RoadVitals

2010 Spartan Mm Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
9
Newest May 17, 2016
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
1 investigation on file

Recall campaigns

9 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

16V313000

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

May 17, 2016
2,582 units potentially affected
The defect: Spartan Motors (Spartan) is recalling certain model year 2007-2015 Spartan K3 and MM motorhome chassis manufactured September 21, 2006, to March 23, 2015. In the affected vehicles, the flexible exhaust tube may tear allowing hot exhaust to blow against other components or materials.
The risk: If hot exhaust gas contacts other components or materials, it can increase the risk of a fire.
The remedy: Spartan will notify the motorhome manufacturers that purchased the affected chassis, and Spartan dealers will inspect the alignment of the tubes, correcting them and replacing any that are torn. These repairs will be performed free of charge. The recall began on June 23, 2016. Owners may contact Spartan customer service at 1-517-543-6400. Spartan's number for this recall is 16014. Note: This recall supersedes 15V-554.
Spartan Motors USAManufacturer number 16014View on NHTSA.gov
14V020000

SUSPENSION:FRONT

Jan 28, 2014
452 units potentially affected
The defect: Spartan Motors Chassis, Inc. (Spartan Chassis) is recalling certain 2010-2014 model year MM motorhome chassis manufactured December 11, 2009, through January 30, 2013, and equipped with a sway bar and model 1253 front suspension. This front suspension design has increased rebound travel which may result in a binding condition of the sway bar end link which could lead to the breaking of the sway bar end links.
The risk: Broken sway bar end links may result in poor vehicle handling, or sway, which increases the risk of a crash.
The remedy: Spartan Chassis will notify owners, and dealers will replace the old end links with new end links and an improved mounting, free of charge. The recall began on March 4, 2014. Customers may contact Spartan Chassis at 1-517-543-6400. Spartan Chassis's number for this recall is 12012.
Spartan Motors, Inc.Manufacturer number 12012View on NHTSA.gov
13V392000

SERVICE BRAKES, AIR:ANTILOCK

Aug 30, 2013
113 units potentially affected
The defect: Spartan Motor Chassis, Inc. (Spartan) is recalling certain model year 2009-2012 MM, 2011-2014 K2, and 2010-2012 K3 motor home chassis. Due to contact with the steering relay rod, the ABS modulator valve may fracture resulting in air not being applied to the affected wheel end.
The risk: This may increase stopping distance of the vehicle or cause the vehicle to pull to one side. Either condition increases the risk of a crash.
The remedy: Spartan will notify owners and dealers will reorient the ABS modulator valve and install spacers for additional clearance, free of charge. The recall began on September 17, 2013. Owners may contact Spartan at 1-517-543-6400. spartan's recall campaign number is 12008.
Spartan Motors, Inc.Manufacturer number 12008View on NHTSA.gov
13V182000

STEERING

May 8, 2013
2,694 units potentially affected
The defect: Spartan Motors Chassis (Spartan) is recalling certain model year 2006-2011 K2, and K3 and 2006-2010 MM motorhome chassis manufactured July 20, 2005, through December 17, 2010. The steering gear mounting brackets may crack and detach resulting in a loss of steering.
The risk: A loss of steering control may increase the risk of a crash.
The remedy: Spartan will notify owners. Starting in mid-June 2013, dealers will install a replacement bracket or a reinforcement to the existing bracket. Until the remedy is available, owners may have their vehicle inspected at any Spartan service center. All repairs will be performed free of charge. Notices were mailed to owners on June 24, 2013. Owners can contact Spartan at 1-855-589-9836.
Spartan Motors, Inc.View on NHTSA.gov
12V429000

SERVICE BRAKES, AIR:DRUM:CHAMBER; SUSPENSION:FRONT:CONTROL ARM

Sep 4, 2012
491 units potentially affected
The defect: Spartan is recalling certain model year 2008-2013 K2 and MM motor home chassis, equipped with a Hendrickson independent front suspension. The front brake chambers may contact the upper control arm of the independent front suspension. Continued contact may result in damage sufficient enough to inhibit the full release of the brakes. If the brakes do not fully release, as they drag, heat could be generated causing the brakes to engage even further.
The risk: As the brakes self-engage, the driver could lose control of the vehicle, increasing the risk of a crash.
The remedy: Spartan chassis will notify owners, and repair the vehicles free of charge. The safety recall began on Decenber 5, 2012. Owners may contact Spartan at 1-800-543-4277 Option 1.
SPARTAN CHASSIS, INC.Manufacturer number 12010View on NHTSA.gov
11V516000

VEHICLE SPEED CONTROL

Oct 17, 2011
1,294 units potentially affected
The defect: SPARTAN IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 INCOMPLETE RECREATIONAL VEHICLE CHASSIS MANUFACTURED FROM JANUARY 4, 2010, THROUGH JANUARY 26, 2011, EQUIPPED WITH AN ELECTRONIC CONTROL MODULE, PART NUMBER 2791-NN2E-001 OR 2791-NN2E-002. WHEN THE BRAKE IS APPLIED, THE CRUISE CONTROL MAY NOT CANCEL. ADDITIONALLY, THESE VEHICLES MAY EXHIBIT AN INADVERTENT, MODERATE INCREASE IN VEHICLE SPEED UNTIL THE VEHICLES REACHES ITS GOVERNED SPEED AFTER THE VEHICLE'S CRUISE CONTROL IS SET.
The risk: IF THE DRIVER ATTEMPTS TO CANCEL THE CRUISE CONTROL BY APPLYING THE BRAKE OR IF THE VEHICLE SPEED INCREASES AND THE DRIVER IS UNAWARE, THEY MAY HAVE REDUCED CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
The remedy: SPARTAN WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 9, 2012. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400.
SPARTAN CHASSIS, INC.Manufacturer number 11027View on NHTSA.gov
10V288000

STEERING:COLUMN

Jun 28, 2010
340 units potentially affected
The defect: SPARTAN IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 RECREATION VEHICLE CHASSIS MANUFACTURED FROM JUNE 17, 2007 THROUGH MARCH 15, 2010 EQUIPPED WITH TRW IGEN3 INTERMEDIATE STEERING COLUMNS. THE WELD AROUND THE IGEN3 STEERING SHAFT TUBE THAT SECURES THE SPLINE TUBE TO THE INTERMEDIATE TUBE MAY BE MISLOCATED (I.E., NOT FULLY OVER THE SEAM CREATED WHEN THE TUBES ARE PRESSED TOGETHER.)
The risk: MISLOCATED WELDS MAY RESULT IN TORSIONAL AND AXIAL STRENGTH FALLING BELOW ACCEPTABLE LEVELS. THIS CONDITION COULD RESULT IN SEPARATION OF THE STEERING COLUMN, LOSS OF STEERING CONTROL AND A VEHICLE CRASH WITHOUT WARNING.
The remedy: SPARTAN WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 16, 2010. OWNERS MAY CONTACT SPARTAN AT SPARTAN CHASSIS AT 1-800-543-5008 - OPTION 5.
SPARTAN CHASSIS, INC.Manufacturer number 10013View on NHTSA.gov
09V478000

SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES

Dec 16, 2009
70 units potentially affected
The defect: SPARTAN IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 MM, K2, AND K3 MOTORHOME CHASSIS MANUFACTURED FROM APRIL 27, 2007 AND AUGUST 11, 2009, EQUIPPED WITH PNEUMATIC AND HYDRAULIC ADJUSTABLE BRAKE PEDAL ASSEMBLIES P/NOS. 6562618, 6565118, 77025-001, 77025-002, 77025-501, 77050-004, SUPPLIED BY KONGSBERG AUTOMOTIVE. SOME ASSEMBLIES COULD CONTAIN A DRIVE PIN THAT IS BELOW SPECIFICATION AND MAY BECOME DISENGAGED FROM THE BRAKE ARM CAUSING SEPARATION OR LOOSENING OF THE PEDAL FROM THE REMAINDER OF THE ASSEMBLY.
The risk: IF THE DRIVE PIN BECOMES DISENGAGED ON THE BRAKE PEDAL ASSEMBLY, IT COULD RESULT IN A LOSS OF VEHICLE BRAKING FUNCTION AND/OR CAUSE THE BRAKE PEDAL TO INTERFERE WITH THE THROTTLE PEDAL FUNCTION. EITHER CONDITION COULD RESULT IN A VEHICLE CRASH.
The remedy: SPARTAN IS WORKING WITH KONGSBERG AND THE VEHICLE MANUFACTURERS TO REMEDY THESE MOTORHOMES. PLEASE SEE RECALL 09E-064. THE REMEDY WILL BE PERFORMED BY SPARTAN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 8, 2010. OWNERS MAY CONTACT SPARTAN TOLL-FREE AT 1-800-543-4277 - OPTION 1.
SPARTAN CHASSIS, INC.Manufacturer number 09027View on NHTSA.gov
09V184000

SERVICE BRAKES, AIR:SUPPLY:QUICK RELEASE VALVE

May 28, 2009
484 units potentially affected
The defect: SPARTAN IS RECALLING 484 MODEL YEARS 2008-2010 ADV, BEY, FUR, GLC, GLD, K2, K3, MG, MM, MTR, AND NVS FIRE TRUCK, AMBULANCE, AND MOTOR HOME CHASSIS MANUFACTURED BETWEEN JULY 1 AND DECEMBER 16, 2008 EQUIPPED WITH CERTAIN HALDEX QUICK RELEASE VALVES (QRV). THE RUBBER DIAPHRAGM INSIDE THE QRV MAY EXPERIENCE DELAMINATION RESULTING IN SIGNIFICANT LEVELS OF AIR PRESSURE LEAKAGE PAST AND/OR THROUGH THE DIAPHRAGM, OR THE DEVELOPMENT OF A BUBBLE IN THE DIAPHRAGM WHICH MAY TRAP AIR PRESSURE IN THE VALVE AND NOT ALLOW THE SERVICE BRAKES TO RELEASE.
The risk: MALFUNCTION OF THE AIR BRAKE SYSTEM COULD RESULT IN A VEHICLE CRASH.
The remedy: EACH VEHICLE MANUFACTURER WILL PROVIDE A REMEDY PLAN AND NOTIFICATION SCHEDULE. THE AFFECTED VEHICLES WILL BE REPAIRED WITHOUT CHARGE TO THE OWNERS. OWNERS MAY CONTACT THEIR VEHICLE MANUFACTURER OR SPARTAN CHASSIS TOLL-FREE AT 1-800-543-4277.
SPARTAN CHASSIS, INC.Manufacturer number 09005View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

PE13028ClosedPreliminary Evaluation

Sway Bar End Link Failure

Opened Aug 26, 2013
Closed Feb 19, 2014

On August 26, 2013, the Office of Defects Investigation (ODI) opened this preliminary evaluation after evaluating a Campaign Service Bulletin (CSB) 12-250-002 (NHTSA ID No. 10051812) issued by Spartan Chassis, Inc.The CSB related to sway bar end link failures on certain motorhome chassis manufactured between April 2, 2009 and January 14, 2013.In response to ODI's information request letter, Spartan conducted a detailed analysis of its claim data related to sway bar end link failures on the subject chassis.Spartan determined that a certain population of model MM motorhome chassis equipped with its model 1253 front suspension were experiencing an increased rate of failure.The population identified incorporated a design change that occurred in late 2009.This change increased the rebound travel of the front suspension resulting in a binding condition that could cause the sway bar end links to fail.A broken sway bar end link can potentially cause poor vehicle handling that could increase the risk of a vehicle crash.Based on the results of their analysis, Spartan decided to issue a defect notice and conduct a safety recall to replace the existing sway bar end links with new units and an improved mounting.Based on Spartan's decision to conduct a safety recall (14V-020), ODI is closing this investigation.

STEERING:LINKAGESLed to recall 14V020000

Elsewhere on this vehicle

Data sources