2008 Subaru Outback Airbags Problems

The dash pad in the 2005 to 2009 Subaru Legacy and Outback models have a very common problem of deteriorating to where they become sticky and then sections start cracking and falling off. My concern is that this is happening in the area of the passenger air bag. There is a portion of the dash bad which says SRS AIRBAG imprinted in the pad material and mines actually about to fall off. If the air bag should deploy from a serious enough collision, these loose pieces will be one projectiles and could easily cause injury esp to someone eye. I reached out to SOA but they offered no help. The claim number was 250530-0001813. Subaru did extend the warranty on this a few years back but they have since expired. The missing piece in the image is towards the bottom but the area directly over the airbag is severely cracked.

NHTSA ID

11669922

Incident

Jun 28, 2025

The contact owns a 2008 Subaru Outback. The contact stated while driving approximately 30 MPH, the passenger’s side air bag sensor light remained illuminated. The contact stated that the air bag warning light was also flashing. The failure became constant. The contact had not taken the vehicle to a local dealer. The vehicle was not repaired. The contact's husband had inspected the air bag sensor under the front passenger’s seat and determined that the sensor was functioning. The contact stated that her husband replaced the air bag sensor in the front passenger’s seat sun visor. The vehicle was repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 128,000.

NHTSA ID

11476359

Incident

Apr 10, 2022

Mileage

128,000 mi

Airbag dashboard warning light stayed on while driving on 1/31/2022 and 2/1/2022. Dealer (Autofair Subaru in Haverhill Massachusetts) confirmed there was a problem in the overhead console. Researching the problem, I came across https://www.subaruoutback.org/threads/2006-obw-airbag-light-on-my-fix.42574/ which identified a loose component on the printed circuit board caused by a crack in the solder. Cold weather seems to exacerbate the crack and cause the component to fail intermittently. Many have reported this problem with their Subaru and have made repairs by touching up the solder. Subaru states that the collision system may not function when this condition causes the Airbag Warning Light to remain on.

NHTSA ID

11450384

Incident

Jan 31, 2022

The contact owns a 2008 Subaru Outback. The contact stated while driving 30 mph, the check engine warning light illuminated. The contact took the vehicle to a local dealer, where it was diagnosed with needing unknown repairs to be completed. The vehicle was repaired however, after the repairs she started to hear an abnormal sound coming from the rear of the vehicle. The vehicle was taken back to the local dealer, where it was diagnosed with needing unknown repairs to be performed. The vehicle was repaired however, the failure persisted. The vehicle was taken to an independent mechanic and was informed that the front passenger’s side ball joint and power steering rack needed to be replaced. Additionally, the rear differential fill plug and the transmission needed to be repaired. The vehicle was repaired however, the transmission was not replaced. The contact called the local dealer and made them aware of the failure of the transmission. The vehicle was not diagnosed nor repaired. The contact stated recently the air bag warning light illuminated. The dealer and independent mechanic were made aware of the failure. The manufacturer had not been informed of the failure. The failure mileage was approximately 139,000.

NHTSA ID

11419526

Incident

Feb 1, 2021

Mileage

139,000 mi

2008 SUBARU OUTBACK. CONSUMER WRITES IN REGARDS TO AIRBAG SAFETY RECALL. *LD THE CONSUMER STATED THERE WERE DIFFICULTIES SCHEDULING THE RECALL REPAIR. *JS

NHTSA ID

11415892

Incident

May 11, 2021

[2008 SUBARU OUTBACK WITH 82,000 MILES, TAKADA AIRBAG REPLACEMENT JULY 2020]. AIRBAG WARNING LIGHT (RED) ILLUMINATED ON THE DASHBOARD INSTRUMENT PANEL AS SOON AS THE CAR IS TURNED ON AND REMAINS ON AS LONG AS THE ENGINE IS RUNNING WHETHER MOVING OR STATIONARY. THIS IS NOTIFYING THE DRIVER THAT THE AIRBAG SYSTEM IS INOPERABLE AS STATED BY MULTIPLE MECHANICS, SUBARU MECHANICS AND SUBARU SERVICE MANAGERS OVER DOZENS OF BLOGS AND EVEN THE SUBARU WEBSITE. OVERHEAD CONSOLE (IN MAP LIGHT GROUP) SHOWS PROPER NOTIFICATION OF SEATBELT NEED AND AIRBAG ACTIVATION WHEN WEIGHT IS EXERTED ON PASSENGER SEAT SURFACE, BUT WITH THE AIRBAG RED WARNING LIGHT LIT ON THE DASHBOARD, THE PASSENGER, AND POSSIBLY DRIVER AIRBAG, IS TOTALLY INOPERATIVE. THIS IS A SERIOUS SAFETY ISSUE AND NEGLECT BY SUBARU IN ADDRESSING THIS SAFETY PROBLEM IS OF IMMEDIATE CONCERN. HUNDREDS OF SUBARU OWNERS, MANY NOT DIRECTLY REPORTING TO NHTSA, HAVE COMPLAINED ABOUT THIS SERIOUS SAFETY ISSUE, BUT NOTHING HAS BEEN DONE.

NHTSA ID

11390985

Incident

May 21, 2020

Mileage

79,600 mi

PASSENGER AIRBAG LIGHT ABOVE MAP LIGHT COMES ON INTERMITTENTLY. TOOK VEHICLE TO DEALER IN SEPTEMBER 2012 TWICE FOR THIS ISSUE (STILL ONGOING). SERVICE WRITER SAID COMPONENT NEEDED TO BE REPLACED BECAUSE IT WAS FAULTY. HE INDICATED THE AIRBAG WOULD STILL DEPLOY IN THE EVENT OF A CRASH, BUT THE SENSOR IN THE SEAT IS NOT ABLE TO READ THE WEIGHT OF THE PASSENGER AND IF I HAD A SMALLER AND SHORTER ADULT IN THE FRONT SEAT, THEY COULD BE INJURED BECAUSE THE AIRBAG WOULD DEPLOY AT A HIGHER RATE OF SPEED AND WITH GREATER FORCE POSSIBLY INJURING THE PASSENGER. THIS APPEARS TO BE AN ONGOING AND PREVALENT ISSUE WITH THIS MAKE AND MODEL. THE AIRBAG LIGHT WILL GO ON AND OFF REGARDLESS OF TEMPERATURE, DRIVING OR PARKED, AND IF THERE IS OR IS NOT A PASSENGER. THIS IS CLEARLY AN ISSUE THAT WARRANTS A RECALL. *TR *BF*JB

NHTSA ID

11326368

Incident

Sep 21, 2012

THE TIMING BELT FAILED PREMATURELY. IT HAD BEEN REPLACED AT 70K MILES AND FAILED AT 140K MILES ON THE SECOND BELT WHICH ONLY HAD 70K MILES ON IT VERSUS THE MANUFACTURE RECOMMENDED 100K MILES REPLACEMENT INTERVAL. THIS HAPPENED DURING HIGHWAY TRAVEL AND THE VEHICLE IMMEDIATELY LOST ALL POWER AND ONLY HAD 5 SECONDS TO FIND A SAFE PLACE TO PULL OFF THE HIGHWAY. ADDITIONALLY, THE VEHICLE HAS AN AIRBAG RECALL FOR THE SECOND TIME, CITING DEATH DUE TO METAL PROJECTILE AND I AM HAVING A VERY HARD TIME HAVING THAT REPLACED AS THE CAR IS NOW BEING DRIVEN IN CANADA AND SUBARU DEALERS IN CANADA WON'T HONOR THE REQUIRED RECALL.

NHTSA ID

11322692

Incident

Apr 20, 2020

Mileage

145,000 mi

I BOUGHT MY CAR IN 2016 THERE WAS A RECALL ON AIRBAGS, THEY FIXED IT BEFORE I BOUGHT IT, BUT MY AIRBAG LIGHT HAS BEEN GOING ON AND OFF FOR OVER A YEAR NOW, I HAD MY MECHANIC RESET IT , BUT IT COMES BACK ON, IS IT UNDER WARRANTY STILL OR NOT ?

NHTSA ID

11256936

Incident

Jun 13, 2018

Mileage

59,000 mi

TAKATA RECALL - THE CAR WAS RECALLED 3 TIMES. THE MECHANIC SAID AS LONG AS THE AIRBAG LIGHT WAS ON, THE AIRBAG WOULD NOT WORK. HE SAID THE FIX WAS NOT INCLUDED IN THE RECALL.

NHTSA ID

11207106

Incident

Jun 1, 2016

Mileage

90,000 mi

MY VEHICLE HAS A PROBLEM WITH AN INTERMITTENT AIRBAG LIGHT ILLUMINATING, INDICATING AN ISSUE WITH THE AIRBAG SYSTEM. SPECIFICALLY IN MY CASE, IT INDICATES THAT THE OVERHEAD AIRBAG INDICATOR SYSTEM IS IN A FAULT STATE. THIS IS EXTREMELY COMMON IN THIS VEHICLE AND AGE, WITH MANY OTHER OWNERS REPORTING THE SAME ISSUE WITH NO RECALL ACTION FROM SUBARU. THIS IS A MAJOR SAFETY ISSUE WITH THIS CAR IF NOT ADDRESSED AND CAN RESULT IN THE AIRBAGS NOT DEPLOYING IN THE EVENT OF A CRASH. COST FOR AN OWNER TO REPAIR (AND IN MY CASE) IS $300+ AND SHOULD BE COVERED BY SUBARU.

NHTSA ID

11194124

Incident

Oct 2, 2018

Mileage

155,000 mi

SOMETIMES THE AIRBAG LIGHT COMES ON EITHER WHEN THE CAR IS STARTED OR ONCE IT'S DRIVING. IT'S VERY SPORADIC.

NHTSA ID

11156024

Incident

Jan 30, 2016

Mileage

80,000 mi

STICKY, MELTING DASHBOARD, SHINY AND REFLECTIVE IN DIRECT SUNLIGHT CREATING VISIBILITY PROBLEMS, UNSURE HOW IT WILL REACT IF PASSENGER AIRBAG MUST BE DEPLOYED THRU DETERIORATING DASHBOARD, AFFECTING RESALE VALUE. DASHBOARD LITERALLY COMES OFF ON HANDS OR WIPING RAGS, POSSIBLE RELEASE OF CHEMICALS INTO INTERIOR? SUBARU WILL ONLY ADDRESS 1/3 OF THE DEFECT REPAIR COST. TOTAL AVERAGE COST FOR REPLACEMENT IS APPROX $1500-1600.00, ACTUAL DASHBOARD ITSELF RETAILS FOR $502.50 FROM DEALERS AND IS APARENTLY AVAILABLE WITHIN A FEW DAYS WHEN ORDERED. SUBARU GAVE CREDIT FOR $500.00, ALMOST COVERING THE COST OF THE DASHBOARD / COVER ONLY*** APPROX. $1000 .00 IN LABOR MUST BE PAID BY CUSTOMER. CAR IS IN OTHERWISE IMMACULENT CONDITION. THIS IS A DEFECT AFFECTING SAFETY, AND IS A KNOWN PROBLEM WITH SUBARU EFFECTING ALL OF THIS MODEL AND SIMILAR MODELS WITH HIGH SUN EXPOSURE. IT IS ALSO CROSS MANUFACTURER AFFECTED, IE; TOYOTA, NISSAN, ETC. THEY HAVE TAKEN THE ROLE OF RECALL AND REPLACE. SUBARU HAS NOT TO DATE. SUBARU IS AWARE THAT THIS IS A SERIOUS PROBLEM YET REFUSES TO ACCEPT FULL RESPONSIBILITY FOR.

NHTSA ID

11142465

Incident

Aug 25, 2018

THERE'S SEEMS TO BE A COMMON ISSUE WITH THE WIRING ON 2005-2009 SUBARU OUTBACK/LEGACY MODELS THAT AFFECTS BOTH THE AIRBAG AND THE LOCKING MECHANISM. I HAVE SEEN MULTIPLE THREADS ONLINE WHERE THE AIRBAG INDICATOR LIGHT COMES ON SPECIFICALLY INDICATING THAT THE PASSENGER AIRBAG MAY BE AFFECTED AND SENSORS MAY BE FAULTY? THERE IS ALSO A COMMON ERROR IN THE ELECTRICAL SYSTEM IN WHICH WHEN YOU LOCK THE CAR - ALL LOCKS ACTIVATE WITH THE EXCEPTION OF THE REAR TAILGATE WHICH POSES A SAFETY RISK OR TOTAL THEFT OF THE CAR. THESE PROBLEMS OCCUR UPON VEHICLE IGNITION AND WHEN THE CAR IS ON OR OFF (FOR THE LOCKING)

NHTSA ID

11102340

Incident

May 5, 2016

Mileage

100,000 mi

AFTER PASSENGER AIR BAG REPLACEMENT AIRBAG LIGHT WOULD COME ON INTERMITTENTLY. NOW AIRBAG LIGHT STAYS ON. ALSO FOUND MOISTURE FROM A/C BEING ON UNDER THE DASHBOARD AFTER PASSENGER AIR BAG WAS REPLACED. AIRBAG LIGHT STAYS ON ALL THE TIME UNTIL CAR IS TURNED OFF. MOISTURE FROM A/C IS WHEN A/C IS ON ANYTIME.

NHTSA ID

11099819

Incident

Jun 4, 2018

Mileage

120,000 mi

2008 SUBARU OUTBACK. CONSUMER WRITES IN REGARDS TO PASSENGER SIDE AIRBAG RECALL. CONSUMER STATES THAT VEHICLE WAS TOTALED AND WOULD LIKE FOR THEIR CONTACT INFORMATION TO BE REMOVED FROM DATABASE. *LD *JS

NHTSA ID

11097428

Incident

Apr 29, 2018

AIRBAG WARNING LIGHT SYSTEM IS ON INTERMITTENTLY, ESPECIALLY FOLLOWING COLD WEATHER. KEYWORDS: "SUBARU CODE 26 AIRBAG". IT IS CLEAR THAT THIS PROBLEM IS PERSISTENT AND OTHER SUBARU OWNERS REPORT THE SAME PROBLEM. THERE APPEARS TO BE A PROBLEM WITH INADEQUATE SOLDERING OF THE ELECTRONICS ON THE PRINTED CIRCUIT BOARD (PCB) RELATED TO THE AIRBAG WARNING LIGHT DISPLAY. IT IS UNCLEAR WHETHER THIS DEFECT IMPAIRS THE ABILITY OF AN AIRBAG TO DEPLOY IN THE EVENT OF AN ACCIDENT. IT CAN PRESENT ITSELF WHEN THE VEHICLE IS MOVING OR STATIONARY. MANY WEB-BASED ACCOUNTS OF THE PROBLEM HAVE REPORTED THAT CHANGES IN VEHICLE TEMPERATURE DUE TO WEATHER (PARTICULARLY ON COLD DAYS) MAY BE RELATED TO THE SOLDERING JOINT TO MALFUNCTION. IT IS NOT CLEAR TO ME WHETHER A PASSENGER IS IN DANGER IF THIS LIGHT IS ON OR IF IT IS A FAULTY SIGNAL THAT I CAN IGNORE. I WANT CLARITY REGARDING SAFETY.

NHTSA ID

11074497

Incident

Feb 18, 2018

Mileage

104,000 mi

ORIGINAL SOLDERING IN OVERHEAD CENTER CONSOLE WHERE PASSENGER AIRBAG ON/OFF LIGHT IS LOCATED WAS LOOSE CAUSING THE AIRBAG LIGHT ON THE DASH TO TURN ON. IT SEEMS TO BE A WIDESPREAD ISSUE WITH THIS GENERATION OF SUBARU OUTBACK. WITH THE AIRBAG LIGHT ILLUMINATED ON THE DASH THE AIRBAGS MAY NOT GO OFF IN AN ACCIDENT CAUSING A MAJOR SAFETY CONCERN.

NHTSA ID

11072418

Incident

Feb 22, 2017

Mileage

115,000 mi

TAKATA AIR BAG RELATED. WE REPLACED THE RECALLED PASSENGER TAKATA AIRBAG A WHILE AGO, AND AT THE SAME TIME PAID $297.95 TO THE DEALER TO FIX THE ISSUE (ERROR CODE 26) RELATED TO THE AIRBAG FAILURE INDICATOR WARNING LIGHT COMES. NOW WE ARE HAVING THE SAME PROBLEM AGAIN WITH THE AIRBAG FAILURE INDICATOR WARNING LIGHT, IT IS TURNED ON. SUBARU SHOULD BE PAYING FOR REPAIRING THIS RE-OCCURING PROBLEM WITH THE WARNING LIGHT AND REIMBURSING US FOR THE $297.95 WE PAID THE FIRST TIME TO FIX IT, SINCE SO MANY PEOPLE HAVE BEEN COMPLAINING ABOUT THIS PROBLEM.

NHTSA ID

11065536

Incident

Jan 27, 2018

Mileage

190,000 mi

"TAKATA RECALL" I UNDERSTAND THAT I MAY BE DRIVING A CAR WITH THESE AIRBAGS AND THAT THEY MAY CAUSE SERIOUS DAMAGE OR DEATH IN CASE OF AN ACCIDENT. NOTHING HAS YET HAPPENED, BUT IN THE CASE OF AN ACCIDENT THERE COULD BE SOMETHING SERIOUS.

NHTSA ID

11056982

Incident

Dec 26, 2017

Mileage

136,000 mi

AIRBAG REPLACED AS PER RECALL, BUT NOT LONG THERAFTER, THE AIRBAG LIGHT WENT ON AND WON'T GO OFF. APPARENTLY, THIS IS A COMMON PROBLEM, AND SUBARU SHOULD COVER IT. ALSO, REAR WHEEL BEARINGS FAILING AT 48K, VERY LOW MILEAGE FOR THEM TO NEED TO BE REPLACED.

NHTSA ID

11035894

Incident

Oct 23, 2017

Mileage

48,000 mi

SUBARU HAS AN EXTREMELY COMMON FAULTY WIRING ISSUE WITH AN LED PRINTED CIRCUIT BOARD THAT IS PART OF THE AIRBAG WARNING LIGHT SYSTEM THAT RESIDES IN THE MAPLIGHT ASSEMBLY ABOVE THE REAR VIEW MIRROR. THIS PROBLEM HAS BEEN REPORTED BY COUNTLESS VEHICLE OWNERS ACROSS A NUMBER OF MODELS (INCLUDING OUTBACK AND FORESTER) ACROSS A NUMBER OF MODEL YEARS. A SIMPLE GOOGLE SEARCH USING THE KEYWORDS: "SUBARU CODE 26 AIRBAG" REVEALS A TREASURE TROVE OF INFORMATION PERTAINING TO THIS ISSUE. IT IS CLEAR THAT THIS PROBLEM IS FREQUENT, PERSISTENT AND WIDESPREAD. THIS ISSUE HAS SPANNED A NUMBER OF MODELS AND MODEL YEARS. THE COMPANY AND ITS DEALERS CANNOT HELP BUT BE AWARE OF THE ISSUE. THERE APPEARS TO BE A PROBLEM WITH INADEQUATE SOLDERING OF THE ELECTRONICS ON THE PRINTED CIRCUIT BOARD (PCB) RELATED TO THE AIRBAG WARNING LIGHT DISPLAY. IT IS UNCLEAR WHETHER THIS DEFECT IMPAIRS THE ABILITY OF AN AIRBAG TO DEPLOY IN THE EVENT OF AN ACCIDENT. SUBARU REFUSES TO WARRANTY THIS DEFECT. IN ADDITION, SUBARU REFUSES TO HONOR THE TAKATA RECALL IF THIS FAULTY WIRING SYSTEM IS NOT FIRST REMEDIED. THE PROBLEM IS INTERMITTENT AND CAN PRESENT ITSELF WHEN THE VEHICLE IS MOVING OR STATIONARY. MANY WEB-BASED ACCOUNTS OF THE PROBLEM HAVE REPORTED THAT CHANGES IN VEHICLE TEMPERATURE DUE TO WEATHER (PARTICULARLY ON COLD DAYS) MAY BE RELATED TO THE SOLDERING JOINT TO MALFUNCTION.

NHTSA ID

11020944

Incident

Aug 29, 2017

Mileage

110,500 mi

TAKATA RECALL-- SUBARU "REPAIR" OF DEFECTIVE AIRBAGS DANGEROUS. WARNING LIGHT ILLUMINATES REGULARLY. SUBARU REFUSES TO FIX. ----NOTE SUBARU ALSO REFUSED TO REPAIR LONG REPORTED ISSUES WITH BRAKES, AIR BAG, WINDSHIELD. THEY SOUGHT $$THOUSANDS OF DOLLARS IN REPAIR BILLINGS. ALL THREE OF THESE LATER SUBJECT OF RECALLS. SUBARU REPORTED OIL CONSUMPTION DUE TO GASKET LEAKAGE, CONCERN FOR CAT CONVERTER AS POTENTIAL REPAIR BILLING. THIS APPEARS TO BE A FOURTH POTENTIAL SUBJECT OF RECALL NOW. ----- WHAT MORE HAS TO BE DEFECTIVE ON ONE CAR BEFORE ENTIRE CAR RECALLED?!

NHTSA ID

11014554

Incident

Aug 11, 2017

TAKATA RECALL. REPORTING MY CAR IS ON THE RECALL LIST. I WAS INFORMED WITH A LETTER FROM SUBARU MY CAR HAS THIS DEFECT. I AM MAKING AN APPOINTNENT TO HAVE IT REPLACED ASAP. IT HAS NOT DEPLOYED YET.

NHTSA ID

11012952

Incident

Aug 4, 2017

Mileage

88,439 mi

TL* THE CONTACT OWNS A 2008 SUBARU OUTBACK. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V323000 (AIR BAGS). THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. A UNKNOWN LOCAL DEALER WAS CONTACTED AND STATED THAT PARTS WERE UNAVAILABLE FOR THREE MONTHS. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

10991543

Incident

Dec 18, 2015