2006 Suzuki Grand Vitara Airbags Problems

The contact owns a 2006 Suzuki Grand Vitara. The contact stated that the door ajar warning light was constantly illuminated while the doors were securely closed. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the front passenger’s side occupant classification system sensor was inoperable. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 56,000.

NHTSA ID

11751603

Incident

Jul 13, 2026

Mileage

56,000 mi

I WAS INVOLVED IN A FRONT END COLLISION WHERE I T-BONED ANOTHER VEHICLE AND MY 2006 SUZUKI GRAND VITARA BECAME IMMOBILIZED BECAUSE THE IMPACT WAS SO HARD THAT THE DRIVELINE BROKE. BUT THE DRIVER AIRBAG DID NOT DEPLOY AT ALL!

NHTSA ID

11376264

Incident

Nov 21, 2020

Mileage

146,500 mi

MY 2006 SUZUKI GRAND VITARA HAS BLOWN AT LEAST 4 HEAD LIGHTS SINCE I BOUGHT THE VEHICLE. SUZUKI SAYS THAT THERE IS A PROBLEM WITH THE TRANSISTOR TO THE LIGHTS,IN THAT IT GIVES TOO MUCH POWER TO THE LIGHTS, THUS CAUSING IT TO BLOW PREMATURELY. THEY HAVE NOT ISSUED A RECALL, SUZUKI NEEDS TO DO SOMETHING ASAP!!

NHTSA ID

11084290

Incident

Apr 1, 2018

AIR BAG WONT GO OUT ON DRIVERS SIDE WHEN SEAT OCCUPIED PASSENGER SEAT BELT WONT GOOUT WHEN ENGAGE BEFORE IN MOTION WAS OFFAND ON NOW STAYS ON

NHTSA ID

11035225

Incident

Jul 4, 2017

Mileage

141,484 mi

A RECALL NOTICE HAS BEEN ISSUED ON THE OCS SENSOR MAT INSTALLED IN THE FRONT PASSENGER SEAT, WHICH MAY FAIL DUE TO REPEATED FLEXING OF THE MAT FROM USE OF THE SEAT. UNFORTUNATELY, THERE IS NO LOCAL SERVICE CENTER TO MY AREA TO FIX THE ISSUE. THE NEAREST CONTRACTED SERVICE CENTER IS 60 MILES AWAY AND IN LOS ANGELES TRAFFIC, FREEWAY TIME ALONE IS A 3+ HOUR ROUND TRIP - NOT INCLUDING WAIT TIME FOR REPAIR. DO I NEED TO WAIT UNTIL THE AIRBAG EXPLODES AND DECAPITATES A FRONT SEAT PASSENGER, PRIOR TO THE PART BEING TRANSFERRED TO A LOCAL SERVICE CENTER?

NHTSA ID

11010093

Incident

Oct 1, 2013

TL* THE CONTACT OWNS A 2006 SUZUKI GRAND VITARA. THE CONTACT STATED THAT AN UNKNOWN RECALL REPAIR FOR THE AIR BAGS WAS PERFORMED TWO YEARS AGO. THE REMEDY FAILED TO PROVIDE A SOLUTION AND THE AIR BAG WARNING INDICATOR CONTINUED TO ILLUMINATE. THE DEALER (BIG RED SPORTS/IMPORTS, 418 N INTERSTATE DR, NORMAN, OK 73072, (405) 364-4400) WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS WAITING TO DETERMINE IF THE MANUFACTURER COULD PROVIDE A SOLUTION. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.

NHTSA ID

10993920

Incident

Mar 2, 2015

THE VEHICLE WAS SHIPPED TO A SUZUKI DEALER IN PUERTO RICO AND THEN SHIPPED BACK TO THE USA. ONCE SHIPPED TO PUERTO RICO, SUZUKI PROVIDES A SPECIFIC VIN AS VEHICLES EXPORTED OUT OF THE USA. THE VEHICLE WAS SHIPPED BACK TO USA IN 2009 AND EVER SINCE I HAVE RECEIVED THREE SAFETY RECALL NOTIFICATIONS TO HAVE DONE BY LOCAL SUZUKI DEALER. WE CONTACTED THE LOCAL SUZUKI DEALERS SEVERAL TIMES AND THE VIN DOES NOT APPEAR IN THEIR SYSTEM AT ALL. I BEEN TOLD THEY WILL NOT SERVICE MY VEHICLE BEING THAT IT WAS SHIP FROM PUERTO RICO AND THE ONLY PLACE THEY WOULD FIX THE RECALL WOULD BE THERE. I HAVE CONTACTED CORPORATE SUZUKI MULTIPLE TIMES AND BEEN TOLD THEY CAN'T DO MUCH TO TRY TO NEGOTIATE WITH THE DEALER AGAIN WHICH HAS REFUSED TO DO THE SERVICE. I HAVE BEEN MANY HOURS EXPLAINING MY SITUATION TO DIFFERENT INDIVIDUALS FROM DEALER AND SUZUKI AND NEVER COME TO A SOLUTION AFTER SEVERAL MONTHS. I'M TOLD THAT VEHICLES SHIPPED TO PUERTO RICO (US TERRITORY) AND BACK TO US ARE NOT COVERED UNDER THESE SAFETY RECALLS DESPITE I AM RECEIVING THE NOTIFICATION TO MY OHIO ADDRESS. ITS BEEN SEVERAL MONTHS WE BEEN TRYING TO SOLVE THIS ISSUE AND ALWAYS GET THE RUN AROUND. ONE OF THE RECALL IS RELATED TO AIR BAGS AND DIFFERENTIAL TRAIN LOCKING DUE TO FAULTY SEAL. THE VEHICLE WAS BEING DRIVEN BY MY DAUGHTER FOR SCHOOL AND WE'VE NOW HAVE RESTRICTED HER FROM DRIVING THE VEHICLE CONCERNED FOR THESE ISSUES. WE WOULD APPRECIATE ANY SUPPORT OR ASSISTANCE YOU MAY PROVIDE TO SOLVING THIS ISSUE.

NHTSA ID

10788180

Incident

Sep 16, 2015

RECALL

NHTSA ID

10783806

Incident

Aug 5, 2015

I HAVE TRIED NUMEROUS TIMES THROUGH SAFERCAR.GOV TO CHECK IF THE AIRBAGS I HAVE IN MY CAR ARE ON THE RECALL. I GET NO RESPONSE. I WOULD APPRECIATE IF YOU CAN CHECK TO SEE IF MY CAR'S AIRBAGS ARE OK. A RESPONSE WOULD BE GREATLY APPRECIATED.

NHTSA ID

10734362

Incident

Jul 15, 2015

Mileage

72,500 mi

TL* THE CONTACT OWNS A 2006 SUZUKI GRAND VITARA. AFTER THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 13V405000 (AIR BAGS), THE AIR BAG WARNING INDICATOR WAS CONSISTENTLY ILLUMINATED. THE FAILURE RECURRED EACH TIME THE VEHICLE WAS STARTED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE AIR BAG SYSTEM WAS FAULTY AND COULD DEPLOY AT ANY TIME. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

NHTSA ID

10733012

Incident

Jul 9, 2014

Mileage

90,000 mi

TL* THE CONTACT OWNS A 2006 SUZUKI GRAND VITARA. WHILE AT A STOP LIGHT, ANOTHER VEHICLE CRASHED INTO THE REAR DRIVER SIDE OF THE CONTACT'S VEHICLE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES REPORTED. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 13V405000 (AIR BAGS); HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 89,000. THE CONSUMER STATED THE RECALL WAS FOR THE PASSENGER SIDE, BUT IT WAS THE DRIVERS SIDE LIGHT THAT WAS LIT. UPDATED 08/26/15. *JB

NHTSA ID

10640753

Incident

Sep 29, 2014

Mileage

89,000 mi

TL* THE CONTACT OWNS A 2006 SUZUKI GRAND VITARA. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER RECALL NHTSA CAMPAIGN ID NUMBER: 13V405000 (AIR BAGS). HOWEVER, THE AIR BAG WARNING LIGHT CONTINUED TO ILLUMINATE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 64,000.

NHTSA ID

10630627

Incident

Sep 2, 2014

Mileage

64,000 mi

NOTICE WHILE DRIVING THAT THE PASSENGER SEAT BELT LIGHT CAME ON SHOWING THAT MY PASSENGER WASN'T BUCKLED IN EVEN IF THE SEAT BELT WAS ON AND THAT AIR LIGHT WARNING LIGHT CAME ON THE DASHBOARD. THIS IS THE SECOND TIME THIS HAS HAPPEN. THIS PROBLEM HAPPENS IF THERE IS A PASSENGER SITTING IN THE SEAT OR EVEN IF NO ONE IS SITTING IN THE SEAT. SEAT SENSOR WAS REPLACED ONCE ALREADY BACK IN 2008, COVERED BY CAR WARRANTY BUT NOT SURE IF IT WILL BE COVERED THIS TIME AGAIN AS I HAVE 134,000 MILES ON THE CAR ALREADY. WAITING FOR RESPONSE FROM DEALER ABOUT THE SITUATION. *TR

NHTSA ID

10535513

Incident

Jul 22, 2013

Mileage

134,500 mi

TL* THE CONTACT OWNS A 2006 SUZUKI GRAND VITARA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE DRIVER AND PASSENGER SIDE AIR BAG WARNING LIGHTS ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS ADVISED TO THE CONTACT THAT THE PASSENGER'S SIDE AIR BAG SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 68,000.

NHTSA ID

10526435

Incident

Aug 15, 2010

Mileage

68,000 mi

A HOT DAY OR ANY BAG WEIGHING OVER 5 LBS. WILL TRIGGER THE PASSENGER SEAT SENSOR FOR THE AIR BAG. THE ONLY WAY TO STOP THIS PROBLEM IS TO PERMANENTLY BUCKLE THE PASSENGER SEATBELT. *TR

NHTSA ID

10523512

Incident

Jul 13, 2010

Mileage

47,703 mi

I WAS TRAVELING ON THE HIGHWAY AT ABOUT 55 MILES PER HOUR WHEN THE PASSENGER AIRBAG AND SEATBELT LIGHT CAME ON. THEN THE DASH AIRBAG LIGHT CAME ON AND STAYS ON CONSTANTLY. NOW THE PASSENGER AIRBAG LIGHT COMES ON AND GOES OFF AT ANY TIME WITH OR WITHOUT A PASSENGER. *TR

NHTSA ID

10521779

Incident

Jan 3, 2013

Mileage

88,500 mi

THE PASSENGER SEAT BELT INDICATOR STAYS ON REGARDLESS OF HAVING SOMEONE SIT IN THE SEAT OR NOT. THE AIR BAG WARNING LIGHT IS ALSO ON ALL THE TIME. I HAVE CHECKED THE WIRING AND NOTHING SEEMS TO BE WRONG WITH IT. *TR

NHTSA ID

10511439

Incident

Feb 4, 2013

THE SENSOR BUILT INTO THE PASSENGER SEAT THAT CONTROLS THE AIRBAG IS DEFECTIVE. THE FIX IS A $2000 TOTAL SEAT REPLACEMENT. UNACCEPTABLE. THE CAR THINKS A DOOR OR HATCH IS OPEN AND TURNS THE OVERHEAD LIGHT ON AND OFF ALL THE TIME. ANOTHER SENSOR. YOU HAVE TO BE HOUDINI TO INSTALL A BULB IN THE FRONT LIGHT ASSEMBLY AND THE BULB IS HELD BY A RINKY DINK CLIP THAT DOESN'T HOLD SO THE FRONT LIGHTS ARE SUBJECT TO GOING OUT. THE CLIP WON'T HOLD THE BULB IN PLACE AND EVEN THE DEALER HAS PROBLEMS WHEN YOUR BULB BURNS OUT OR MANY TIMES JUST BECOMES LOOSE. *TR

NHTSA ID

10456043

Incident

Jul 8, 2009

SEAT AIRBAG SENSOR FAILURE, AIRBAG CODE LIGHT IN DASH ALWAYS ON, CHEKED IN DEALER, AND THE NO PASSENGER INDICATOR LIGHT IN CONSOLE ALWAYS ON WITH A PASSENGER SIT ON THE SEAT. *TR

NHTSA ID

10454445

Incident

Apr 29, 2010

TO WHOM THIS CONCERN I HAVE A 06 SUZUKI GRAND VITARA IM THE ORIGINAL OWNER THE PASSENGER AIR BAG LIGHT STAYS ON, THE DEALER AND COMPANY SAYS I HAVE TO SPEND 2000.00 TO FIX IT IF U GO ON LINE THE OTHER PEOPLE ARE HAVING THE SAME ISSUES MY AUTISTIC SON SITS IN THE FRONT AND I BELIEVE THEY DEALER AND COMPANY KNEW ABOUT THIS FOR THE LONGEST TIME NOPT DOING NOTHING TO HELP US EXPECT EVERYONE TO SPEND MONEY WHICH I THINK I SHOULD BE A RECALL, CAN SOMETHING BE DONE TO HELP MY EMAIL IS[XXX] OR[XXX] ADDRESS IS [XXX] TY FOR YOUR TIME AND I HOPE TO GET A RESPONSE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10453403

Incident

Aug 16, 2007

Mileage

30,000 mi

PREMATURE FAILURE OF THE PASSENGER RESTRAINT AIR BAG SYSTEM DUE TO FAILURE OF A PRESSURE SENSOR IN THE PASSENGER SEAT. SUZUKI REFUSES TO REPAIR IT AS THEY CONSIDER IT OUT OF WARRANTY AND THE DEALER WANTS $1,200.00 TO REPLACE THE SEAT. *TR

NHTSA ID

10450746

Incident

Feb 28, 2012

Mileage

70,000 mi

RIGHT FRONT PASSENGER SEAT INTERMITTENT SENSOR FAILURE. SEAT INTERMITTENTLY DOES NOT SENSE AN ADULT IN THE SEAT CREATING A "PASS" CONDITION WHICH DISABLES THE RIGHT PASSENGER SEAT AIR BAG(S). *TR

NHTSA ID

10449077

Incident

Jan 25, 2012

Mileage

69,000 mi

TL* THE CONTACT OWNS A 2006 SUZUKI GRAND VITARA. THE CONTACT STATED BOTH THE FRONT PASSENGER'S SIDE SEAT BELT AND DRIVER'S SIDE AIR BAG WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE WARNING INDICATORS REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE FRONT PASSENGER SEAT CUSHION SENSOR WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 66,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

10440088

Incident

Dec 1, 2011

Mileage

66,000 mi

I ENGAGED MY BRAKES AND PULLED INTO A PARKING SPOT GOING ABOUT 10 MILES PER HOUR. WHEN I WAS ABOUT 6 INCHES AWAY FROM THE SIDEWALK CURB (ABOUT 6 INCHES HIGH) WITH MY BRAKES APPLIED FULLY MY VEHICLE REVVED UP REALLY LOUD AND LUNGED FORWARD VIOLENTLY AND CRASHED THROUGH A BRICK OFFICE BUILDING. I DID NOT STEP ON THE GAS AT ALL. MY AIR BAGS DID NOT DEPLOY EITHER. *TR

NHTSA ID

10435408

Incident

Nov 9, 2011

AT APX. 10000 MILES, THE AIR BAG LIGHT CAME ON WITH THE CAR, AND DID NOT GO OUT. TOOK THE VEHICLE TO THE DEALER; WAS INFORMED THAT THE DRIVER'S SIDE AIR BAG WEIGHT SENSOR HAD FAILED IN THE SEAT, AND WOULD BE REPLACED UNDER WARRANTY. AT APX. 25000 MILES, THE AIR BAG LIGHT AGAIN CAME ON. THE CAR WAS NOW OUT OF WARRANTY. I TOOK THE CAR TO THE DEALER, AND WAS INFORMED THAT THE AIR BAG WEIGHT SENSOR IN THE SEAT HAD FAILED, AND NEEDED TO BE REPLACED. WHEN I INFORMED THE SERVICE MANAGER THAT THIS WAS THE SECOND TIME THAT THIS HAD HAPPENED, THEY OFFERED TO REPLACE THE SENSOR FOR $300 DOLLARS. WHICH I PAID FOR. AT APX. 52000 MILES, THE AIR BAG LIGHT CAME ON AGAIN. (IT WAS INTERMITTENT, AS IT WOULD SOMETIMES NOT BE ON) AFTER A FEW MONTHS, WE WERE INVOLVED IN A MINOR ACCIDENT, (STRUCK BY ANOTHER CAR ON REAR QUARTER) WHEN THE CAR WAS REPAIRED, I WAS ASKED ABOUT THE SEATBELT LIGHT; I WAS INFORMED THAT THE DIAGNOSTIC CODE INDICATED A FAILURE OF THE WEIGHT SENSOR. I INFORMED THE REPAIR SHOP AND INSURANCE THAT THE LIGHT WAS NOT DUE TO THE ACCIDENT. WHILE I WAS AT THE SHOP, THE ERROR LIGHT WENT OUT, BUT SUBSEQUENTLY (WITHIN 5 MILES) CAME BACK ON AGAIN. THE SHOP INFORMED ME THAT THE PROBLEM WAS <<<PROBABLY>>> IN THE WIRING HARNESS OR SENSOR CONNECTOR, RATHER THAN THE ACTUAL SENSOR (AS THE PROBLEM WAS INTERMITTENT.) THE CAR HAS NOT BEEN FIXED, AND THE AIR BAG LIGHT IS STILL ON. THAT IS THREE AIR BAG WEIGHT SENSOR RELATED PROBLEMS WITH THE SAME CAR. THIS IS A SAFETY ISSUE, AND IT SEEMS TO BE A PERVASIVE SAFETY ISSUE WITH THE 2006 GRAND VITARA... [IN ADDITION, THE CAR BLOWS THE LOW-BEAM (AND SOMETIMES HIGH BEAM) HEADLIGHTS QUITE OFTEN - MORE THAN ANY OTHER CAR I'VE DRIVEN IN NEARLY 40 YEARS OF DRIVING.] *TR

NHTSA ID

10426813

Incident

Feb 14, 2007

Mileage

10,000 mi