Owner-reported complaints naming the electrical system, filed with NHTSA
Data refreshed
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories. Every record below is an owner-reported complaint about the 2009 Subaru Outback submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 23 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
The rear hatch on this Outback won't lock. As a woman on her own, my safety is at risk. I have read of other people who have this issue and has been able to fix this on their own. This is a safety issue if your vehicle won't lock completely because the wires in the hatch are compromised.
The contact owns a 2009 Subaru Outback. The contact stated that the vehicle failed to restart after being parked. The contact stated that several attempts were needed to start the vehicle. The contact stated that the battery was charged to start the vehicle. The contact was informed by a tow truck mechanic, who assisted with jumping starting the vehicle, that the end switch needed to be replaced. The information was confirmed by another certified mechanic. The contact stated that a certified mechanic was contacted to schedule a repair however, the vehicle was not yet repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 115,000.
The contact owns a 2009 Subaru Outback. The contact stated while driving at various speeds, the vehicle shut-off with the check engine, traction control and cruise control warning lights illuminated. On several occasions the vehicle would not immediately restart. The vehicle was taken to the local dealer for service. No further information was available. The manufacturer was also notified of the failure. The failure mileage was 81,000. The VIN was not available.
PREVIOUSLY SUBMITTED COMPLAINT REGARDING MY SUBARU OUTBACK STALLING. I WAS ASSIGNED COMPLAINT NUMBER 11414502 (ATTACHED) BUT WHEN I DIDN'T RECEIVE THE EMAIL, I CHECKED AND IT DIDN'T PULL UP SO I'M RESUBMITTING.
THE CAR INTERMITTENTLY BUCKS/CHUGS WHILE DRIVING AND THEN STALLS. ALL THE LIGHTS FLASH ON. IT IS DIFFICULT TO RESTART. IT HAS HAPPENED ON THE HIGHWAY AND LOCAL STREETS. IT ALSO IDLES VERY ROUGH WHEN AT STOPS OR IN PARK AND SHUDDERS LIKE IT WANTS TO STALL - SOMETIMES IT DOES. THIS HAS BEEN GOING ON FOR 2 MONTHS NOW. THE FIRST TIME, I WAS STOPPED AT A RED LIGHT AND IT STALLED CREATING A HAZARDOUS SITUATION. MY MECHANIC HAS ATTEMPTED TO FIX IT AND THEN HE HAS TAKEN IT TO THE LOCAL SUBARU DEALERSHIP WHERE IT HAS SPENT ALMOST 2 MONTHS OFF & ON WHILE THEY "FIXED" IT. THEY GIVE IT BACK AND IT IS BACK TO THEM WITHIN A WEEK WITH THE SAME ISSUE. THE LAST TIME THEY REPLACED A MAP SENSOR AND SOME WIRING. THIS IS HAZARDOUS AND THE VEHICLE IS UNSAFE. IT FEELS LIKE THEY JUST KEEP CLEARING OUT THE ERROR AND GIVING IT BACK TO ME.
CAR INTERMITTENTLY STALLS AND IS HARD TO RESTART. HAPPENS RANDOMLY WITH NO CHECK ENGINE LIGHT OR CODE IN THE ECU. HAS HAPPENED ON THE HIGHWAY AT INTERSTATE SPEED AND WHILE STOPPED. WILL NOT RESTART IMMEDIATELY. ROUGH IDLE AT RESTART THEN BACK TO NORMAL. MECHANIC WAS UNABLE TO RECREATE THE PROBLEM AND THUS UNABLE TO REPAIR. CREATES POTENTIALLY DANGEROUS SITUATION WHEN STALLING ON THE HIGHWAY, INTERSECTION, ETC. *TR
2009 SUBARU OUTBACK STALLING WHILE DRIVING. THE ENGINE TURNED OFF WHILE DRIVING WITH LIGHT ACCELERATION AT LOW SPEEDS (5-20 MPH) WITHOUT WARNING. WARNING LIGHTS FLICKERED ON AND OFF. I WAS ABLE TO RESTART THE CAR. THIS IS A HUGE SAFETY ISSUE TO HAVE THE CAR STALL OUT WITHOUT WARNING. SUBARA SOUTH BLVD DEALERSHIP SAY THEY DO NOT KNOW THE ROOT CAUSE. PRIOR TO THE ABOVE INCIDENCE THE CAR, WHILE DRIVING AT LOW SPEEDS, WOULD OCCASIONALLY SHUDDER AND THE WARNING LIGHTS WOULD FLICKER ON THEN GO OFF. IT FELT LIKE THE CAR WAS GOING TO SHUT OFF BUT IT DIDN'T. NOW IT IS SHUTTING OFF. IT'S COMPLETELY UNSAFE.
THERE IS A WELL DOCUMENTED FAULTY DESIGN ISSUE THAT LEADS TO FAILURE OF THE WIRING HARNESS (REAR GATE CORD) TO THE REAR WAGON DOOR/GATE OF THIS MODEL SUBARU OUBACK WAGONS. FAILURE OF THE WIRING HARNESS HAS AFFECTED ME WHILE DRIVING THE VEHICLE. AS THIS ISSUE HAS PROGRESSED, MORE AND MORE WIRES BREAK, COMPLETELY SEVERED, AND LEAD TO THE REAR LOCK NOT WORKING, THEN BACKUP LIGHTS NOT WORKING, REAR DEFROSTER NOT WORKING, WIPER NOT WORKING, AND LICENSE PLATE LIGHT NOT WORKING. THIS IS A SAFETY ISSUE, ESPECIALLY THE BACKUP LIGHTS, REAR DEFROSTER, REAR WIPER, AND LOCKING MECHANISM NOT WORKING AT ALL! THESE COMPROMISE VISIBILITY AND CAR SAFETY. THIS FAULTY DESIGN, OR FAULTY MATERIAL CHOICE IS CLEARLY SUBARU'S FAULT: SEVERED ELECTRICAL WIRES, AS A RESULT OF NORMAL USE, SHOULD NOT BE ACCEPTABLE, ESPECIALLY WHEN THEY COMPROMISE SAFETY BY DISABLING BACKUP LIGHTS AND THE REAR LOCK. WHILE THE REPLACEMENT CABLE ITSELF IS ONLY $63, THE SUBARU DEALERSHIPS WANT TO CHARGE OVER $500 IN LABOR. I AM REALLY DISAPPOINTED THAT THERE HAS BEEN NO RECALL, OR SUPPORT ON THIS ISSUE FROM SUBARU OF AMERICA. I CANNOT FIND ANY OFFICIAL RESPONSE FROM SUBARU ON THIS ISSUE. I DON'T THINK IT'S FAIR TO HAVE LOYAL CUSTOMERS LIKE MYSELF, PAY EXCESSIVE LABOR CHARGES TO FIX A SAFETY PROBLEM THAT IS A DESIGN FLAW FROM SUBARU.
THE WIRING IN REAR HATCH IN REALLY BAD SHAPE SOME SHOWING THE COPPER AND TWO COMPLETELY BROKE APART. CAUSING THE LATCH NOT TO WORK AND ALARM GOING OFF. REAR WIPER NOT WORKING.
INDIVIDUAL WIRES IN THE HARNESS POWERING AND CONTROLLING THE BRAKE, TURN, BACKUP, AND LICENSE PLATE LIGHTS, AND THE REAR WIPER MOTOR AND WASHER PUMP, MAY FAIL WITHOUT WARNING. THIS FAILURE COULD RESULT IN AN REAR END COLLISION OR IMPAIRING VISION OUT THE REAR WINDOW IN INCLEMENT WEATHER. THE POINT OF FAILURE IS INSIDE THE FLEXIBLE RUBBER BOOT PROTECTING THE HARNESS WHERE IT PASSES FROM THE REAR FRAME OF THE MAIN BODY TO THE TOP OF THE REAR LIFT GATE. IT APPEARS THAT REPEATED FLEXING OF THE WIRES INSIDE THE PROTECTIVE BOOT, AS THE REAR LIFT GATE IS OPENED AND CLOSED, WORK HARDENS THE INSULATION AND COPPER WIRES CAUSING THEM TO EVENTUALLY BREAK. SYMPTOMS MAY APPEAR AS STATIC ON THE RADIO, FAILING REAR LIGHTS, AND/OR FAILING REAR WIPER/WASHER MOTORS. IN MY CASE, I EXPERIENCED RADIO STATIC AND A FAILURE OF THE REAR WIPER/WASHER MOTORS. TROUBLE SHOOTING LED ME TO CUT OPEN THE PROTECTIVE BOOT REVEALING THE BROKEN WIRES. FURTHER INSPECTION REVEALED THAT THE WIRE INSULATION WAS BRITTLE IN THE AREA OF THE BREAKS. A SEARCH ONLINE REVEALED THIS IS NOT AN ISOLATED INCIDENT.
AFTER FUSES BLOWN REPEATEDLY AND REPLACED, REAR WIPER, WASHER PUMP AND LOCK CEASED TO OPERATE FOR PERHAPS A YEAR. RECENTLY THE HEADLIGHTS GOT REAL FUNKY - WOULD NOT OPERATE IN NORMAL "ON" POSITION. BUT THEN SOME STRANGE BEHAVIOR WHEN SHIFTED INTO REVERSE (IGNITION ON WITHOUT STARTING TO ALLOW SHIFTING). HEADLIGHTS STILL NOT LIT IN EITHER OFF OR ON POSITION, BUT THEN CAME ON AS SWITCH MOVED BACK FROM HEADLIGHTS ON TO RUNNING LIGHTS POSITION! I HAPPENED UPON THE VIDEO MENTIONED IN AN EARLIER POST ABOUT REAR WIRING HARNESS ISSUE WHICH EASILY COULD HAVE BEEN RELATED TO WIPER/LOCK ISSUE, SO TOOK A LOOK. INSPECTION REVEALED 11 SEVERED WIRES WITH A CLUMP OF 5 OR SO MELTED TOGETHER AND ANOTHER 3 WIRES NEARLY SEVERED (SEE PHOTOS). DEALER SAYS HE'LL REPLACE WIRING HARNESS FOR $350 -500, AND HAD A SAME GENERATION OUTBACK IN THE SHOP FOR SAME WORK. SERVICE MGR SUGGESTED A CALL TO SUBARU CUSTOMER CARE LINE. IF YOU HAVE GOOFY ELECTRICAL ISSUES, ESPECIALLY IN REAR, CHECK THE WIRING INSIDE BOOT FROM BODY TO DOOR ON UPPER RIGHT SIDE. IT'S NOT EASY TO GET AT AS WIRES ARE SHORT, WHICH MAY HAVE LED TO QUITE A SERIOUS, UM, SHORT. CALL SUBARU BEFORE YOUR HEADLINER IGNITES...
REAR HATCH WIRING HAS WORN TO THE POINT OF FULLY BREAKING FOUR AND DAMAGING FIVE OTHER WIRES OUT OF APPROXIMATELY 14 TOTAL GOING THROUGH THE FLEXIBLE BOOT BETWEEN THE BODY AND THE HATCH ON THE PASSENGER SIDE OF THE VEHICLE. SYSTEMS AFFECTED: REAR WIPER, REAR LOCK, POSSIBLY THE BRAKE LIGHT AND LICENSE PLATE LIGHTS. THIS WAS DAMAGE INCURRED OVER TIME OF NORMAL USE, OPENING THE HATCH NO MORE THAN ONCE PER DAY.
THE REAR GATE WIRING HARNESS FAILED, CAUSING REAR BRAKE LIGHTS AND TAIL LIGHTS TO STOP WORKING. WITHOUT REPLACING THE REAR GATE WIRING HARNESS ($88.80 PARTS + $448.80 LABOR + 51.07 TAX) SOON THE REAR WIPER AND DEFROST WOULD NOT WORK AND THE BACK HATCH WOULD LOCK. THIS IS A SERIOUS SAFETY ISSUE, I WANT TO SEE A RECALL AND REIMBURSEMENT OF $588.67 FROM SUBARU OF AMERICA.
REAR GATE ELECTRICAL CORD PREMATURE FAILURE AT RUBBER ACCORDION BEND
THE BRAKE LIGHTS, HATCH LOCK, WIPER AND OTHER ELECTRICAL COMPONENTS ON THE REAR PART OF MY SUBARU 2009 OUTBACK STOPPED WORKING OR WORKING ERRATICALLY. I CHECKED THE RUBBER BOOT CONTAINING THE REAR WIRING HARNESS FOR DAMAGE AND DISCOVERED 13 OUT OF 14 WIRES WERE EITHER COMPLETELY BROKEN, OR THE INSULATION WAS WORN, EXPOSING BARE CONDUCTOR. IN ADDITION TO THE REAR ELECTRICAL ISSUES, I REPLACED THE BULBS FOR THE HEADLIGHTS AT LEAST FOUR TIMES IN A TWO YEAR PERIOD. THE AM CHANNEL ON MY RADIO NO LONGER RECEIVES SIGNALS. THE REAR ELECTRICAL PROBLEMS ARE CAUSING A SAFETY HAZARD DUE TO THE BRAKE/TAIL LIGHTS NOT FUNCTIONING, OR THE REAR WINDSHIELD WIPER NOT WORKING. SUBARU IS NOT RESPONSIVE TO THIS DESIGN FLAW.
WHEN IT RAINED DASH LIGHTS COME ON WOULD NOT GO OUT WHEN TURNED CAR ON FOR A FEW DAYS NEXT RAIN WENT TO CHECK CAR WHEN STARTED LIGHTS CAME ON THEN ALL WENT OUT AND A LOUD NOISE AND FIRE UNDER HOOD
WHEN LOCKING THE VEHICLE, THE REAR LIFT GATE WILL NOT LOCK. SUBARU DEALERSHIP FOUND A BROKEN WIRE LEADING TO THE REAR LIFT GATE ACTUATOR, AND FIXED. JUNE 2015, PROBLEM OCCURRING AGAIN. JUST LOOKED, AND WIRE WAS BROKEN AGAIN (FOUND BY REMOVING PASSENGER SIDE RUBBER BOOT COVERING WIRES BETWEEN LIFT GATE AND BODY). WILL TRY TO FIX MYSELF, THIS TIME.
PROBLEM 1: EXPERIENCED REAR WIPER (STATION WAGON) NOT WORKING. CAR STILL UNDER WARRANTY, TOOK IT TO THE DEALER AND WAS TOLD THE WIRING HARNESS THAT GOES THROUGH THE HINGE AREA WAS BROKEN. IT WAS REPAIRED. NOW THE CAR HAS 72,000 MILES AND I AM HAVING REAR WIPER PROBLEMS AGAIN AS WELL AS THE REAR DOOR NOT LOCKING. WIRES FRAYED AND BROKEN AGAIN. THIS IS A KNOWN ISSUE BOTH WITH SUBARU AND ON THE FORUMS ON THE WEB. THIS IS A POOR DESIGN AND POSSIBLY DANGEROUS AS IT CAN CAUSE THE REAR LIGHTS TO FAIL. FAILURE TIME FRAME WAS ALMOST DOUBLE MILEAGE FROM THE PREVIOUS FAILURE. (35,251 - 72,000). PROBLEM 2: AIR BAG LIGHT KEEPS COMING ON. HAVE HAD IT TO THE MECHANIC SEVERAL TIMES TO BE CHECKED OUT AND RESET. THIS IS ALSO A KNOWN PROBLEM WITH SUBARU AND ON THE WEB FORUMS. THIS IS A SERIOUS SAFETY ISSUE AS THE AIR BAGS COULD FAIL TO DEPLOY. SUBARU MAY SAY THE AIRBAGS ARE A "SECONDARY" SAFETY FEATURE, BUT TO ME THEY ARE EXTREMELY IMPORTANT. AIRBAG DEPLOYMENT CAN BE THE DIFFERENCE BETWEEN LIFE AND DEATH IN AN ACCIDENT. PLEASE INVESTIGATE! *TR
"AIR BAG" WARNING LIGHT IN THE INSTRUMENT PANEL (COMBINATION METER) IS ON. THE AIRBAG LIGHT HAS COME ON SINCE IT HAS BEEN COLD OUT. IT KEEPS ON EVERY COLD DAY. IT IS A SAFETY ISSUE AND IF POSSIBLY NOT DEPLOYING THE SRS TO PROTECT DRIVER AND PASSENGER IN A COLLISION. THIS PROBLEM WAS REPORTED BY MANY DRIVERS OF SUBARU, BUT SUBARU COMPANY IS STILL NO RESPONSE. *TR
09 OUTBACK WAS BLOWING FUSES ON THE DOOR LOCK CIRCUIT. PUT IN A NEW FUSE AND IT WOULD BLOW IN A FEW DAYS, OFTEN WHEN CAR WASHED OR DRIVEN IN RAIN (OR PERHAPS WHEN REAR HATCH OPERATED). LAST REPLACEMENT FUSE HAS HELD FOR A FEW WEEKS NOW, THROUGH SUMMER. THEN THE REAR WIPER STOPPED WORKING. SAW THIS VIDEO AND THEN PULLED THE WIRING BOOT CONNECTING HATCH WITH BODY (TO RIGHT OF HATCH HINGES) AND SURE ENOUGH FOUR WIRES ARE SNAPPED RIGHT WHERE VIDEO SHOWS - AT BOTTOM OF RIGHT BOOT: HTTPS://WWW.YOUTUBE.COM/WATCH?V=AMEKPTVGMHS. *TR
2009 SUBARU OUTBACK. CONSUMER WRITES IN REGARDS TO VEHICLE SHUTS DOWN WHILE DRIVING. *SMD THE CONSUMER BELIEVED THE VEHICLE SHUTTING DOWN, WAS THE RESULT OF A FAULTY IGNITION. *JB
THE HEADLIGHTS ON THIS VEHICLE ARE GROSSLY INADEQUATE WHEN USING LOWER BEAMS. I HAVE CONTACTED SUBARU AND WAS TOLD THAT THERE IS NO PROBLEM. I CONTACTED THE LOCAL DEALER AND WAS INFORMED THAT THEY ARE AWARE OF THE PROBLEM, BUT NOTHING CAN BE DONE - IT IS A SUBARU ENGINEERING DECISION TO HAVE THAT 'QUALITY' OF HEADLIGHT. *TR
STARTED MY CAR AT NIGHT TO FIND OUT MY HEADLIGHTS WOULD NOT TURN ON, BUT THE SAFELY LIGHTS WERE STILL ON. UPON FURTHER INSPECTION, THE BRAKE LIGHTS AND REVERSE LIGHTS WOULD NOT WORK EITHER. THE LIGHTS ABOVE MY REAR LICENSE PLATE HAD BEEN OUT FOR A COUPLE OF WEEKS ALSO SO I AM NOT SURE IF THAT IS RELATED AS WELL. LOOKED ON-LINE TO FIND OUT MANY OTHER SUBARU OUTBACK OWNERS HAD A SIMILAR PROBLEM AND SUGGESTED LOOKING AT THE HARNESS THAT HOUSED MANY ELECTRICAL WIRES ON THE UPPER CORNERS OF THE HATCHBACK. MANY OF THE WIRES WERE EITHER BROKEN OR LOOSE. I HAVE READ THAT BECAUSE OF ITS LOCATION, THE WIRES BECOME BRITTLE AND BREAK BECAUSE THEY ARE CONSTANTLY BEING BENT WHEN YOU OPEN AND CLOSE THE REAR HATCHBACK DOOR. TOOK MY CAR INTO THE DEALERSHIP AND THEY HAD TO RESOLDER THE WIRES AND CHARGED ME $225 FOR THE LABOR AND PARTS NEEDED. IF I HAD TO REPLACE THIS, IT WOULD HAVE COST ME OVER $600 SO THE DEALERSHIP DISCOURAGED ME FROM DOING THIS. I FEEL THIS SHOULD BE COVERED BY SUBARU SINCE IT IS DUE TO BAD DESIGN AND PERFORMANCE AND THE SERVICE I HAD DONE DOES NOT GUARANTEE THAT THIS WILL NOT HAPPEN AGAIN. *TR
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .