RoadVitals

2007 Saturn Outlook

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
511
Latest Jul 3, 2025
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
5
Latest Jun 30, 2015
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
2
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
15
8 injuries, 0 deaths reported

Overview

Our database contains 511 NHTSA owner-reported complaints for the 2007 Saturn Outlook, most frequently naming the exterior lighting, powertrain (other) and electrical categories. 5 safety recalls have been issued covering this model year; 2 NHTSA investigations name it; and 978 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

5 campaigns cover this model year

View all 5

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
15V415000

STRUCTURE:BODY:HATCHBACK/LIFTGATE

Jun 30, 2015
691,144 units potentially affected
The defect: General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
The risk: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
The remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
General Motors LLCManufacturer number 15240View on NHTSA.gov
10V240000

ELECTRICAL SYSTEM

Jun 4, 2010
1,365,070 units potentially affected
The defect: GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
The risk: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
The remedy: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
GENERAL MOTORS CORP.View on NHTSA.gov
08V441000

ELECTRICAL SYSTEM

Aug 28, 2008
857,735 units potentially affected
The defect: GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.
The risk: THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.
The remedy: DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
GENERAL MOTORS CORP.Manufacturer number 08048View on NHTSA.gov

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect.

DP12003ClosedDefect Petition

Loss of Headlamp Illumination

Opened Jun 4, 2012
Closed Jul 24, 2014

As of July 16, 2014, out of a population of 248,453 subject vehicles, NHTSA received 473 consumer complaints of inoperative head lamp. Many of these complaints indicated that the head lamp harness suffered damage from overheating. After reviewing the complaints, ODI found: -69% (328) alleged that a single head lamp was inoperative. -18% (86) alleged that both head lamps were inoperative but not at the same time. -9% (41) alleged that both head lamps were inoperative but the complaints did not indicate whether the failures had occurred at the same time. -4% (17) alleged that both head lamps were inoperative at the same time. -One additional complaint cited wire harness damage to both sides but did not specify an outage -No crashes or loss of vehicle control were reported. -Any alleged thermal damages were limited to melting of the head lamp harness and the head lamp housing. -A head lamp would intermittently fail to come on or flickers before becoming completely inoperative. For the seventeen complaints that alleged simultaneous failure of both head lamps while attempting to turn them on or while driving, the head lamp failures likely had occurred one at a time. The subject vehicle's head lamps are connected in a parallel circuit and each circuit is fused. Therefore, failure of one head lamp or its harness should not affect the other head lamp operation. Over the last 25 years, ODI has opened numerous defect investigations of the loss of headlamp illumination.Investigations that resulted in safety recalls involved simultaneous loss of illumination from both headlamps. NHTSA does not consider the loss of a single headlamp as presenting an unreasonable safety risk-such failures are readily detectable by the driver while allowing the vehicle to retain forward visibility and conspicuity from the remaining headlamp.There is typically enough time between the failure of the first headlamp and the second during which the vehicle operator can obtain the needed repairs. Based on the information currently available, NHTSA does not believe that the headlamp condition as alleged by the petitioner indicates the likelihood of a safety-related defect that would warrant a formal investigation.Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is denied.Further specifics can be found in the Federal Register Notice ODI complaint ID numbers are referenced on the next page.

EXTERIOR LIGHTING:HEADLIGHTS
EA08010ClosedEngineering Analysis

NON-CRASH ENGINE COMPARTMENT FIRES

Opened Jun 12, 2008
Closed Sep 8, 2008

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

ELECTRICAL SYSTEM:12V/24V/48V BATTERYLed to recall 08V441000

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 511
Exterior lighting
Filed Jul 3, 2025

Passenger headlight dim. Grand Street Batteey and Electric replaced bulb and states voltage to connector is good.the vehicle is available for inspection. Headlight is not bright enough to utilize at night as it should be for owner or traffic. No warning lamps light up on instrument panel.

NHTSA ID
11671172
Incident
Apr 15, 2025
AirbagsBody & structureDriver assistance
Filed Nov 7, 2024
1 injury reported

The contact owns a 2007 Saturn Outlook. The contact stated that the air bag, the traction control, and the electronic stability control warning lights were illuminated. The contact stated that after opening the liftgate with the power liftgate button, the liftgate unexpectedly lowered, and struck her on the head. The contact stated that the failure had occurred twice. The contact had head pain, but medical assistance was not required. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failures to NHTSA Campaign Numbers: 07V062000 (Air Bags) and 15V415000 (Structure); however, the VIN was not included. The manufacturer was notified of the failure. The failure mileage was approximately 163,000.

NHTSA ID
11624026
Incident
Nov 1, 2024
Mileage
163,000 mi
Electrical
Filed Jan 20, 2024

When it's cold I get frost inside my vehicle I replaced my windshield because I thought air was getting inside to cause the frost but after getting it replaced same issue water is leaking in and causing moisture and causing my vehicle not wanting to start because it's doing something to the battery

NHTSA ID
11566629
Incident
Jan 20, 2024
ElectricalExterior lightingPowertrain (other)
Filed Jul 8, 2023

I HAVE A WIRE THAT BURNED-OUT AND IT CONTROLS MY WINDOWS, SUNROOF,MY AC CONTROLS, AND THEN ALSO MY TRANSMISSION IS SHUTERING

NHTSA ID
11531083
Incident
Feb 17, 2022
Powertrain (other)Steering
Filed Jun 23, 2022

While driving, the car will automatically shift into 1st gear. Steering will then be disabled to the point of crash. Transmission/computer issue. Major issue with Saturn Outlooks.

NHTSA ID
11470781
Incident
Jun 23, 2022
Powertrain (other)
Filed Jan 27, 2022

I just purchased this vehicle & on my way home with it the check engine light came on. I hooked up the diagnostic code scanner on the car and it threw several different codes PO700, PO752, PO420. There are specific transmission issues with this particular year, make, and model. My car has the exact same symptoms as the others that were recalled so why has mine not been recalled as well? It's malfunctioning just as the others described in the recall so clearly this is a common issue with these particular vehicles. I feel my car should be covered as part of the safety recall on the transmission and I need it repaired as soon as possible.

NHTSA ID
11449138
Incident
Jan 1, 2022
Driver assistanceElectrical
Filed Aug 19, 2020

WATER IS LEAKING INTO THE VEHICLE CAUSE ELECTRICAL MALFUNCTIONING. WATER IS COLLECTING INTO THE BATTERY COMPARTMENT. ELECTRICAL PROBLEMS CAUSED BY WATER INCLUDE RADIO, LIGHTS; DASHBOARD( SHUTS OFF FOR A FEW SECONDS THEN COMES BACK ON) AND INTERIOR, DOOR LOCKS, STABILITY TRACK MALFUNCTION AT WHICH POINT THE CAR WILL SHAKE AND SHUT ITSELF OFF WHILE BEING DRIVEN ABOVE 40 MPH.

NHTSA ID
11350337
Incident
Jun 15, 2019
Mileage
200,000 mi
Powertrain (other)
Filed Jul 29, 2020

THE VEHICLES AUTOMATIC TRANSMISSION WAS NOT SHIFTING APPROPRIATELY WITH FLUCTUATING CHANGES OF SPEEDS, THEN THE CAR WOULD NOT MAINTAIN A SAFE SPEED TO EXIT THE FREEWAY. AFTER PARKING I CALLED A TOW TRUCK AND HAD IT DELIVERED TO THE CLOSEST DEALER WHERE THEY HAD PUT IN A REBUILT TRANSMISSION WHEN THE VEHICLE HAD 90,223 MILES BACK IN 2013. NOW, LESS THAN 50,000 MILES LATER THE DEALERSHIP IS TELLING ME THE VEHICLE NEEDS ANOTHER TRANSMISSION AT THE COST OF $5,500. IF A VEHICLE ONLY GETS 50,000 MILES OUT OF A TRANSMISSION SOMETHINGS NOT RIGHT! I HAVE MY RECEIPTS FROM THE FIRST TRANSMISSION THAT CLEARLY INDICATE THE MILEAGE.

NHTSA ID
11342086
Incident
Jul 27, 2020
Mileage
145,000 mi

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

PIC5650M

This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble Codes B3055, B3060, B3935, C0750, C0755, C0760, C0765, and/or C0775.

PIP5601C

This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

PIT5074R

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

PIT5074R

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

PIT5074R

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

23-NA-001

ELECTRICAL SYSTEM

This service bulletin provides information for dealers/technicians on OnStar Module 2G Sunset Information.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Saturn Outlook by model year
YearComplaintsRecallsInvestigationsIssue Index
2011000—
2010164247.5
20091927357.0
20086335254.3
2007Viewing5115253.7

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.