2008 Sprinter 3500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2008 Sprinter 3500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Tires & wheels457.1%
- Body & structure228.6%
- Other / unspecified114.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2008 35000 SPRINTER VAN EQUIPPED WITH KUMHO ROAD VENTURE A/T TIRES SIZED LT215/85R16 (N/A), DOT H20PYD4A. THE CONTACT STATED THAT THE WHILE DRIVING AT VARIOUS SPEEDS THE REAR PASSENGER SIDE TIRES HAD BLOWN ON TWO SEPARATE OCCASIONS AND A THIRD TIRE HAD EXPERIENCED BUBBLING AND SEPARATION OF THE INNER SIDE WALL. THE MANUFACTURER AND LOCAL DEALER DISCOUNT TIRES IN TRAVERSE CITY, MI WAS NOTIFIED OF THE FAILURES.
KUHMO TIRE ROAD VENTURE AT 215 85R16 TREAD SEPARATED FROM CASING CAUSING MINOR DAMAGE TO MY 09 MONACO COVINA MOTOR HOME. THESE TIRES CAME AS ORIGINAL EQUIPMENT ON THE MONACO. THIS IS THE FOURTH OF SEVEN OF THESE TIRES THAT HAS FAILED IN THIS FASHION. THE TIRES HAVE BEEN INSPECTED, ROTATED, AND MAINTAINED AT APPROPRIATE AIR PRESSURE. I CONTACTED KUHMO AND THEY AGREED TO REPLACE THE TWO TIRES THAT THREW OFF RUBBER ON MY LAST TRIP WITH THE MONACO. I JUST COMPLETED ANOTHER TRIP (THE FIRST SINCE REPLACING THE TWO ORIGINAL DEFECTIVE TIRES) AND HAD TWO MORE GO BAD WITHIN A DAY OF EACH OTHER. THE MONACO HAS LESS THAN 30,000 MILES ON IT. IT WAS NOT OVERLOADED NOR ARE THERE ANY MECHANICAL DEFICIENCIES. BOTH TIRES WERE ON THE REAR OUTSIDE OF DUALS. BOTH APPEARED TO HAVE BLISTERED PRIOR TO TREAD SEPARATION. IN THE PREVIOUS INCIDENTS, ONE FRONT AND ONE REAR INSIDE DUAL SEPARATED. BOTH HELD AIR ALLOWING TRANSPORTATION TO A TIRE SHOP FOR REPLACEMENT. THERE MUST BE A SYSTEMIC PROBLEM WITH THESE TIRES. PLEASE INVESTIGATE AND RECALL IF APPROPRIATE. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
THE DODGE SPRINTER AMBULANCE, ROAD RESCUE CONVERSION, THE CABINET/SHELF FELL OFF OF THE WALL BARELY MISSING THE PARAMEDIC ONBOARD. *TR
THE ROAD RESCUE SPRINTER AMBULANCE CONVERSION HAS HAD ISSUES WITH THEIR CONVERSIONS. WE HAVE HAD NUMEROUS REPAIRS MADE TO TWO (2) OF OUR SPRINTER AMBULANCES AND ROAD RESCUE HAS FAILED TO REPAIR AND SOLVE THE ISSUES. THE STRUCTURAL ISSUES PROVIDE A RISK TO OUR EMT'S AND PATIENTS AS WELL. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
THE ROAD RESCUE SPRINTER AMBULANCE CONVERSION HAS HAD ISSUES WITH THEIR CONVERSIONS. WE HAVE HAD NUMEROUS REPAIRS MADE TO TWO (2) OF OUR SPRINTER AMBULANCES AND ROAD RESCUE HAS FAILED TO REPAIR AND SOLVE THE ISSUES. THE STRUCTURAL ISSUES PROVIDE A RISK TO OUR EMT'S AND PATIENTS AS WELL. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .