2008 Subaru Outback Engine Problems

Unknown why car sparked & ignited. Car was driven to grocery store 5min away then sat for approx. 2hrs before catching fire.

NHTSA ID

11746283

Incident

Feb 1, 2026

Four Subaru dealership licensed service centers in Maine and New Hampshire have had for some 8 weeks my Outback to evaluate, diagnose, and -upon my approval- service. Every one of the four Subaru locations was been unable to resolve a single one of these chronic problems of the Outback's erratic 1) start/no-start, 2) triggered security light and activated alarm, 3) dashboard battery and brake icons lighting/pulsing, 4) error code 55 (or SS) and 5) car headlights pulsing. The above problems compound with the issues Subaru's service teams have failed to resolve since early days of new car ownership (despite repeated repair) for 1) brakes regularly making noise, 2) radio randomly changing volume or shutting off, and 3) back tail light not working. Note: During the first two years of ownership, Subaru's service stated it "could not replicate" the problem with the brakes I'd reported within weeks of purchasing the new car. But a few weeks out of warranty, the same Subaru service location stated "I need whole new brakes" and quoted some $1,800 in repairs. A few months later, Subaru issued its first admission to the defective brake system. These four Subaru dealership licensed service centers in part or full 1) held my car at least 2x - 4x longer than quoted, while upselling me on the loaner model, then missing several by which they'd a written diagnostic report , 2) refused diagnostic report and when sought provided scant or impractical information, 3) demanded under threat of rental fees if loaner was not retuned within a couple of hours .... during a business day (including at distant locations too far to reach by deadline), and 5) sought many hundreds of dollars in payment for undisclosed and unapproved work without ever diagnosing issue, which they demanded in conjunction with the rental fees ginned up by dragging out and then failing to do the diagnostic work. Subaru USA added years of delay and refuses to honor manufacturer's or licensee-issued warranties.

NHTSA ID

11614816

Incident

Jan 1, 2020

THE TIMING BELT FAILED PREMATURELY. IT HAD BEEN REPLACED AT 70K MILES AND FAILED AT 140K MILES ON THE SECOND BELT WHICH ONLY HAD 70K MILES ON IT VERSUS THE MANUFACTURE RECOMMENDED 100K MILES REPLACEMENT INTERVAL. THIS HAPPENED DURING HIGHWAY TRAVEL AND THE VEHICLE IMMEDIATELY LOST ALL POWER AND ONLY HAD 5 SECONDS TO FIND A SAFE PLACE TO PULL OFF THE HIGHWAY. ADDITIONALLY, THE VEHICLE HAS AN AIRBAG RECALL FOR THE SECOND TIME, CITING DEATH DUE TO METAL PROJECTILE AND I AM HAVING A VERY HARD TIME HAVING THAT REPLACED AS THE CAR IS NOW BEING DRIVEN IN CANADA AND SUBARU DEALERS IN CANADA WON'T HONOR THE REQUIRED RECALL.

NHTSA ID

11322692

Incident

Apr 20, 2020

Mileage

145,000 mi

CAR CHECK ENGINE LIGHT ON, ALONG WITH TRACTION LIGHT ON, CRUISE LIGHT ON. CAN'T SHUT ANY OFF. CAR ACTUALLY GETS VERY HOT TO THE TOUCH DRIVERS SIDE NEAR FENDER HEADLIGHT. COULD START ON FIRE! DANGEROUS! THINK THERE IS A RECALL ON FRONT OXYGEN SENSOR, ONLY IF TURBO? REDICULOUS! SHOULD BE ALL NOT JUST TURBO MODEL! ALSO HAD TO REPLACE HEAD COVER GASKET AND EVERYTHING THAT GOES WITH THAT 5/17/2017 108,900 MILES. THAT SHOULD BE A RECALL ALSO.

NHTSA ID

11114370

Incident

Jul 27, 2018

Mileage

108,900 mi

TRANSMISSION FAILED, ON THE ROAD, PROBLEM SHIFTING, I WANT TO KNOW IF THERE HAS BEEN A RECALL. I COULD FIND THE PLACE TO ENTER THAT INFO. I AM NOT A MACHANIC!

NHTSA ID

11052268

Incident

Nov 13, 2017

VEHICLE HAS HAD SEVERE OIL LEAKING FOR 4 YEARS. DEALERSHIP INFORMED ME OF HEAD GASKET PROBLEMS, BUT ONLY OFFERED REPAIR AT FULL SHOP RATE PRICES. I SEE THIS A POTENTIAL FIRE HAZARD.

NHTSA ID

11016306

Incident

Mar 10, 2013

Mileage

55,000 mi

TAKATA RECALL-- SUBARU "REPAIR" OF DEFECTIVE AIRBAGS DANGEROUS. WARNING LIGHT ILLUMINATES REGULARLY. SUBARU REFUSES TO FIX. ----NOTE SUBARU ALSO REFUSED TO REPAIR LONG REPORTED ISSUES WITH BRAKES, AIR BAG, WINDSHIELD. THEY SOUGHT $$THOUSANDS OF DOLLARS IN REPAIR BILLINGS. ALL THREE OF THESE LATER SUBJECT OF RECALLS. SUBARU REPORTED OIL CONSUMPTION DUE TO GASKET LEAKAGE, CONCERN FOR CAT CONVERTER AS POTENTIAL REPAIR BILLING. THIS APPEARS TO BE A FOURTH POTENTIAL SUBJECT OF RECALL NOW. ----- WHAT MORE HAS TO BE DEFECTIVE ON ONE CAR BEFORE ENTIRE CAR RECALLED?!

NHTSA ID

11014554

Incident

Aug 11, 2017

I WAS DRIVING AND WITHOUT NOTICE THE CRUISE CONTROL SHUT OFF, BECAUSE OF A MINOR PROBLEM WITH THE CATALYTIC CONVERTER EFFICIENCY. HAD THE VEHICLE BEHIND ME BEEN ANY CLOSER I COULD HAVE BEEN REAR ENDED. IT TURNS OUT THAT SUBARU HAS PROGRAMED THEIR VEHICLES TO DO THIS. WHY WOULD ANYONE PROGRAM A CAR TO HAVE A SUDDEN LOSS OF POWER OVER SUCH A MINOR ISSUE.RECALLS FOR "KEYS TURNING OFF" HAVE HAPPENED, AND THE MANUFACTURERS KNEW ABOUT IT. SUBARU KNOWS THIS HAPPENS AND I HOPE THERE WILL BE A RECALL TO FIX THIS VERY DANGEROUS SITUATION. I HOPE THIS IS BOUGHT TO THE HIGHEST OFFICIALS AT NHTSA AND IS ADDRESS PROPERLY. I HOPE NO ONE GETS KILLED BEFORE THIS IS ADDRESSED.

NHTSA ID

10967192

Incident

Mar 19, 2017

Mileage

173,200 mi

MY CAR HAS HAD CYLINDER MISFIRES FOR OVER A YEAR. SUBARU HAS TOLD ME IT IS "NOT THEIR PROBLEM" AND THEY HAVE CHARGED ME OVER $2,000 FOR THE VARIOUS TIMES I HAVE BROUGHT IT IN TO FIX THE PROBLEM. THEY JUST "FIXED" IT LAST WEEK AND WITHIN 1 DAY, ALL MY CHECK ENGINE LIGHTS CAME BACK ON, AND WITHIN 3 DAYS IT IS MISFIRING AGAIN. THEY DO NOT RETURN MY CALLS OR PROPERLY SERVICE MY CAR. I BELIEVE THIS IS AN ENGINE RECALL PROBLEM THEY ARE AVOIDING FOR THE COSTS ASSOCIATED WITH THE RECALL. I DO NOT WANT THIS DANGEROUS CAR.

NHTSA ID

10925045

Incident

Dec 3, 2015

Mileage

98,000 mi

ALL OF BELOW: SINCE EARLY ORIGINAL OWNERSHIP, FOR YEARS SUBARU DISMISSED REPEATED REPORTING OF (MOVING, STATIONARY, ALL ROADS): TAKATA RECALL AIRBAG WARNING LIGHT ILLUMINATION. ONLY AFTER NATIONAL AIRBAG RECALL DID SUBARU RECOGNIZE CONCERN AND ADDRESS. SUBARU RECENTLY HAS SERVICED AIRBAG TWICE. BOTH TIMES, SHORTLY AFTER SERVICE DASH WARNING LIGHTS ILLUMINATED: AIRBAG, CRUISE, CHECK ENGINE. ALSO, ERRATIC CRUISE FUNCTION AND ENGINE CLICKING NOISE (MOVING, ALL ROADS) RESULTED. FOR NUMEROUS WEEKS, SUBARU HAS BEEN REFUSING TO FIX LETHAL AIRBAG/S AND REMEDY DAMAGE/CONCERNS RESULTING FROM AIRBAG SERVICE. SUBARU SEEKS PAYMENT FOR DIAGNOSIS (AND PRESUMABLY, SUBSEQUENT SERVICE) OF AIRBAG AND RELATED DAMAGE/CONCERNS AND A WRITTEN WAIVER FOR THIS SERVICE AND ANY FUTURE SERVICE NEEDS AS CONDITION OF SERVICE. BRAKES RUSTING, SQUEALING, SPONGINESS. WEEKS BEFORE WARRANTY EXPIRED SUBARU DISMISSED ISSUES. WEEKS AFTER WARRANTY, (AT SOME 25K MILES) SUBARU SOUGHT TO SELL SOME $1900 IN NEW BRAKES OR NEW CAR. SUBARU RELENTED MONTHS LATER, ADDRESSING CONCERN. THEREAFTER, FOLLOWING THE NATIONAL BRAKES RECALL, SUBARU REPORTED NO SERVICE NEEDED ON SECOND FULL SET OF BRAKES. THIS MONTH REPLACED 4 ROTORS (AND PADS)'THIS IS THE THIRD TIME 4 ROTORS INSTALLED ON ORIGINAL-OWNERSHIP CAR WITH SOME 65K MILES. ENGINE'S LOUD RATTLING, GURGLING. SUBARU EVENTUALLY ADMITTED AND SERVICED HEATSHIELD DEFECT. SUBARU HAS STATED REPEATEDLY HEATSHIELD ISSUE CAN'T BE RESOLVED. AFTER THREE SERVICES, SUBARU REPORTED RELATED ENGINE DAMAGE: OIL LEAK AND CATALYTIC. CHRONIC HEATSHIELD AND RELATED DAMAGE/CONCERNS ONGOING. WINDSHIELD INTERIOR POOLING WATER AND ICING (NEEDING SCRAPING OFF DESPITE WINTER-PACKAGE WINDSHIELD HEATING), AS WELL AS EXTERIOR WINDSHIELD SEAL SLIDING FREELY. ONLY AFTER SHIELD SPONTANEOUSLY CRACKED DID SUBARU RECOGNIZE ISSUES AND ADDRESS.

NHTSA ID

10899763

Incident

Aug 31, 2016

TL* THE CONTACT OWNS A 2008 SUBARU OUTBACK. THE CONTACT STATED THAT THE ABS, TRACTION CONTROL, ENGINE, AND OTHER UNKNOWN WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE FAILURE WAS UNABLE TO BE DIAGNOSED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 128,000.

NHTSA ID

10898479

Incident

Aug 19, 2016

Mileage

128,000 mi

2008 SUBARU OUTBACK. CONSUMER SEEKS REIMBURSEMENT FROM MANUFACTURERS CATALYTIC CONVERTER DEFECT RECALL REPAIRS. *SMD THE CONSUMER STATED A FEW DAYS AFTER PURCHASING THE VEHICLE, THE CHECK ENGINE LIGHT ILLUMINATED. A LOCAL REPAIR SHOP READ THE CODES AND EXPLAINED TO THE CONSUMER, THE CATALYTIC CONVERTER WAS FAILING. THE CONSUMER LEARNED SUBARU HAD ISSUED A SELECTIVE RECALL, ONLY HONORED IN CERTAIN STATES, ON THE CATALYTIC CONVERTER WITH A REPROGRAMMING OF THE ECM. THE CONSUMER PAID FOR THE REPLACEMENT OF THE CATALYTIC CONVERTER. HOWEVER, SHE IS REQUESTING REIMBURSEMENT. *JB

NHTSA ID

10721954

Incident

May 13, 2015

ENGINE HEAD GASKET IS LEAKING OIL. WARRANTY IS EXPIRED, BUT 74K MILES IS TOO EARLY FOR THIS MAJOR PROBLEM TO OCCUR. SUBARU CUSTOMER SERVICE HAS AGREED TO PAY FOR A PORTION OF THE REPAIR COST.

NHTSA ID

10715488

Incident

May 1, 2015

Mileage

74,000 mi

HEAD GASKETS FAILED AND, ONCE DISASSEMBLED, VALVES WERE FOUND TO BE LEAKING. *TR

NHTSA ID

10679991

Incident

Jan 21, 2015

Mileage

100,450 mi

IN JULY FOLLOWING THE REPLACEMENT OF OUR CATALYTIC CONVERTER I WROTE TO SUBARU TO INQUIRE ABOUT REIMBURSEMENT. THERE WAS NO RESPONSE. THE REPLACEMENT COST WAS $728.08. APPARENTLY ONLY SEVEN STATES ISSUED A MANDATORY RECALL. VIRGINIA ISN'T ONE OF THEM. THE VEHICLE WAS RELIGIOUSLY MAINTAINED, ALL SUPPORTED BY DOCUMENTATION. AT 97,600 MILES THE CATALYTIC CONVERTER WEARING OUT HAD SOMETHING TO DO WITH THE PART ITSELF. REIMBURSEMENT FOR THIS CATALYTIC CONVERTER WOULD GO A LONG WAY IN OUR FUTURE DECISION OF WHICH BRAND CAR TO BUY. IT'S KNOWN IN MARKETING IT COSTS A LOT LESS TO KEEP A CUSTOMER THAN TO GAIN A NEW ONE. *TR

NHTSA ID

10660018

Incident

Jul 18, 2014

Mileage

97,600 mi

BLOWN HEAD GASKET, DAMAGE OCCURRED OVER MANY YEARS WHILE CAR WAS UNDER WARRANTY AND WAS BEING SERVICED REGULARLY BY THE SUBARU DEALER. NO NOTIFICATION OF THIS DAMAGE WAS GIVEN TO ME UNTIL THE CAR WAS JUST OUTSIDE OF ITS WARRANTY. PREVIOUSLY SUBARU HAS ACKNOWLEDGED THIS DEFECT WHICH COULD CAUSE AN ENGINE TO SEIZE WHILE DRIVING CAUSING A SAFETY ISSUE IF THAT OCCURRED ON A HIGHWAY. *TR

NHTSA ID

10644758

Incident

Jun 17, 2014

Mileage

75,815 mi

VEHICLE OVERHEATED, DROVE TO NEAREST SERVICE STATION. RADIATOR FLUSHED AND TESTED FOR LEAKS, NONE FOUND. NO OTHER DETERMINATION MADE. CAR OVERHEATING, SLOW COOLANT LOSS. SUBARU DIAGNOSED MAJOR HEAD GASKET FAILURE PROBABLY OCCURRED PRIOR TO 73000 MILES, BUT BEYOND POWER TRAIN WARRANTY. SUBARU HQ DECLINED TO HELP WITH COST CONSIDERING THE SERVICE TECH MGR STATED A 2008 MODEL CAR SHOULD NOT HAVE THIS FAILURE. PREVIOUSLY OWNED 1998 SUBARU OUTBACK WITH SIMILAR GASKET FAILURE SOME TIME AFTER POWER TRAIN WARRANTY EXPIRED. COSTLY REPAIR. *TR

NHTSA ID

10513068

Incident

Jun 18, 2012

Mileage

73,000 mi

VEHICLE STARTED RUNNING BIT ROUGH WHILE IDLING AT INTERSECTION; UPON ACCELERATION, CHECK ENGINE LIGHT AND OTHER INSTRUMENT LIGHTS STARTED FLICKERING AND CAR STALLED. RESTARTED NORMALLY. *TR

NHTSA ID

10447686

Incident

Feb 10, 2012

Mileage

63,046 mi

MY CAR ENGINE STALLS IN THE MIDDLE OF THE ROAD WHILE DRIVING AND WHILE MAKING A LEFT TURN IN A SIGNAL, WHILE WAITING ON THE RED LIGHT AND WHILE STOPING AND IDLING AT THE PARKING LOT. WHEN THIS ISSUE HAPPENS ALL THE LIGHTS IN THE DASH LIGHTS UP AND THE STEERING WHEEL BECOMES LOCKED. THIS ENGINE STALLING ISSUE HAPPENS RANDOMLY. SOME TIMES EVERY DAY IN A WEEK, 2 DAYS IN A WEEK OR 3 DAYS IN A WEEK. SOME TIMES THE ENGINE STALLS MORE THAN 10 TIMES IN A DAY. IN ORDER TO CORRECT THIS ISSUE, I TOOK MY CAR TO SUBARU DEALERSHIP AND EXPLAINED THE SERVICE TECHNICIAN THE PROBLEM. FIRST TIME, I WAS ASKED TO LEAVE MY CAR AT THE DEALER SHIP OVERNIGHT TO SEE IF DEALER CAN RECREATE THE PROBLEM. DEALER TOLD ME HE COULDN'T RECREATE THE ISSUE. SECOND TIME, DEALER FOUND CHECK ENGINE LIGHT ON AND USED THE DIAGONSTIC TOOL TO FIND OUT THAT MASS AIR FLOW SENSOR IS BAD AND REPLACED IT. BUT THIS DIDN'T FIX THE PROBLEM. THIRD TIME I CONTACT SUBARU CUSTOMER SERVICE AND EXPLAINED THE ISSUE. SUBARU CUSTOMER SERVICE ASKED ME TO TAKE MY CAR TO THE DEALERSHIP AGAIN. I TOOK MY CAR TO DEALERSHIP AND LEFT IT THERE FOR 2 DAYS. ON THE THIRD DAY, DEALER SAID THE BATTERY WAS BAD AND REPLACED THE BATTERY AND SAID HE COULDN'T REPRODUCE THE ISSUE. WHEN I TOOK THE CAR BACK FROM THE DEALERSHIP ON THE THIRD DAY, WITHIN FEW HOURS MY CAR ENGINE AGAIN STALLED. THIS TIME I TOOK THE VIDEO OF THE ISSUE. I CONTACTED THE SUBARU CUSTOMER SERVICE AND EXPLAINED WHAT WAS HAPPENING AND I WAS TOLD THAT DEALER CANNOT FIX THE ISSUE UNLESS HE CAN RECREATE THE ISSUE. SO I TOOK MY CAR TO SUBARU DEALERSHIP MORE THAN 3 TIMES, SPENT MORE THAN $1000 FOR PARTS, LABOR AND CAR RENTAL AND STILL THE PROBLEM IS NOT FIXED. ACTUALLY IT IS GETTING WORSE DAY BY DAY. *TR

NHTSA ID

10398135

Incident

Aug 10, 2010

Mileage

54,000 mi

THE PROBLEM IS THE CAR SUDDENLY LOOSING POWER AT VARIOUS SPEEDS FOR NO APPARENT REASON. HAS OCCURRED OVER 6 TIMES IN THE PAST MONTH, 4 TIMES IN THIS LAST WEEK. THE MOST RECENT ON 4/30/10 THE CAR COMPLETELY SHUT DOWN WHILE DRIVING AT A SPEED OF 20 MPH. NO WARNING INDICATORS CAME ON THE DASHBOARD. FIRST TIME WAS WHEN ACCELERATING UP AN ON RAMP AND SEVERAL MORE TIMES ON OTHER INCLINED RAMPS, THEN LEAVING A STREET TO ENTER A HWY 4/28/10, ANOTHER AT A COMPLETE STOP THE CAR SHUDDERED 4/29/10, SAME DAY TRAVELING AT 60 MPH LOST POWER FOR A BRIEF MOMENT THEN RESUMED, THESE TWO INCIDENTS WERE WITHIN 5 MINUTES. I HAVE TAKEN IT TO THE DEALER WHERE PURCHASED AND SERVICED TO HAVE THEM LOCATE AND REPAIR THE PROBLEM. HAVE NOT RECEIVED INFORMATION AS YET. *TR

NHTSA ID

10328667

Incident

Apr 30, 2010