2007 Mazda CX-7

One of the Prinx HiCountry HT2 tires (size 235/60R18) developed a structural failure shortly after installation. The tire repeatedly lost air with no visible puncture. I first took it to a local tire shop, which could not locate the source of the leak. The problem continued, so I brought the tire to a second independent tire shop, where a technician inspected it and confirmed the issue was caused by a thin steel belt wire protruding through the tread near the shoulder area. They marked the defect with white tire chalk and determined the tire was not repairable under safety guidelines. The failure originated from inside the tire, not from an external object. The tire is still in my possession and available for inspection. No warning lights appeared prior to the failure; the only symptom was repeated pressure loss.

NHTSA ID

11727854

Incident

Nov 13, 2025

The headlights are horrible for night time driving. The low beam lights are nearly invisible, which leaves you no choice but to drive with high beam lights and still poses a serious safety risk. Vehicle was taken to dealership and asked if there had been any recalls on the headlights because they’re very dangerous, can’t see anything at night.

NHTSA ID

11652659

Incident

Jul 10, 2024

The contact owns a 2007 Mazda CX-7. The contact stated that the air conditioning system was inoperable, and the cabin air filter was replaced; however, the failure persisted. Additionally, the contact stated that while her husband was driving at an undisclosed speed, he smelled a burning odor. The contact stated that her husband drove to the residence, and while parking the vehicle, he noticed smoke coming from underneath the hood. There was no warning light illuminated. An independent mechanic diagnosed the vehicle at the residence and determined that the air condition compressor clutch had seized, causing the compressor fuse to burn. The dealer was contacted, and the contact was informed that older vehicles were not service at their location. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 174,000.

NHTSA ID

11545177

Incident

Sep 7, 2023

Mileage

174,000 mi

THE HEADLIGHTS ON THIS VEHICLE ARE COMPLETELY INADEQUATE FOR NIGHT DRIVING. THEY DO NOT PROJECT ANY WHERE NEAR ENOUGH LIGHT TO SEE IN UNLIT AREAS WHERE YOU CANNOT USE HIGH BEAMS. THE LIGHT IS YELLOW NO MATTER WHAT BULB YOU USE AND DOES NOT PROJECT DOWN ROAD AT ALL.

NHTSA ID

11405150

Incident

Jun 23, 2018

ENGINE VVT SOLENOID SEIZED CAUSING COMPLETE ENGINE FAILURE WHILE TRAVELING ON THE HIGHWAY AT 60MPH. THE DEALER IS ASKING $10,730 TO REPLACE THE ENGINE. THE CAR HAS 76,000 MILES.

NHTSA ID

11351539

Incident

Aug 19, 2020

Mileage

76,000 mi

WE BOUGHT THE VEHICLE USED FROM A CAR DEALERSHIP CALLED HEAVY FOOT MOTORS IN SAN ANTONIO TX. THE VERY NEXT DAY, THE VEHICLE STARTED SMOKING FROM THE HOOD, EXHAUST, AND SMOKE CAME THROUGH THE AIR VENTS. MY WIFE GOING ABOUT 5-10MPH WHILE MAKING A TURN IN A RESIDENTIAL NEIGHBORHOOD WHEN THE SMOKING STARTED. WE TOWED THE VEHICLE TO THE DEALERSHIP AND EXPLAINED WHAT HAPPENED. THEIR MECHANIC TOOK THE VEHICLE AND HAD IT FOR THREE WEEKS. I PICKED THE VEHICLE UP AND MADE IT MAYBE 5 MINUTES DOWN THE ROAD, AND THE VEHICLE DID THE SAME THING. SO I HAD THE VEHICLE TOWED BACK TO THE DEALERSHIP AGAIN AND IT IS CURRENTLY THERE AS OF 4/4/2020. MY SAFETY CONCERN IS THAT THERE IS SMOKE COMING OUT OF THE ENGINE, EXHAUST, AS WELL AS THROUGH THE AC VENT AND GOING INTO THE VEHICLE. ALSO, WHEN I WENT TO INSTALL MY CHILDREN'S SEAT BELT WE REALIZED THE BACK SEATS SEAT BELTS DO NOT LOCK TO SECURE A CARSEAT. THAT IS A MAJOR SAFETY CONCERN FOR ME. ALSO, UPON PURCHASE I REALIZE THERE WAS NO DRIVER SIDE DOOR HANDLE. WE AGREED IN PURCHASE CONTRACT THAT THE DEALERSHIP WOULD PUT ONE ON IF I PURCHASED IT. I JUST FOUND IT STRANGE HOW YOU COULD SELL A CAR FROM A DEALERSHIP WITHOUT A DRIVER SIDE DOOR HANDLE. THAT IS A HUGE SAFETY CONCERN INCASE SOMETHING WERE TO HAPPEN AND THAT WAS THE ONLY DOOR TO OPEN FROM THE OUTSIDE. I ALSO REALIZE NOW THAT THE TRUNK DOES NOT OPEN, THE DOOR WILL NOT OPEN. I WILL BE GETTING A COPY OF THEIR MECHANIC'S REPORT WHERE HE STATED THAT IT IS HIS PROFESSIONAL OPINION THAT THE VEHICLE WAS SOLD IN THIS CONDITION. I HAVE REQUESTED A REFUND WHICH INITIALLY,( VERBALLY) I WAS TOLD WE WOULD GET IF IT IN FACT WAS SOLD IN THAT MANNER BUT NOW THEY HAVE BACKED OUT OF THAT. *TR

NHTSA ID

11320474

Incident

Mar 14, 2020

Mileage

140,000 mi

BEFORE I RECEIVED THE RECALL NOTICE I HAD TAKEN THE CAR IN TO STAR MAZDA AN AUTHORIZED DEALER IN GLENDALE TWICE FOR THE AIRBAG LIGHT WARNING SIGN WHICH HAD BEEN LIT UP ON THE DASHBOARD. TWICE STAR MAZDA CHARGED ME $140.00 FOR DIAGNOSTICS AND COULDN'T FIND THE PROBLEM WITH THE LIGHT. AFTER I RECEIVED THE NOTICE I TOOK THE CAR IN AND AFTER TWO HOURS THEY INDICATED THAT THEY REPLACE THE PARTS NEEDED AND IT IS A SIMPLE RECALL AND ITS NOT SO IMPORTANT. THE AIRBAG MALFUNCTION LIGHT IS STILL LIT ON THE DASHBOARD AND MY REGULAR MECHANIC STATED THAT THE AIRBAG MIGHT NOT FUNCTION ON MY CAR SINCE THE MALFUNCTION LIGHT IS LIT. PLEASE ADVISE. I HAVE ANOTHER MAZDA WITH THE SAME PROBLEM AND THE DEALER REFUSES TO RESOLVE THE AIRBAG WARNING SIGN WHICH IS ON RIGHT AFTER I TURN ON THE VEHICLE. THE OTHER MAZDA VIN # IS [XXX]. PLEASE ADVISE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

11307987

Incident

Jul 15, 2019

JUNE 2014, I WAS DRIVING VEHICLE OUT OF TOWN ON VACATION AND IT SUDDENLY BEGAN RUNNING ROUGH LIKE THE PISTONS WERE MISFIRING. MILEAGE WAS 69,700. I PULLED INTO A DEALERSHIP (1 MILE AWAY), DROPPED THE KEYS, AND CALLED TO EXPLAIN IN THE MORNING. LATER, THEY SAID THEY DROVE THE CAR AROUND THE LOT AND THE ENGINE LOCKED UP. THEY TOOK NO RESPONSIBILITY FOR MAKING IT WORSE AND CHARGED ME FOR CONFIRMING THE LOSS OF COMPRESSION IN THE PISTONS. WE REPLACED THE ENGINE AT GREAT EXPENSE AND TO A POOR RESULT. I FOUND THIS 2007 MODEL HAD A CHRONIC PROBLEM WITH THE VARIABLE VALVE TIMING (VVT) CAUSING THE TIMING CHAIN TO COME OUT OF ADJUSTMENT AND DESTROY THE ENGINE. INSTEAD OF ISSUING A RECALL AND FIXING IT, MAZDA OFFERED AN EXTENDED WARRANTY TO 6 YEARS-60,000 MILES. THIS IS ABOUT THE AVERAGE POINT OF FAILURE, MEANING HALF THE PEOPLE ARE NOT COVERED. A FEATURE OF THE TURBO CHARGER IS MAKING THE ENGINE RUN HOT, BURNING THE OIL, SO PEOPLE WERE OFTEN DENIED BECAUSE THE OIL "HAD NOT BEEN CHANGED." INTERESTINGLY, MAZDA SAID THE TIMING CHAIN HAD BEEN REPLACED UNDER WARRANTY WITH A PREVIOUS OWNER. THAT DATE AND LOCATION COINCIDED WITH A DATE OF SERVICE SHOWN ON CARFAX FOR TYPICAL MAINTENANCE ONLY. THAT DEALERSHIP SAID THEY COULD NOT POSSIBLY DO ANY WORK WITHOUT IT SHOWING ON CARFAX. I WONDER WHO MAZDA PAID FOR THE WARRANTY CLAIM... I WANT NHTSA TO COMPEL MAZDA TO COMPENSATE OWNERS WHO EXPERIENCED ENGINE FAILURE DUE TO THIS DOCUMENTED DESIGN FLAW.

NHTSA ID

11279145

Incident

Jun 13, 2014

Mileage

69,700 mi

This SA supersedes the previously issued SA(s) listed below. The changes are noted in Red. SA-061/25 12/17/25 DESCRIPTION If you encounter any type of electrical concern (e.g, dead battery, engine no start, DTC(s) stored...), interview the customer before proceeding with normal MGSS diagnosis by asking if any aftermarket devices have been installed. Aftermarket devices may be the cause of the electrical concern. Below are a few examples of unusual electrical concerns caused by aftermarket devices. Examples: 1. Devices connected to the DLC-2 (battery discharge/DTC stored) 2. Devices plugged into the 12V outlet 3. GPS tracking device (engine no start/battery discharge) 4. Dash cam (DTC stored) 5. Non-certified USB cable (Apple Carplay™/ Android Auto™ will not connect) 6. Over-sized wheels/tires (incorrect GPS location) 7. DTC C0023:14 8. Decorative trim and/or cover on the START/STOP ENGINE button Example 1: Some electrical devices connected to the DLC-2 connector by insurance or mobile phone companies may cause: Battery discharge. The device may disrupt the CAN system battery saver mode. • IDS/MMDS will not communicate with the vehicle due to poor DLC-2 connection. The aftermarket device may cause DLC-2 female terminals to spread open.

This Service Alert supersedes the previously issued SA listed below: The changes are noted in Red. SA-011/24 02/12/24, 06/06/24, 07/29/24 DESCRIPTION Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manual. Services performed outside of Mazda's factory scheduled maintenance are not recommended. These services are unnecessary and create unneeded expenses for your customers. SCHEDULED MAINTENANCE Refer to the applicable Workshop Manual or Owner's Manual for vehicle -specific manufacturer scheduled maintenance. Workshop Manual - Refer to section 00-00 SCHEDULED MAINTENANCE. Owner's Manual - Refer to section 8 Maintenance and Care. b. Note: Please refer to the information below outlining the services not included in Mazda's Factory Scheduled Maintenance: IMPORTANT: Recommending fluid flushes when not necessary can lead to customer confusion and dissatisfaction. Fluid flushing for preventive maintenance purposes is strongly discouraged, unless otherwise specified in a published procedure (Owner’s Manual, Workshop Manual, Technical Service Bulletin, etc.).

If you encounter any type of electrical concern (e.g, dead battery, engine no start, DTC(s) stored...), interview the customer before proceeding with normal MGSS diagnosis by asking if any aftermarket devices have been installed. Aftermarket devices may be the cause of the electrical concern. Below are a few examples of unusual electrical concerns caused by aftermarket devices.

A musty/mildew type odor may come from the vents when the air conditioning (A/C) system is operating. It is most noticeable when the A/C is first turned ON. This odor is the result of mold growth in the A/C evaporator/cooling unit which is caused by condensation, dust, and pollen within the cooling unit. This condition is usually worse during high humidity conditions. “Mazda Air Cooling Coil Coating” is available to encapsulate the mold to reduce odors. If the product is properly applied, it can effectively reduce the musty/mildew odor for up to three years. NOTE: See parts information for Mazda Air Cooling Coil Coating and Kit part numbers.

Some vehicles may experience exterior trim heat damage such (melted, separating, etc.) when parked near a glass building or Low-E windows. This may be caused by the sun's reflection. If a structure's windows create enough of a curve, the concave glass can focus the sun's rays onto a small area and acting like magnifiying glass direct the sunbeams into a hot pinpoint of light. This magnifcation of the sun's rays can cause damage to vehicle trim (see examples). Additional information and exemplar images regarding this phenomenon can be found by performing a google search.

When replacing the SiriusXM satellite radio unit, a call must be made to inform SiriusXM of the existing Radio ID and the new/replacement SAT Radio ID as soon as possible to ensure the customer leaves the dealership with an active SAT radio.