2003 Suzuki Grand Vitara Electrical Problems

SOMETIMES IT WANT START AT ALL

NHTSA ID

11151386

Incident

Nov 3, 2018

Mileage

186,789 mi

TL*THE CONTACT OWNS A 2003 SUZUKI GRAND VITARA. THE CONTACT EXPERIENCED DIFFICULTY STARTING THE VEHICLE. HE DISCOVERED THAT THE BATTERY CABLE WAS GROUNDING OUT AGAINST THE BODY OF THE VEHICLE, WHICH CAUSED THE FAILURE. THE CONTACT STATED THAT THE VEHICLE IS UNSAFE DUE TO THE CURRENT RECALLS ON THE VEHICLE, ALTHOUGH HE HAS NOT EXPERIENCED ANY OF THE FAILURES NOTED IN THE RECALLS. THE FAILURE MILEAGE WAS 70,000.

NHTSA ID

10235550

Incident

Jul 23, 2008

Mileage

70,000 mi

DT*: THE CONTACT STATED WHILE DRIVING UNDER ANY CONDITIONS OR SPEED, THE BRAKE LIGHTS FAIL DUE TO A BLOWN FUSE. AFTERWARDS WHEN THE VEHICLE IS STOPPED, IT US UNABLE TO BE PLACED INTO THE PARK POSITION UNTIL THE FUSE HAS BEEN REPLACED. THE VEHICLE WAS TAKEN TO DEALER FOR INSPECTION. IT WAS DETERMINED THE ELECTRICAL SYSTEM WAS THE PROBLEM HOWEVER IT IS UNKNOWN WHAT REPAIRS WILL CORRECT THE PROBLEM.

NHTSA ID

10157877

Incident

May 18, 2006

Mileage

48,400 mi

THE CONSUMER RECEIVED THREE RECALL NOTICE FOR HER 2003 GRAND VITARA XL-7. EVERYTIME THE CONSUMER CALLED TO MAKE AN APPOINTMENT, SHE WAS TOLD BY THE DEALER, THEY WERE WAITING ON THE PARTS. *TC *JB

NHTSA ID

10101062

Incident

Nov 1, 2004

8/14/03 - 2003 SUZUKI GRAND VITARA, [XXX], PURCHASED AT SUZUKI OF DES MOINES, PO BOX 13377, DES MOINES IA 50310, 515-270-5800. 1/13/04 - RECEIVED RECALL LETTER REGARDING ACCELERATOR CABLE CASING CAP. 1/17/04 - HAD CAR REPAIRED. 9/9/04 - HEADLIGHTS ON AT END OF DAY WHEN LEAVING WORK AND BATTERY DEAD. JUMP-STARTED CAR AND TOOK TO DEALER; NOTICE SMELL OF SOMETHING BURNING. 9/21/04 - CAR FINALLY FIXED. INVOICE STATES: DRL LIGHTS STAY ON PULLED INSIDE AND FOUND LIGHT DO NOT TURN OFF BUT MARKER LIGHTS NOT ON ALSO NOTICED BCM FLASHING CLOCK HOOKED UP TECH 2 AND FOUND CODE P1121 LOOKED UP CODE IN BOOK AND RUN TEST HAD TO REMOVE BCM FROM DASH TO INSPECT ECT WIRING RUN TEST AND BCM APPEARS TO BE OK BUT FOUND WIRE NOT GIVING PROPER READING DISCONNECT RELAY AND LIGHT STILL ON DISCONNECT HIGH BEAM RELAY AND LIGHTS GO OFF CHECKED AND FOUND HIGH/LOW SWITCH BURNT ORDERED PARTS REMOVED SWITCH TO REPLACE AND FOUND WIRE CONNECTOR IS BURNT EXTREMELY BAD HAD TO ORDER WIRE LOOM TO MAKE REPAIR USED CONNECTOR FROM NEW LOOM TO REPAIR SEPARATED MOST PINS HAD TO SOLDER IN 4 WIRES AND SECURE RE ASSEMBLED AND TEST WORKING FINE NOW." 10/4/04 - RECEIVED RECALL LETTER: "MOISTURE CAN FREEZE IN THE FUEL PRESSURE REGULATOR. 10/8/04 - HAD CAR FIXED. INVOICE STATES: SCHEDULED APPOINTMENT TO FIX TIMING COVER WHICH IS LEAKING. 10/9/04 - NHTSA OFFICE WEB SITE HAS RECALL I HAVENT BEEN NOTIFIED ABOUT AND NEED TO MAKE SURE IT DOESN'T INVOLVE MY VEHICLE: WINDSHIELD. *NM UPDATED 07/27/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

10095586

Incident

Sep 9, 2004

THE CONSUMER RECEIVED A RECALL LETTER LAST WEEK CONCERNING THE IGNITION WIRING HARNESS. THE CONSUMER CONTACTED THE DEALER AND THEY STATED THEY DIDN'T HAVE THE PART AND IT WAS THE CONSUMER'S CHOICE TO DRIVE THE VEHICLE AS IT WAS OR PARK IT. *AK THE CONSUMER HAD TO TAKE THE VEHICLE TO ANOTHER DEALER THAT WAS 40 MILES AWAY TO HAVE THE RECALL PERFORMED. *JB

NHTSA ID

10051917

Incident

Dec 22, 2003

WHEN WARMING OUT, CAR SOMETIMES SURGES AND CUTS OUT CAUSING CAR TO NOT BE STEERED OR TO STOP. IT ALSO SOMETIMES WILL NOT START. *LA

NHTSA ID

10047699

Incident

Aug 27, 2003

Mileage

3,322 mi

WHILE DRIVING, THE DRIVER WAS ABLE TO AIR COMING INSIDE OF THE VEHICLE WHEN THE ALL WINDOWS WERE CLOSED. ALSO, THE HEADLIGHTS WILL CAME ON AND WENT OFF BY THEMSELVES. THIS IS A HAZARD TO THE DRIVER'S VISIBILITY AT NIGHT. THIS WAS A CONTINUOUS PROBLEM. *JB

NHTSA ID

10044680

Incident

Oct 24, 2003

Mileage

6,000 mi