2006 Sunnybrook Titan

WE PURCHASED THE 2006 SUNNYBROOK TITAN FROM BUDDY GREGG BACK ON JULY 7, 2017. THE SECOND WEEKEND OF USING THE UNIT STARTED WITH THE FAILURE OF THE IOTA ITS-50R TRANSFER SWITCH. WIRE AND INSULATION BURNED, THE TERMINAL LUGS MELTED/FUSED, AND THE PLASTIC COVER STARTED TO MELT. THE RV WAS STATIONARY. WE WERE ABLE TO GET A TECHNICIAN TO RESPOND SATURDAY AFTERNOON AFTER SALESMAN TOLD ME THE SERVICE DEPARTMENT AT BUDDY GREGG WAS NOT OPEN ON SATURDAY. AFTER REPLACING THE ATS, THE TECH FOUND THE HEATING ELEMENT OF THE REFRIGERATOR WAS FRIED AS WELL AS THE CONVECTION MICROWAVE. THE TECH WAS ABLE TO REPLACE THE HEATING ELEMENT AND REPAIR THE REFRIGERATOR. A FEW HOURS AFTER THE TECH LEFT, THE REFRIGERATOR BOARD APPEARED TO FAIL, THE 12V LIGHTS DIMMED, AND THE PROPANE ALARM WAS TRIPPED. THE LIGHT PATTERN ON THE ALARM INDICATED A POWER FAILURE. WE CONTACTED THE TECH AND DETERMINED THE CONVERTER/INVERTER WAS EVIDENTLY IRREPARABLY DAMAGED BY THE FAILURE IOTA TRANSFER SWITCH. WE NOW HAVE TO HAVE THIS REPLACED. RESEARCH REVEALS THE IOTA ITS-50R TRANSFER SWITCH HAD SEVERAL RECALLS ISSUED FOR IT SEVERAL YEARS AGO. ONE INCLUDED THE TIGHTENING OF TERMINAL LUGS TO 45 POUNDS AND ONE ISSUED LATER FOR TOTAL REPLACEMENT OF THE UNIT. OBVIOUSLY THE PREVIOUS OWNERS OF THIS RV EITHER DID NOT EVER GET A RECALL NOTICE, OR JUST OPTED NOT TO HAVE THE UNIT REPLACED. ALTHOUGH WE UNDERSTAND THIS RV WAS USED WHEN WE PURCHASED IT AND WAS ASSURED IT HAD PASSED THROUGH SOME TYPE OF INSPECTION BY THE DEALERSHIP. AT MINIMUM, AS NEW RV OWNERS WE EXPECTED AND RELIED ON THE DEALERSHIP/SERVICE EXPERTISE TO ENSURE THE UNIT WAS SAFE. NEVER IN OUR WILDEST NIGHTMARES WOULD WE HAVE EXPECTED POTENTIALLY CATASTROPHIC EVENT OF THIS NATURE THE SECOND TIME USING IT. THAT SAID, WE ARE ALSO VERY GRATEFUL IT OCCURRED WHILE WE WERE AWAKE AT THE TIME AND IT DIDN'T DEVELOP INTO A FIRE.

NHTSA ID

11015038

Incident

Aug 11, 2017

BY READING RV.NET I LEARNED OF A RECALL ON DOMETIC REFRIGS, INSTALLED IN RVS. I CALLED OUR DEALER WHO DIDN'T THINK OUR REFRIG WAS PART OF THE RECALL. I CALLED DOMETIC AND THEY SAID IT WAS BUT IT IS UP TO OUR DEALER TO NOTIFY US. THE DEALER SAID HE HAS HAD NO INFO ON THIS. MY COMPLAINT IS "WHY AREN'T WE NOTIFIED BY DOMETIC OF THE RECALL? IF I HADN'T READ OF THIS ON RV.NET I WOULD HAVE NEVER FOUND OUT AND SOMETHING IS WRONG WITH THIS PRACTICE. OUR REFRIG DIDN'T CATCH ON FIRE BUT THE POTENTIAL IS THERE. THE CAMPER IS SCHEDULED TO BE FIXED BUT THAT DOESN'T MAKE ME FEEL ANY BETTER IN REGARDS TO THE WAY WE WEREN'T NOTIFIED. THANKS. *TR

NHTSA ID

10232739

Incident

Jun 30, 2008

ON 3 MAR 08 7:50 AM CALIF. HI 95 MILE MARKE56 I HEARD A LOUD NOISE CHECKED THE RIGHT MIRROR FIRST THEN THE LEFT WHEN I SAW THE LEFT FRONT TIRE COMING APART. THE DAMAGE TO THE R.V. IS VERY EXTENSIVE, SOME WHERE BETWEEN 3,000.00 AND 6,000.00 DOLLARS. THE DEALER IS STILL ASSESSING THE DAMAGE. I TOOK THE R.V. ,WITCH IS A 32 FOOT 5TH WHEEL TO MY TIRE DEALER AND THEY FOUND THE OTHER TIRE ON THE SAME SIDE READY TO BLOW ALSO. AS A RESULT I HAD TO REPLACE ALL 5 TIRES ON THE TRAILER TO PREVENT ANY MORE DAMAGE. THE TIRES ARE KARRIER LOAD STAR ST235/80R16 DOT#7YHJ ANC 3505. *TR

NHTSA ID

10220800

Incident

Mar 4, 2008

TL*THE CONTACT OWNS A 2006 SUNNYBROOK 5TH WHEEL CAMPER (NA). THE VEHICLE HAS LOADSTAR KENDA TIRES (NA). WHILE DRIVING 60 MPH, THE PASSENGER SIDE TIRES BLEW OUT. WHILE DRIVING APPROXIMATELY 58 MPH, THE CONTACT NOTICED THE TREAD SEPARATING FROM THE TIRE. SHE NOTIFIED THE MANUFACTURER AND THEY SENT HER FIVE NEW TIRES. SHORTLY AFTERWARDS, WHILE DRIVING 61 MPH, THE DRIVER SIDE TIRE BLEW OUT. THE TIRE PRESSURE OF ALL THE TIRES WAS 90 PSI. SHE NOTIFIED THE DEALER AGAIN AND THEY STATED THAT THE TIRES WERE DEFECTIVE. THE NUMBER OF CYLINDERS, ENGINE SIZE, POWERTRAIN, AND TIRE SIZE WERE UNKNOWN. THE FAILURE MILEAGE WAS 2,500 AND CURRENT MILEAGE WAS 3,000. UPDATED 10/31/07. *JB

NHTSA ID

10206005

Incident

May 13, 2006

Mileage

2,500 mi

TL*THE CONTACT OWNS A 2006 SUNNYBROOK TITAN WITH KARRIER LOADSTAR TIRES 235R8016. WHILE DRIVING 60 MPH THE DRIVER SIDE FRONT TIRED EXPERIENCED A BLOWOUT. THE TIRE WAS REPLACED AND THE DEALER DID NOT INSPECT THE TIRE. APPROXIMATELY TWO DAYS LATER WHILE DRIVING 60 MPH HE EXPERIENCED A BLOWOUT ON THE REAR DRIVER SIDE TIRE. THE DEALER STATED THAT THERE WERE STRESS CRACKS IN THE TIRE AND THAT THE TIRES WERE DEFECTIVE. THE TIRES WERE REPLACED. THE DOT NUMBER AND VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 3,000. THE VEHICLE WAS A TRAILER; THEREFORE, THERE WAS NO ENGINE SIZE, NUMBER OF CYLINDER OR CURRENT MILEAGE INFORMATION.

NHTSA ID

10199042

Incident

Jul 4, 2007

Mileage

3,000 mi

WE BOUGHT A 2006 SUNNYBROOK SUNSET CREEK FROM HUFNAGEL MAJORS IN ZELINOPLE, PA THE CAMPER SITS PERMANENT IN A CAMPGROUND IN TITUSVILLE, PA. THEY OFFERED ONE FREE SERVICE CALL UP TO THE CAMPGROUND. AFTER MANY CALLS IT WAS FINALLY AGREED UPON BY BOTH PARTIES THAT HM WOULD COME AND GET THE CAMPER AT THE END OF THE CAMP SEASON AND FIX THE PROBLEMS OVER THE WINTER. CAMPER WAS BROUGHT BACK UP TO TITUSVILLE, PA IN APRIL. 3 OF THE MAJOR PROBLEMS WERE NOT FIXED. WE NOTIFIED HM THE VERY DAY WE ARRIVED AT CAMP. THEY WILL NOT REPAIR THE CAMPER UNLESS WE COME UP WITH $75 SERVICE CALL, WE HAVE NO PROBLEM PAYING A SERVICE CALL IF THE PROBLEMS WERE NEW ONES. WHAT IF THE PROBLEM STILL WASN'T FIXED?? HOW MANY TIMES DO I HAVE TO PAY THE MONEY TILL THEY FIX IT RIGHT?? THE PRESIDENT BUCK MAJORS CLAIMS THAT A SOME TIME IN JULY HIS SERVICE GUY JOHN CAME UP TO THE CAMP TO LOOK AT THE CAMPER AND SAW NOTHING WRONG. MY QUESTION IS WHY DID THEY NOT CALL US OR BILL US FOR THE CALL OR EVEN TELL THE CAMPGROUND OWNERS HE WAS THERE. WE JUST WANT OUR CAMPER FIXED. PLEASE HELP.JB

NHTSA ID

10198899

Incident

Mar 31, 2006