2006 Suzuki Grand Vitara Interior & seats Problems

PASSENGER AND DRIVER SEATBELT LIGHT STAYS ON. *TR

NHTSA ID

10525840

Incident

Jul 19, 2013

Mileage

89,000 mi

A HOT DAY OR ANY BAG WEIGHING OVER 5 LBS. WILL TRIGGER THE PASSENGER SEAT SENSOR FOR THE AIR BAG. THE ONLY WAY TO STOP THIS PROBLEM IS TO PERMANENTLY BUCKLE THE PASSENGER SEATBELT. *TR

NHTSA ID

10523512

Incident

Jul 13, 2010

Mileage

47,703 mi

THE SENSOR BUILT INTO THE PASSENGER SEAT THAT CONTROLS THE AIRBAG IS DEFECTIVE. THE FIX IS A $2000 TOTAL SEAT REPLACEMENT. UNACCEPTABLE. THE CAR THINKS A DOOR OR HATCH IS OPEN AND TURNS THE OVERHEAD LIGHT ON AND OFF ALL THE TIME. ANOTHER SENSOR. YOU HAVE TO BE HOUDINI TO INSTALL A BULB IN THE FRONT LIGHT ASSEMBLY AND THE BULB IS HELD BY A RINKY DINK CLIP THAT DOESN'T HOLD SO THE FRONT LIGHTS ARE SUBJECT TO GOING OUT. THE CLIP WON'T HOLD THE BULB IN PLACE AND EVEN THE DEALER HAS PROBLEMS WHEN YOUR BULB BURNS OUT OR MANY TIMES JUST BECOMES LOOSE. *TR

NHTSA ID

10456043

Incident

Jul 8, 2009

SEAT AIRBAG SENSOR FAILURE, AIRBAG CODE LIGHT IN DASH ALWAYS ON, CHEKED IN DEALER, AND THE NO PASSENGER INDICATOR LIGHT IN CONSOLE ALWAYS ON WITH A PASSENGER SIT ON THE SEAT. *TR

NHTSA ID

10454445

Incident

Apr 29, 2010

PREMATURE FAILURE OF THE PASSENGER RESTRAINT AIR BAG SYSTEM DUE TO FAILURE OF A PRESSURE SENSOR IN THE PASSENGER SEAT. SUZUKI REFUSES TO REPAIR IT AS THEY CONSIDER IT OUT OF WARRANTY AND THE DEALER WANTS $1,200.00 TO REPLACE THE SEAT. *TR

NHTSA ID

10450746

Incident

Feb 28, 2012

Mileage

70,000 mi

AT APX. 10000 MILES, THE AIR BAG LIGHT CAME ON WITH THE CAR, AND DID NOT GO OUT. TOOK THE VEHICLE TO THE DEALER; WAS INFORMED THAT THE DRIVER'S SIDE AIR BAG WEIGHT SENSOR HAD FAILED IN THE SEAT, AND WOULD BE REPLACED UNDER WARRANTY. AT APX. 25000 MILES, THE AIR BAG LIGHT AGAIN CAME ON. THE CAR WAS NOW OUT OF WARRANTY. I TOOK THE CAR TO THE DEALER, AND WAS INFORMED THAT THE AIR BAG WEIGHT SENSOR IN THE SEAT HAD FAILED, AND NEEDED TO BE REPLACED. WHEN I INFORMED THE SERVICE MANAGER THAT THIS WAS THE SECOND TIME THAT THIS HAD HAPPENED, THEY OFFERED TO REPLACE THE SENSOR FOR $300 DOLLARS. WHICH I PAID FOR. AT APX. 52000 MILES, THE AIR BAG LIGHT CAME ON AGAIN. (IT WAS INTERMITTENT, AS IT WOULD SOMETIMES NOT BE ON) AFTER A FEW MONTHS, WE WERE INVOLVED IN A MINOR ACCIDENT, (STRUCK BY ANOTHER CAR ON REAR QUARTER) WHEN THE CAR WAS REPAIRED, I WAS ASKED ABOUT THE SEATBELT LIGHT; I WAS INFORMED THAT THE DIAGNOSTIC CODE INDICATED A FAILURE OF THE WEIGHT SENSOR. I INFORMED THE REPAIR SHOP AND INSURANCE THAT THE LIGHT WAS NOT DUE TO THE ACCIDENT. WHILE I WAS AT THE SHOP, THE ERROR LIGHT WENT OUT, BUT SUBSEQUENTLY (WITHIN 5 MILES) CAME BACK ON AGAIN. THE SHOP INFORMED ME THAT THE PROBLEM WAS <<<PROBABLY>>> IN THE WIRING HARNESS OR SENSOR CONNECTOR, RATHER THAN THE ACTUAL SENSOR (AS THE PROBLEM WAS INTERMITTENT.) THE CAR HAS NOT BEEN FIXED, AND THE AIR BAG LIGHT IS STILL ON. THAT IS THREE AIR BAG WEIGHT SENSOR RELATED PROBLEMS WITH THE SAME CAR. THIS IS A SAFETY ISSUE, AND IT SEEMS TO BE A PERVASIVE SAFETY ISSUE WITH THE 2006 GRAND VITARA... [IN ADDITION, THE CAR BLOWS THE LOW-BEAM (AND SOMETIMES HIGH BEAM) HEADLIGHTS QUITE OFTEN - MORE THAN ANY OTHER CAR I'VE DRIVEN IN NEARLY 40 YEARS OF DRIVING.] *TR

NHTSA ID

10426813

Incident

Feb 14, 2007

Mileage

10,000 mi

WE RECENTLY PURCHASED A 2006 SUZUKI GRAND VITARA FROM AN INDIVIDUAL. ON THE WAY HOME THE" PASSENGER SEAT BELT OFF" AND AIR BAG LIGHTS REMAINED ON. WHEN WE TOOK IT TO A SUZUKI DEALER FOR DIAGNOSIS THE RESULTS WAS THE PASSENGER SEAT SENSOR WAS NOT WORKING THEREFORE THE PASSENGER AIR BAGS WERE DISABLED. THE SERVICE MANAGER QUOTED $1800. TO $2000. FOR REPLACEMENT. WE ARE VERY DISAPPOINTED TO FIND THIS TO BE A COMMON PROBLEM WITH SUZUKI. *TR

NHTSA ID

10426703

Incident

Aug 31, 2011

Mileage

66,500 mi

I GOT A 2006 GRAND VITARA BRAND NEW AT FIRST IT WAS LITTLE THINGS LIKE MY DOME LIGHT SWITCH BREAKING AND THE WINDOW CONTROLLER BECOMING LOSS AND AFTER GETTING THEM FIXED THEY BREAK AGAIN A WEEK LATTER THEN A SENSOR LIGHT COMES ON ABOUT THE AIR BAG AND WONT GO OFF THE WORST THING IS MY AIR CONDITION CONTROL ONLY LETS AC RUN CANT TURN IT OFF AND DON'T TRY TO PUT THE HEAT FROM YOU FEET TO FACE THE AIR MIGHT JUST STOP WORKING THEN I STARTED TO HAVE BEARING ISSUES THAT WAS A RECALL ITEM BUT MY DEALERSHIP CLOSED SO I HAD TO DRIVE 47 MILES DROP IT OFF AND HAD TO COME BACK THE NEXT DAY TO GET IT THAT WAS THE FIRST RECALL THEN MY CAR STARTED TO MAKE A WEIRD NOISE I GOT THE NOTICE OF ANOTHER RECALL AND MY PULLEY BROKE AND I CANT DRIVE MY CAR 47 MILES TO GET IT FIXED I ASKED IF I JUST FIX IT MY SELF WILL THEY REFUND ME MY MONEY BACK FOR THE PART THEY SAID NO AND THEY WOULDN'T EVEN SHIP THE ITEM TO ME BECAUSE IM NOT A SHOP BUT THEY WERE WILLING TO PAY 50 DOLLAR TOWARDS MY THREE HUNDRED DOLLAR TOW TO GET MY CAR THERE. *TR

NHTSA ID

10382671

Incident

Feb 1, 2011

Mileage

110,000 mi

TL*THE CONTACT OWNS A 2006 SUZUKI GRAND VITARA. THE CONTACT STATED THAT WHENEVER A PERSON WAS SITTING IN THE PASSENGER SEAT, THE AIR BAG LIGHT ILLUMINATED. THE PASSENGER SEAT MODULE WAS DEFECTIVE. THE CONTACT HAD TO TURN THE VEHICLE OFF AND RESTART IT TO RESET IT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THEY WOULD COVER 50% OF THE REPAIR COSTS TO REPLACE THE ENTIRE SEAT CUSHION. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 35,700 AND THE CURRENT MILEAGE WAS 36,600. UPDATED 02/1/11*LJ UPDATED 04/14/11

NHTSA ID

10369777

Incident

Sep 17, 2010

Mileage

35,700 mi

DASH BOARD LIGHTS AND HEADLIGHTS DIM AND CHANGE MODE AT WILL. HVAC BLOWER FAN WHISTLES UNDERCARRIAGE DUST COVER SHAKES LOOSE (NEEDS BOLTS!) WHAT ELSE IS WRONG -- NOT SURE IF I WANT TO KNOW! HAVE CALLED DEALERSHIP FOR SERVICE, BUT HAVEN'T HEARD BACK. *JB

NHTSA ID

10169575

Incident

Sep 9, 2006

Mileage

12,200 mi