RoadVitals

2000 Suzuki Dr-Z400S

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1
Latest May 7, 2013
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
0
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains 1 NHTSA owner-reported complaint for the 2000 Suzuki Dr-Z400S, most frequently naming the engine category.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Engine1100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

No recalls in our database for this model year

That does not guarantee a specific vehicle is unaffected — recalls are issued against VINs, and new campaigns are announced regularly. Check a VIN on NHTSA.gov.

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Engine
Filed May 7, 2013

THE HEAD GASKET ON MY DR-Z400 BLEW AT 45 MPH WITH ONLY 4100 MILES, I USUALLY ONLY DRIVE THE MOTORCYCLE DURING THE SUMMER, AND I ALWAYS PUT NEW OIL AND NEW RADIATOR FLUID, AND DO ALL MAINTENANCE BEFORE I TAKE THE MOTORCYCLE OUT FOR THE YEAR, I WAS TRAVELING ABOUT 45 ON THE ROAD AND THE HEAD GASKET BLEW OUT, WHEN I GOT IT HOME AND TOOK THE HEAD OFF TO REPLACE THE HEAD GASKET, IT HAD PITTED ON THE UPPER AND LOWER SURFACES OF THE HEAD WHERE THE HEAD GASKET FITS FROM HOT GASES. HOWEVER, AFTER TAKING ALL THE ITEMS TO GET DOWN TO UNTORQUE THE HEAD BOLTS, THE HEAD BOLT LOCATED NEAREST TO THE EXHAUST MANIFOLD WAS NOT TORQUED DOWN AT ALL, AND WAS LOOSE AND WAS NEVER TORQUED DOWN AT THE FACTORY. I HAVE WORKED ON COUNTLESS MOTORCYCLES AND AUTOS OVER THE YEARS AND HAVE NEVER SEEN A HEAD BOLT LOOSEN ITSELF UP TO THE POINT WHERE THERE WAS NO TORQUE ON IT WHATSOEVER. THIS WAS CAUSED BY A LACK OF TIGHTENING THE HEADBOLT UP AT THE FACTORY. I HAD TO TAKE THIS MOTORCYCLE INTO THE SHOP TO HAVE THE HEAD GROUND DOWN FROM THE PITTING, BUT THIS DEFECT SHOULD NOT HAVE EVEN HAPPENED, IF THE HEADBOLT WAS TORQUED AT THE FACTORY CORRECTLY. THIS IS A FACTORY DEFECT. *TR

NHTSA ID
10510941
Incident
Nov 21, 2012
Mileage
4,100 mi

Compare model years

Complaint and recall counts across every year of this model

Suzuki Dr-Z400S by model year
YearComplaintsRecallsInvestigationsIssue Index
2026010—
2025010—
2024000—
2023000—
2018010—
2007100—
2006100—
2005000—
2004000—
2003000—
2002100—
2000Viewing100—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.