAS DIAGNOSED AS IGNITION CASSETTE. WITCH WAS RECALLED, BUT STILL DEFECTIVE.

NHTSA ID

10307484

Incident

Jan 24, 2010

Mileage

76,400 mi

2002 SAAB 9-5 TURBO 4 CYLINDER IGNITION CASSETTE. *TR

NHTSA ID

10275497

Incident

Jun 24, 2009

Mileage

76,427 mi

WE HAVE A COMPLAINT REGARDING RECALL 05V399000 FOR OUR 2002 SAAB 9-5 AERO. OUR IDM SERIAL NUMBER FALLS WITHIN THOSE REQUIRED TO BE REPLACED BY THE RECALL. HOWEVER, SAAB WILL NOT REPLACE IT BECAUSE OUR VIN # DOES NOT FALL WITHIN THEIR RECALL. OUR IDM NEEDS TO BE REPLACED. THIS DOES NOT MAKE SENSE. OUR SAAB WAS DELIVERED IN GERMANY (IT IS US SPEC) TO A SERVICEMEMBER STATIONED THERE. WE BOUGHT IT USED WHILE STATIONED OVER THERE. NO RECALL NOTICES WERE SENT TO US OVER THERE. WE JUST STARTED GETTING RECALL NOTICES ONCE WE SHIPPED THE CAR TO THE STATES. WE HAD TO PROVIDE OUR CERTIFICATE OF ORIGIN TO SAAB. SAAB TOLD US THEY HAD NO IDEA OUR CAR EXISTED UNTIL WE GAVE THEM THE CERTIFICATE OF ORIGIN (WHICH SOUNDS FISHY). THIS RECALL WAS ISSUED BEFORE WE MOVED BACK TO THE STATES. OUR DEALERS SERVICE DEPARTMENT SAYS OUR IDM SERIAL NUMBER AND THE PROBLEM WITH IT FALL WITHIN THE RECALL. BUT SAAB WILL NOT REIMBURSE THEM FOR REPLACING IT. *TR

NHTSA ID

10261651

Incident

Aug 15, 2007

2002 SAAB 9-5 HAS HAD FAILURE OF HEADLIGHT BULBS AT A RATE OF ONE OR TWO PER YEAR FROM THE VERY FIRST YEAR I HAVE OWNED THIS CAR. NO OTHER BULB HAS BURNED OUT IN THE PAST 8 YR. A LOCAL GARAGE MECHANIC TOLD ME IT WAS RELATED TO A FAULTY FRONT ELECTRICAL HARNESS IN THE SAAB BUT THE DEALER SAID THIS WAS NOT A RECALL, EVEN THOUGH IT HAS BEEN A PROBLEM FROM THE FIRST YEAR OF OWNERSHIP. NOW I HAVE 2 HEADLIGHT BULBS BURNING OUT WITHIN ONE DAY OF EACH OTHER -- ONE HIGH BEAM, ONE REGULAR. IS THERE A RECALL OF ELECTRICAL HARNESS ON SAABS TO CORRECT FREQUENT HEADLIGHT BULB BURNOUT? SO FAR I HAVE JUST BEEN REPLACING THE BULBS AT $50/BULB AT THE RATE OF ONE OR TWO PER YEAR. *TR

NHTSA ID

10260332

Incident

Feb 27, 2009

Mileage

5,000 mi

TL*THE CONTACT OWNS A 2002 SAAB 9-5. THE CONTACT STATED THAT HE HAS NOT EXPERIENCED ANY FAILURES AT THIS TIME WITH THE AIR BAGS; HOWEVER, HE FEELS THAT THEY WILL NOT DEPLOY DURING A CRASH. HE ALSO BELIEVES THAT THEY MAY DEPLOY WITHOUT WARNING AT ANY TIME. THE AIR BAGS ARE RUNNING THROUGH A CENTRAL RIBBON CABLE AND NOTHING ELSE CONNECTED TO THAT CABLE IS FUNCTIONING PROPERLY. THE CENTRAL WARNING LIGHT IS ILLUMINATED, WHICH COULD ALSO CAUSE THE AIR BAGS TO MALFUNCTION. THE VEHICLE WAS PURCHASED TWO WEEKS AGO AND THE CENTRAL WARNING LIGHT WAS ALSO ILLUMINATED AT THAT TIME. THE DEALER DID NOT DETERMINE WHAT CAUSED THE LIGHT TO ILLUMINATE. THE CURRENT MILEAGE WAS 117,000.

NHTSA ID

10230130

Incident

May 20, 2008

LOSS OF REVERSING LIGHTS, TRUNK OPENING WARNING LIGHT AND CRUISE CONTROL FUNCTION WITH NO INTERNAL WARNING INDICATIONS. UPON INVESTIGATION, THE CAUSE WAS THE FAILURE OF TRUNK WIRING HARNESS AT 70K MILES - 2 WIRES WERE COMPLETELY SEVERED, ALL OTHERS (6) HAD LOST INSULATION. FAILURE IS AT THE FOLDING POINT JUST PRIOR TO ENTRY INTO THE TRUNK LID. CAUSE APPEARS TO BE EXCESSIVE TIGHTNESS OF THE INTERIOR WIRES. THE RUBBER BOOT WAS ENTIRELY INTACT, SEALED TO CONNECTORS IN THE BODY AND TRUNK LID AND THERE WAS NO VISIBLE INDICATION OF THE INTERNAL FAILURE. WIRES ARE SEPARATE INSIDE THE BOOT UP UNTIL THE TRUNK LID ENTRY WHERE THEY ARE WRAPPED WITH ELECTRICAL TAPE. THIS WAS DISCOVERED ONLY DURING SERVICE, NOT REPORTED BY SELF-CHECK DISPLAY WHICH ALWAYS REPORTS LIGHT BULB OUTAGES IN TEXT MESSAGES ON THE 2 LINE SAAB INFORMATION DISPLAY (SECONDARY FAILURE). PRIOR TO DISCOVERY A NUMBER OF CARS HAD ALMOST REAR ENDED THE CAR WHEN BACKING UP (REVERSING LIGHT FAILURE WAS NOT REPORTED OR KNOWN). CORRECTED TEMPORARILY BY SPLICING IN WIRES AND HEAT WRAPPING, WAITING FOR APPOINTMENT WITH THE SAAB DEALER TO REPLACE THE HARNESS. *TR

NHTSA ID

10228911

Incident

May 15, 2008

Mileage

69,500 mi

TL*THE CONTACT OWNS A 2002 SAAB 9-5 ARC. WHILE DRIVING 20 MPH, THE ENGINE MISFIRED AND THE CONTACT NOTICED A BURNING SMELL. APPROXIMATELY TEN MINUTES AFTER SHE PARKED THE VEHICLE, THERE WERE FLAMES COMING FROM THE REAR OF THE VEHICLE NEAR THE FUEL TANK. THE FLAMES ENGULFED THE VEHICLE AND CAUSED DAMAGED TO THE TREES AND DRIVEWAY. THE FIRE DESTROYED THE VEHICLE. AS OF DECEMBER 5, 2007, THE INSURANCE COMPANY OR MANUFACTURER HAD NOT INSPECTED THE VEHICLE. THE CONTACT STATED THAT RECALL #07V087000 (FUEL SYSTEM, GASOLINE: DELIVERY: HOSES, LINES/PIPING, AND FITTINGS) WAS PERFORMED TWO WEEKS PRIOR TO THE FAILURE. THE CONTACT FELT THAT THE RECALLED PART CAUSED THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 66,500.

NHTSA ID

10210874

Incident

Dec 1, 2007

Mileage

66,500 mi

TRANSMISSION "CLUNK" OCCURRED WITH SHIFTING FROM REVERSE TO DRIVE. DEALER DIAGNOSED VALVE BODY AND RECOMMENDED TRANSMISSION REBUILD. AAMCO DIAGNOSED SAME ISSUE RESULTING FROM METAL SHAVINGS BEING RELEASED FROM TORQUE CONVERTER INTO TRANSMISSION. ENTIRE TRANSMISSION INCLUDING TORQUE COVERTER NEEDED TO BE REPLACED AT 74,000 MILES.*JB

NHTSA ID

10202483

Incident

Jun 14, 2007

Mileage

68,000 mi

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS SUMMARY: DRIVING ON HIGHWAY, PRESSURE LINE FROM FUEL TANK CAME LOOSE AND STARTED LEAKING MASSIVE AMOUNTS OF GAS ALL OVER THE UNDERSIDE OF THE VEHICLE AND STREET. STREAM OF FUEL ON HIGHWAY ALERTED DRIVER. LOST UNKNOWN AMOUNT OF GALLONS OF GAS QUICKLY . HAD TO PULL OVER AND CALL FOR TOW TRUCK TO TAKE TO NEAREST FACILITY. I EVACUATED THE CAR DUE TO LARGE AMOUNTS OF GAS UNDER VEHICLE AND STREAMS OF FUEL NEAR HOT EXHAUST PIPES. TECHNICIAN DISCOVERED FUEL LINE HAD COME LOOSE AFTER LOOKING INSIDE PORT FROM UNDER BACK SEAT. NO EVIDENCE OF ANY BREAKAGE OR OTHER ISSUES THE FIRST EVENT-- THE LINE SIMPLY CAME LOOSE AND WAS EASILY RE-ATTACHED. THE SECOND EVENT HAPPENED IN JUNE 2007 AND FUEL AGAIN WAS POURING OUT FROM THE UNDERSIDE IN A PARKING LOT. I CALLED THE SAME INDEPENDENT DEALER WHO IMMEDIATELY HAD THE CAR TOWED . THIS TIME THE REPAIR WAS DONE WITH METAL STRAPS TO PREVENT ANY FURTHER COMING APART. I THEN RECEIVED A RECALL LETTER FROM SAAB AFTER THIS OCCURRENCE TWO TIMES. I WAS TOLD BY SAAB USA TO SUBMIT REPAIR ORDERS FOR REIMBURSEMENT WHICH I DID. I RECEIVED A DENIAL LETTER UNTIL AN AUTHORIZED SAAB DEALER COULD CHECK THE WORK COMPLETED BY THE INDEPENDENT DEALER. I WAS CALLED BY THE AUTHORIZED DEALER IN MARIETTA, GA AND TOLD THAT I MAY NEED A COMPLETE FUEL ASSEMBLY FOR $1100 DUE TO THE INDEPENDENT DEALERS REPAIRS AFFECTING ELECTRICAL WIRING. THE CAR IS AT THE DEALER FOR INVESTIGATION AND HOPEFULLY A SAAB USA WILL STAND BEHIND THE NEEDED REPAIRS. CONSULTATION ON INTERNET CHAT ROOM SAABNET.COM FINDS THAT AT LEAST 4 OTHER OWNERS OF SIMILAR VINTAGE SAAB 9-5 VEHICLES HAVE EXPERIENCED THIS SAME PROBLEM. SAAB USA IS QUESTIONING MY REPAIRS AT THE INDEPENDENT DEALER. *TR

NHTSA ID

10200050

Incident

Oct 26, 2006

Mileage

77,314 mi

I AM EXPERIENCING A TRANSMISSION ISSUE WITH MY 2002 SAAB 9-5. JUDGING BY THE NUMBER OF MENTIONS I HAVE SEEN IN ONLINE FORUMS, THIS IS A PRETTY WIDE SPREAD ISSUE. THE SAAB TSB THAT RELATES TO THIS ISSUE IS 440-2497, OCTOBER 2004. MY LOCAL DEALER HAS ADVISED ME I NEED TO FOOT THE BILL FOR A NEW TRANSMISSION VALVE BODY. I BELIEVE THIS SHOULD BE A RECALL ISSUE. IT APPEARS VERY SIMILAR TO THE EXPLORER/MOUNTAINEER VALVE BODY ISSUE THAT WAS ELEVATED TO RECALL STATUS A FEW YEARS AGO. *JB

NHTSA ID

10199694

Incident

Feb 1, 2007

Mileage

72,000 mi

TL*THE CONTACT OWNS A 2002 SAAB 9-5. THE CONTACT STATED THAT THE FRONT HEADLIGHTS ARE DISCOLORED AND FOGGY. WHEN THE VEHICLE IS DRIVEN AT NIGHT, THE LIGHT BARELY SHINES THROUGH THE HEADLIGHTS. THE SAAB DEALER DIAGNOSED THE VEHICLE AS NEEDING A NEW HEADLIGHT ASSEMBLY. THE VEHICLE HAS NOT BEEN REPAIRED. THE POWERTRAIN WAS UNKNOWN. THE CURRENT MILEAGE IS 70,000 AND FAILURE MILEAGE WAS 65,002.

NHTSA ID

10195146

Incident

Jan 4, 2007

Mileage

65,002 mi

TL*THE CONTACT OWNS A 2002 SAAB 9-5. THE CONTACT RECENTLY RECEIVED A RECALL LETTER REGARDING THE FUEL PUMP RETAINING TABS. HE STATED THAT THE ONLY LOCAL SAAB DEALER IN HIS AREA IS NO LONGER SERVICING SAAB, AND THE NEXT CLOSEST DEALER IS 151 MILES AWAY. HE DOES NOT WANT TO DRIVE HIS VEHICLE THAT FAR BECAUSE IT MAY FAIL OR HAVE A NEGATIVE EFFECT DUE TO THE RECALL. NO FAILURES HAVE OCCURRED AT THIS TIME. THE CURRENT AND FAILURE MILEAGES WERE 35,000.

NHTSA ID

10193694

Incident

Jun 18, 2007

Mileage

35,000 mi

TL*THE CONTACT OWNS A 2002 SAAB 9-5. THE CONTACT RECEIVED A RECALL NOTICE IN REFERENCE TO THE FUEL PUMP RETAINING TABS, WHICH MAY RESULT IN FUEL LEAKAGE AND A FIRE. HE STATED THAT THE NOTICE SUGGESTED HAVING THE REPAIR DONE AT AN AUTHORIZED DEALER SIX MILES AWAY, WHILE HIS AUTO MECHANIC SHOP IS RIGHT DOWN THE STREET. THE DEALER WILL NOT PROVIDE HIM WITH A LOANER VEHICLE. HE NOTIFIED THE MANUFACTURER ABOUT HAVING TO TAKE HIS VEHICLE TO AN AUTHORIZED DEALER. THE VIN, ENGINE SIZE, AND FAILURE MILEAGE WERE UNKNOWN. THE CURRENT MILEAGE IS 85,000.

NHTSA ID

10193580

Incident

Jun 7, 2007

TL*THE CONTACT OWNS A 2002 SAAB 9-5. WHILE DRIVING THE CONTACT SMELLED GAS AND PULLED THE VEHICLE OFF THE ROAD. THE CONTACT INSPECTED THE VEHICLE, AND FOUND A LARGE GAS LEAK DUE TO THE FUEL LINE LOOSENING FROM THE PIPE. THE VEHICLE WAS REPAIRED, AND THE CONTACT FELT THE FAILURE WAS A SAFETY RISK. THE CURRENT MILEAGEWAS 29,500, AND FAILURE MILEAGE WAS 29,470.*AK

NHTSA ID

10187155

Incident

Apr 3, 2007

Mileage

29,470 mi

LETTER FROM INSURANCE COMPANY REGARDING LOSS OF SAAB DUE TO FIRE WITH REQUEST FOR PAYMENT**CC THE CONSUMER NOTICED THAT ONE OF THE LIGHTS ON THE DASHBOARD HAD ILLUMINATED AND THE VEHICLE BEGAN TO ACT STRANGELY. THE CONSUMER ARRIVED HOME PARKED THE VEHICLE IN THE GARAGE AND THEN SUDDENLY THE VEHICLE CAUGHT ON FIRE. *JB UPDATED

NHTSA ID

10187954

Incident

Jan 10, 2006

DRIVING ON HIGHWAY, PRESSURE LINE FROM FUEL TANK CAME LOOSE AND STARTED SPRAYING GAS ALL OVER THE UNDERSIDE OF THE VEHICLE. STREAM OF DRIPS ON HIGHWAY ALERTED A PASSING MOTORIST WHO FLAGGED US DOWN. LOST 5 GALLONS OF GAS IN JUST A COUPLE OF MINUTES. HAD TO PULL OVER AND CALL FOR ROADSIDE ASSISTANCE. EVACUATED CAR DUE TO LARGE POOLS OF GAS UNDER VEHICLE AND DRIPS NEAR HOT EXHAUST PIPES. TECHNICIAN DISCOVERED FUEL LINE LOOSE AFTER LOOKING INSIDE PORT FROM UNDER BACK SEAT. NO EVIDENCE OF ANY BREAKAGE OR OTHER ISSUES -- THE LINE SIMPLY CAME LOOSE AND WAS EASILY RE-ATTACHED. CAR IS BEING TAKEN TO DEALER FOR INVESTIGATION AND HOPEFULLY A FIX. CONSULTATION ON INTERNET CHAT ROOM SAABNET.COM FINDS THAT AT LEAST 3 OTHER OWNERS OF SIMILAR VINTAGE SAAB 9-5 VEHICLES HAVE EXPERIENCED THIS SAME PROBLEM. JB

NHTSA ID

10183329

Incident

Feb 23, 2007

Mileage

70,500 mi

BOLT CAME OFF ON TURBO-CHARGER AND BLASTED A HOLE THROUGH THE TURBO-CHARGER. MY CAR SUDDENLY STOPPED ACCELERATING DURING A MERGE AND I ALMOST CRASHED. THIS RESULTING IN $2000 WORTH OF REPAIRS. *NM

NHTSA ID

10178684

Incident

May 23, 2006

Mileage

77,005 mi