1996 Subaru Outback Problems

WHILE DRIVING VERY BUSY HIGHWAY, THE TEMPERATURE GAUGE WENT ALL THE WAY TO "H". I PULLED OVER AND NOTICED SOME STEAM UNDER HOOD. ADDED SOME WATER. A LITTLE LATER, STILL ON "H". MECHANIC WHO HAS SERVICED MY 1996 SUBARU OUTBACK SINCE I GOT IT IN 1998 SAID IT HAD A BLOWN HEAD GASKET, COMMON WITH SUBARUS. IN 2009 I HAD THE 90K MILE MAINTENANCE DONE, VERY EXPENSIVE. ALSO HAD ALL NEW BRAKES, VERY EXPENSIVE. ALSO FOUR NEW TIRES AND LAST MONTH, A NEW BATTERY. ALSO, LAST MONTH, HAD OIL CHANGE. I HAVE NEVER RECEIVED EVEN ONE RECALL NOTICE FROM SUBARU, EVEN THOUGH THEY KNEW ALL ALONG THAT THEIR HEAD GASKETS ARE FAILING IN THEIR CARS. I WANTED MY OUTBACK TO LAST MANY MORE YEARS BUT NOW MUST JUNK IT BECAUSE OF A FAULTY HEAD GASKET. MECHANIC SAID IT'S USELESS TO FIX HEAD GASKET OR REPLACE IT, AND TOLD ME TO GET A NEW CAR, WHICH I CANNOT AFFORD. MECHANIC PUT CHEMICAL IN LINE WHICH IS SUPPOSED TO SEAL ANY LEAKS (NO GUARANTEES). I OFTEN VISIT MY DAUGHTER, WHO IS RECUPERATING FROM BREAST CANCER, IN THE NORTHEAST PART OF CT, IN A VERY SECLUDED AREA OF FEW HOMES, NO BUSINESSES. TO HAVE CAR FAILURE IN THE WOODS WOULD PROBABLY GIVE THIS 70 YEAR OLD A HEART ATTACK. *TR

CAR OVERHEATED WITHOUT WARNING. SUSPECT HEADGASKET FAILURE ALLOWING COOLANT TO ESCAPE AND ENGINE TO OVERHEAT . (POTENTIAL FOR CAR TO UNEXPECTEDLY STALL ON INTERSTATE) UPON INTERNET SEARCH FOUND THAT HUNDREDS OF THE SUBARU 2.5L ENGINES SUFFER FROM SAME CONDITION (1995-1999). HTTP://HOME.COMCAST.NET/~SKIPNOSPAM/. *TR

WHILE SITTING AT A INTERSECTION WAITING FOR THE LIGHT TO CHANGE THE AIR BAGS WENT OFF INADVERTENTLY. DRIVER WAS NOT INJURED, AND THE VEHICLE WAS TOWED TO THE DEALER. A CAUSE COULD NOT BE DETERMINED AT THIS TIME. *AK

IN HEAD-ON COLLISION WITH BOTH CARS AT 30 MPH, BOTH FRONT AIR BAGS DEPLOYED. PASSENGER SIDE AIR BAG BURST THROUGH THE WINDSHIELD AND ENDED UP ON THE HOOD. PASSENGER NEVER TOUCHED THE AIR BAG, BUT WAS RESTRAINED BY THE SEAT/SHOULDER BELT. NO OTHER KNOWN REASON FOR WINDSHIELD DAMAGE BEFORE OR DURING THE CRASH. *AK

WHENEVER THE CAR HAS BEEN PARKED IN SUB-ZERO TEMPERATURES FOR A MINIMUM OF THREE HOURS, THE CHECK VALVE IN THE BRAKE BOOSTER VACUUM HOSE WILL FREEZE IN PLACE AND RESULTS IN NO POWER ASSIST BRAKING. THE FIRST APPLICATION OF THE BRAKES WOULD BE NORMAL AS THERE WAS RESIDUAL VACUUM IN THE BOOSTER. ADDITIONAL APPLICATION OF THE BRAKES WOULD HAVE NO POWER ASSIST AT ALL. MULTIPLE PUMPS OF THE BRAKE PEDAL WOULD BE REQUIRED TO BREAK LOOSE THE CHECK VALVE AND RESTORE NORMAL BRAKING. THIS CAR WAS NEW TO ME IN 2013 AND I WAS UNAWARE OF THIS DEFECT. THE FIRST FEW TIMES IT HAPPENED TO ME, I WENT THROUGH STOP SIGNS NOT KNOWING THAT I HAD NO POWER ASSIST BRAKES. NOW THAT I KNOW WHAT TO EXPECT- BEFORE PUTTING THE CAR INTO GEAR, I WOULD TEST THE BRAKE PEDAL AT LEAST THREE TIMES. WHEN THE CHECK VALVE IS FROZEN, I WOULD FEEL NORMAL PEDAL PRESSURE THE FIRST TIME THEN THE PEDAL WOULD GO HARD THE SECOND TIME. I WOULD THEN HAVE TO DEPRESS THE PEDAL MULTIPLE TIMES UNTIL I FELT THE CHECK VALVE BREAK FREE AND NORMAL PEDAL PRESSURE WAS RESTORED. *TR

RECENTLY PURCHASED (1/17/14) VEHICLE A CATASTROPHIC LOSS AFTER PAX SIDE T-BONE @ A/B PILLAR SUBSEQUENT TO HILL HOLDER SELF-ACTIVATION CAUSED UNRECOVERABLE YAWED SLIDE/SKID (TO A NON-INPUTTED STOP FROM 40-0MPH IN +/- .25MI.) DURING BRAKE/DOWNSHIFT CONTROL INPUT ON (ISTHA FOIA FILE)% UPHILL GRADE IN 4-6" SNOW ACCUMULATION ON NEGLECTFULLY MAINTAINED [UNCLOSED/FEMA/IEMA] EISENHOWER INTERSTATE HIGHWAY SYSTEM (TO WIT: IL TOLLWAY: SB I-294 @ MPH 39.5). CDL'D OWNER/OPERATOR SUFFERING EFFECTS PTSD + RIGHT SIDE BFT/HARD-IMPACT ORTHOPEDIC JOINT/RELATED INJURIES. IL STATE POLICE DIST. #15 STAR #6274 CONTRIBUTED TO CAUSE VIA IMPROPER LANE USAGE (+/-20MPH/#2LN {VS. #4/5} W/4WAY HAZARDS ON/DUTY E-LIGHTS OFF/OBSCURED) IN VIRTUALLY UNRECOGNIZABLE SNOW-COVERED (INCL. GREENHOUSE) MARKED DUTY VEHICLE,+ FAILURE TO STOP/CITE SEMI-TRUCK (LIKE SPEED) IN #1LN. *TR

COMPLETE SEPARATION OF TREAD FROM BODY AND SIDEWALL OF RIGHT FRONT MICHELIN HARMONY TIRE. TIRES IN SERVICE FOR THREE MONTHS ON A SUBARU LEGACY WAGON. *JB

MICHELIN XW4 TIRE P205/70R15, DOT M3H342DX079, OUTSIDE SIDEWALL SLIT OPEN BELOW THE TREAD EDGE, MICHELIN STATED THE TIRE BLEW OUT DUE TO A ROAD HAZARD OR UNDERINFLATION, CONSUMER CHECKED OVER TIRE AND FOUND NO INDICATIONS OF A PUNCTURE. *SLC

TL*THE CONTACT OWNS A 1996 SUBARU OUTBACK. WHEN THE CONTACT PLACED HER VEHICLE INTO REVERSE AND THEN DRIVE, IT SPED OFF ON ITS OWN AND DID NOT RESPOND WHEN THE BRAKE AND ACCELERATOR PEDALS WERE DEPRESSED. THE CONTACT DID NOT HAVE CONTROL OVER THE STEERING AS WELL. SHE ATTEMPTED TO STEER THE VEHICLE INTO TALL GRASS; HOWEVER, APPROXIMATELY 25 FEET LATER, THE VEHICLE SUDDENLY BEGAN TO RESPOND AND SHE WAS ABLE TO TAKE CONTROL. SHE CALLED SEVERAL DEALERS, BUT THEY CLAIMED TO NEVER HAVE HEARD OF THE FAILURE. THE VEHICLE HAS NOT BEEN REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE CURRENT MILEAGE WAS APPROXIMATELY 196,000 AND FAILURE MILEAGE WAS APPROXIMATELY 186,000.

VEHICLE EXPERIENCING BUCKING ON TWO OCCASIONS WHEN THE FOOT IS TAKEN OF THE ACCELERATOR / WHEN MAKING A TURN DUE TO SOLENOID FAILURE. REPAIRS WERE DONE. PROBLEM STILL EXIST. *YC

ACCORDING TO SUBARU IN NHTSA RECALL NO. 01V-216, THE PROTECTIVE PAINT WAS APPLIED INCORRECTLY TO '96 SUBARU LEGACY OUTBACK SPRINGS WHICH LEADS THEM TO RUST AND BREAK. SUBARU WILL REPLACE THE FRONT SPRINGS BUT WILL NOT REPLACE THE REAR SPRINGS, EVEN THOUGH THE SAME PROBLEM OCCURS ON BOTH FRONT AND REAR SPRINGS. BOTH OF MY FRONT SPRINGS BROKE, ONE OF MY REAR SPRINGS BROKE, AND THE OTHER REAR SPRING IS CRACKED AND BREAKING. WHEN THE REAR SPRINGS BREAK THERE IS THE SAME SAFETY ISSUE AS WHEN THE FRONT SPRINGS BREAK, THAT BEING THAT THE CAR MAY BECOME UNCONTROLLABLE WHICH COULD BE FATAL AT HIGHWAY SPEEDS. PLEASE PROMPT SUBARU TO RECALL THE REAR SPRINGS AS WELL AS THE FRONT TO MITIGATE THIS SAFETY ISSUE. THANKS. *JB

ON SEVRAL OCCASIONS, THE LEFT AND RIGHT BEARINGS FAILED CAUSING DAMAGE TO THE AXLE ASSEMBLY. BEARINGS HAD TO BE REPLACED TWICE. DEALER NOTIFIED. *TT

CONSUMER STATES WHEELS ARE OXDIZING/CORRODING AND AIR IS LEAKING IN ALL TIRES. CHECKED BY DEALER WHO OXIDIZED THE TIRES.*JB

ALL 4 ALLOY WHEELS HAVE DETERIORATED TO THE POINT THAT TIRES WILL NOT RETAIN SUFFICIENT AIR PRESSURE. OTHER BRAND VEHICLES WITH ALLOY WHEELS (EX. AUDI) DRIVEN IN IDENTIAL CONDITIONS AND HOUSED IN SAME GARAGE HAVE SHOWN NO ABNORMAL DETERIORIATION AS HAS THE SUBARU. TIRES DEFLATE RAPIDLY WHEN CAR IS DRIVEN AT HIGHWAY SPEED.*AK

RECENTLY PURCHASED (1/17/14) VEHICLE A CATASTROPHIC LOSS AFTER PAX SIDE T-BONE @ A/B PILLAR SUBSEQUENT TO HILL HOLDER SELF-ACTIVATION CAUSED UNRECOVERABLE YAWED SLIDE/SKID (TO A NON-INPUTTED STOP FROM 40-0MPH IN +/- .25MI.) DURING BRAKE/DOWNSHIFT CONTROL INPUT ON (ISTHA FOIA FILE)% UPHILL GRADE IN 4-6" SNOW ACCUMULATION ON NEGLECTFULLY MAINTAINED [UNCLOSED/FEMA/IEMA] EISENHOWER INTERSTATE HIGHWAY SYSTEM (TO WIT: IL TOLLWAY: SB I-294 @ MPH 39.5). CDL'D OWNER/OPERATOR SUFFERING EFFECTS PTSD + RIGHT SIDE BFT/HARD-IMPACT ORTHOPEDIC JOINT/RELATED INJURIES. IL STATE POLICE DIST. #15 STAR #6274 CONTRIBUTED TO CAUSE VIA IMPROPER LANE USAGE (+/-20MPH/#2LN {VS. #4/5} W/4WAY HAZARDS ON/DUTY E-LIGHTS OFF/OBSCURED) IN VIRTUALLY UNRECOGNIZABLE SNOW-COVERED (INCL. GREENHOUSE) MARKED DUTY VEHICLE,+ FAILURE TO STOP/CITE SEMI-TRUCK (LIKE SPEED) IN #1LN. *TR

RECENTLY PURCHASED (1/17/14) VEHICLE A CATASTROPHIC LOSS AFTER PAX SIDE T-BONE @ A/B PILLAR SUBSEQUENT TO HILL HOLDER SELF-ACTIVATION CAUSED UNRECOVERABLE YAWED SLIDE/SKID (TO A NON-INPUTTED STOP FROM 40-0MPH IN +/- .25MI.) DURING BRAKE/DOWNSHIFT CONTROL INPUT ON (ISTHA FOIA FILE)% UPHILL GRADE IN 4-6" SNOW ACCUMULATION ON NEGLECTFULLY MAINTAINED EISENHOWER INTERSTATE HIGHWAY SYSTEM (TO WIT: IL TOLLWAY: SB I-294 @ MPH 39.5). CDL'D OWNER/OPERATOR SUFFERING EFFECTS PTSD + RIGHT SIDE BFT/HARD-IMPACT ORTHOPEDIC JOINT/RELATED INJURIES. *TR

RECENTLY PURCHASED (1/17/14) VEHICLE A CATASTROPHIC LOSS AFTER PAX SIDE T-BONE @ A/B PILLAR SUBSEQUENT TO HILL HOLDER SELF-ACTIVATION CAUSED UNRECOVERABLE YAWED SLIDE/SKID (TO A NON-INPUTTED STOP FROM 40-0MPH IN +/- .25MI.) DURING BRAKE/DOWNSHIFT CONTROL INPUT ON (ISTHA FOIA FILE)% UPHILL GRADE IN 4-6" SNOW ACCUMULATION ON NEGLECTFULLY MAINTAINED [UNCLOSED/FEMA/IEMA] EISENHOWER INTERSTATE HIGHWAY SYSTEM (TO WIT: IL TOLLWAY: SB I-294 @ MPH 39.5). CDL'D OWNER/OPERATOR SUFFERING EFFECTS PTSD + RIGHT SIDE BFT/HARD-IMPACT ORTHOPEDIC JOINT/RELATED INJURIES. IL STATE POLICE DIST. #15 STAR #6274 CONTRIBUTED TO CAUSE VIA IMPROPER LANE USAGE (+/-20MPH/#2LN {VS. #4/5} W/4WAY HAZARDS ON/DUTY E-LIGHTS OFF/OBSCURED) IN VIRTUALLY UNRECOGNIZABLE SNOW-COVERED (INCL. GREENHOUSE) MARKED DUTY VEHICLE,+ FAILURE TO STOP/CITE SEMI-TRUCK (LIKE SPEED) IN #1LN. *TR

RECENTLY PURCHASED (1/17/14) VEHICLE A CATASTROPHIC LOSS AFTER PAX SIDE T-BONE @ A/B PILLAR SUBSEQUENT TO HILL HOLDER SELF-ACTIVATION CAUSED UNRECOVERABLE YAWED SLIDE/SKID (TO A NON-INPUTTED STOP FROM 40-0MPH IN +/- .25MI.) DURING BRAKE/DOWNSHIFT CONTROL INPUT ON (ISTHA FOIA FILE)% UPHILL GRADE IN 4-6" SNOW ACCUMULATION ON NEGLECTFULLY MAINTAINED EISENHOWER INTERSTATE HIGHWAY SYSTEM (TO WIT: IL TOLLWAY: SB I-294 @ MPH 39.5). CDL'D OWNER/OPERATOR SUFFERING EFFECTS PTSD + RIGHT SIDE BFT/HARD-IMPACT ORTHOPEDIC JOINT/RELATED INJURIES. *TR

DT: THE CONSUMER STATES THAT THE 1996 SUBARU OUTBACK WAS HAVING A PROBLEM WITH THE GAS TANK FILLER GUARD AND PIPE. THE GUARD RUSTED FROM DEBRIS OVER THE YEARS, AND DIRT AND DEBRIS WERE GETTING UNDERNEATH THE GUARD. THE RESULT WAS RUSTING AND LEAKING GAS FROM THE GAS TANK. THE GAS TANK WAS NOTICED LEAKING LAST WEEK. THE OWNER HAS CONTACTED THE DEALER, HAS E-MAILED AND CONTACTED SUBARU VIA PHONE. THEY SEEMED NOT INTERESTED IN THE FACT THAT THE CAR WAS OLD. *AK

DT: 1996 SUBARU OUTBACK CALLER COMPLAINED ABOUT THE FUEL INJECTION .SYSTEM. WHEN STARTING THE CAR IT SHUT OFF AGAIN. WHEN DRIVING IT DIDN'T HAVE ANY SPEED, THE SPEED ODOMETER WAS 60 MPH WHEN GOING 40 MPH. SOMETIMES IT WILL PICK UP SPEED AND SOMETIMES IT WON'T. TOOK VEHICLE TO DEALER AND HE WOULD NOT WORK ON THIS CAR. THE CAR WILL NOT ACCELERATE, AND HE WOULD NOT LISTEN . THE CAR WAS PARKED ON THE ROAD SIDE NOW AND IT WILL NOT RUN. THE CAR VIBRATED WHEN TRYING TO START THE CAR TODAY. AND THE CAR WILL NOT START. THIS HAS BEEN HAPPENING FOR THE LAST TWO WEEKS AND TODAY THE CAR JUST DIED. *AK

I DRIVE A 1996 OUTBACK WITH 116,000 MILES ON IT. I'VE READ ABOUT POSSIBLE RECALLS PERTAINING TO THE TRANSMISSIONS BINDING IN TURNS, WHICH IS WHAT I'M EXPEREINCING NOW. I'VE BEEN TOLD THAT IF IT GETS TOO BAD, IT MAY BREAK AN AXLE OR SOMETHING. IF IT IS A RECOGNIZED PROBLEM/MISTAKE, I'D REALLY LIKE TO SEE A RECALL.*AK

CAR JUMPS WHEN STEERING AT LOW SPEED. I WAS INFORMED THAT IT WAS A TRANSMISSION DEFECT. I FEEL IT IS A CONSTRUCTION DEFECT. *AK

VEHICLE DID A 360 DEGREE SPIN ACROSS THE HIGHWAY AND ROLLED OVER, NEITHER DRIVER'S OR PASSENGER'S SIDE AIRBAGS DEPLOYED. THE ROOF AND THE FRONT END CAVED IN. ALSO THE SEAT BELTS DID NOT HOLD. *AK

THE RECEIVING PART OF THE BELT BUCKLE IS EXTENDED TOO LONG FROM THE SEAT, LEAVING A GAP WHEN A CHILD SAFETY SEAT IS PLACED IN THE VEHICLE'S BACK SEATS. *AK

WARPED ROTORS CAUSED BRAKES TO PULSE.

VEHICLE STALLS INTERMITTANTLY.

A PERMANENT HAZING OF THE HEADLIGHT LENSES HAS BEEN PROGRESSIVELY GETTING WORSE, AND CANNOT BE REMOVED. THIS HAS CAUSED SAFE NIGHT DRIVING ILLUMINATION TO DROP DRAMATICALLY.*AK