1996 Suzuki Sidekick Owner Complaints

CLUTCH PEDAL SEPARATES FROM PIVOT SHAFT. WELD BRAKES, PEDAL DETACHES, VEHICLE DISABLED. THIRD OCCURRENCE. OEM PEDAL REPLACEMENT REVEALS NO-WARRANTY, COMMON OCCURRENCE FAILURE MODE. PEDAL RE-ATTACHED TO SHAFT BY PROFESSIONAL WELDERS ON TWO PREVIOUS OCCURRENCES. HAVE REPLACED CLUTCH CABLE, CLUTCH PLATE & THROWOUT BEARING WITHOUT RESOLUTION. HYDRAULIC REPLACEMENT INVESTIGATION IN PROGRESS. *TR

NHTSA ID

10212453

Incident

Dec 20, 2007

Mileage

76,421 mi

TL*- THE CONTACT STATED THAT WHILE DRIVING THE 1996 SUZUKI SIDEKICK SPORT ON AN ICY AFTERNOON HE PULLED INTO THE DRIVEWAY AT 5 MPH AND HIT THE UTILITY POLE, AND BOTH AIRBAGS DEPLOYED. THE PASSENGER SIDE AIRBAG POPPED AND BURST INTO FLAMES IN THE CENTER OF THE BAG. A NEIGHBOR SAW WHAT HAPPENED ,CAME OVER, OPENED THE PASSENGER DOOR, AND BEAT THE FLAMES UNTIL THE FIRE WAS OUT. THE DRIVER SIDE AIRBAG DEPLOYED AND FORCED THE CONTACT LEFT HAND TO GO THROUGH THE DRIVER'S SIDE WINDOW WHICH SHATTER,ED,AND CAUSED CONTUSIONS TO HIS KNUCKLES. THE CONTACT CONTACTED THE POLICE AND THERE WAS REPORT. THE OFFICER COULDN'T UNDERSTAND HOW THE AIRBAGS COULD HAVE DEPLOYED BECAUSE THE UTILITY POLE HAD NO DAMAGE, BUT THE VEHICLE DID RECEIVE A DING. THE CONTACT HAS PICTURES AVAILABLE OF THE VEHICLE AND THE UTILITY POLE. THE CURRENT MILEAGE WAS 76000.*AK UPDATED 03/19/07.*JB

NHTSA ID

10182340

Incident

Feb 8, 2007

CONSUMER STATES THAT HER VEHICLE CAUGHT FIRE. SHE STATES THAT SHE GOT INTO HER VEHICLE AND INSERTED THE KEY. SHE SAID THAT WHEN SHE TURNED THE KEY, IT SOUNDED AS IF THE BATTERY WAS DEAD. SHE STATES SHE TURNED THE IGNITION OFF, WAITED AND THEN TURNED THE IGNITION ON AGAIN, THEN SHE SMELLED AND SAW SMOKE, THEN THERE WAS FIRE. SHE SAID HER HUSBAND AND THE NEIGHBOR PUT THE FIRE OUT. SHE HAD THE VEHICLE TOWED TO A PRIVATE MECHANIC, WHO STATED THAT THE SHE HAD AN ELECTRICAL FIRE . SHE SAID SHE HAD TO PURCHASE A NEW/USED MOTOR. SHE SAID SHE CALLED THE MANUFACTURER AND THEY DID NOT SEEM CONCERNED. *JB

NHTSA ID

10092513

Incident

Sep 16, 2004

THE VEHICLE EXPERIENCED THE SAME DEFECT AS NHTSA RECALL 96-V-121-002 RELATED TO THE FUEL TANK. THE CONSUMERS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *NLM

NHTSA ID

10019369

Incident

May 7, 2003

CONSUMER STATES, THE TEMPERATURE GAUGE ALWAYS INDICATED HOT, DUE TO THE RADIATOR CAP WHICH IS DEFECTED, HAS BEEN CHANGE THREE TIMES. AND REOCURRING THE PROBLEM.. PLEASE PROVIDE FURTHER INFORMATION. TS

NHTSA ID

8022832

Incident

Oct 10, 2002

THIS CAR HAS BEEN IN THE SHOP ALMOST FROM THE DAY I PURSCHASED IT FROM LARGO HONDA IN KEY LARGO FLORIDA; DEC. OF 1999. ALTHOUGH I PURSCHASED AN EXTENDED SERVICE CONTRACT FOR $8,000, I WAS NEVER ABLE TO GET SATIFACTION FROM THE DEALER, THE SELLER, OR MY WARRENTY CO. ALWAYS AT MY EXPENCE , TOWING, {RENTAL CARS =$1,700 04/05/00 - 50,373 MILES AUTO DOC OF KEY LARGO, 305] 453-0977, REPLACED FAN, CLUTCH, ADJUSTER, RADIATOR, WATER PUMP.... NOW THIS WHERE MY MOST RECEIENT BEGAINS. *SOUTH MOTORS OF MIAMI. I WAS NOTIFIED ABOUT A SECOND W2 RECALL NHTSA ID # 00V008000, 96V121002- I CALLED SUZKI, I CALLED SOUTH MOTORS - TOOK AUTO TO SOUTH MOTORS 6AM, FOR THE DAY, RECIEVED ESTIMATED $29 OIL CHANGE THAT ENDED UP BEING $139, BUT THEY DID NOT DO THE POWER LOCK PROBLEM I HAD ASKED FOR , AND TOLD ME THAT ALL RECALL WORK HAD BEEN COMPLEATED - BLEW ME OFF. STILL NO POWER LOCKS, FULE FILTER SEEMED MORE STUFFED UP THAN BEFORE, = POINTS, PLUGS, COILS, "SERVICE ENGIN LIGHTS" ETC. ON JULY 30, 2002 A BOLT APPARENTLY BROKE OFF THAT HAD BEEN HOLDING THE AIRCONDIONER TO REST OF THE CAR, THE FAN BELT WAS REPLACED ANDBOLT WELDED

NHTSA ID

766501

Incident

Aug 23, 2002

RIGHT FRONT DROPPED WHILE PULLING INTO DRIVEWAY. VEHICLE TAKEN TO REPAIR SHOP, AND INFORMED CONSUMER THAT FRONT STRUTS NEEDED TO BE REPLACED. DEALER NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

NHTSA ID

8016353

Incident

Mar 12, 2002

CONSUMER RECEIVED RECALL NOTIFICATION LAST YEAR IN 2001,TO DATETHE DEALERSHIP HAS NOT BEEN ABLE TO SUPPLY THE REPLACEMENT COMPONENT FOR THE VEHICLE. NLV CONSUMER HAS RECEIVED SECOND NOTICE FOR SAFETY RECALL. *MR

NHTSA ID

8006570

RECALL 00 V 008000 /FRONT STRUTS: C AFTER CONTACTING THE DEALER: (KNOXVILLE, FORD LINCOLN, SUZUKI; KNOXVILLE, TN; PHONE# 865/688-4600, HE STATED THAT THEY WOULD INSPECT THE STRUTS, AND ONLY MAKE REPAIRS IF IT NEEDED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

NHTSA ID

8005500

Incident

Mar 12, 2002

CLUTCH WELL ARM BROKE WHILE DRIVING. WAS UNABLE TO DISENGAGE THE CLUTCH. DEALER / MANUFACTURER WERE NOT NOTIFIED AT THIS TIME. PROVIDE ANY FURTHER INFORMATION ON THIS MATTER.*AK

NHTSA ID

895498

Incident

Jun 16, 2001

IT SEEMS THESE TROUBLES ARE UNUSUAL FOR ANY CAR OWNER AND VERY COSTLY!! THE SPEEDOMETER WAS RELACED BY MY HUSBAND WITH A PART BOUGHT ONLINE FOR $50 IN ONE DAY, WHERE THE DEALER WOULD HAVE HAD IT FOR A WEEK AND CHARGED US $350. HOWEVER, THE CLUTCH IS A MUCH BIGGER PROBLEM. THE DEALER QUOTED THE PART AT $51, WITH LABOR AT $700. I CANNOT AFFORD TO FIX THIS PROBLEM THAT SHOULD HAVE NEVER HAPPENED IN THE FIRST PLACE. IT IS A SAFETY FACTOR, SINCE I COULD NOT ENGAGE THE CLUTCH WHILE THE VEHICLE WAS IN MOTION, AND AM TERRIFIED TO ATTEMPT TO DRIVE IT UNTIL IT HAS BEEN PROPERLY FIXED. CAN THE MANUFACTURER BE HELD RESPONSIBLE?*AK

NHTSA ID

746328

Incident

May 1, 2001

CROSS MEMBER OF VEHICLE IS HELD IN PLACE BY ONE BOLT, BOLT FELL OFF WHILE DRIVING, VEHICLE WAS SHAKING BADLY. HARD TO CONTROL, ALMOST LOST DRIVESHAFT.*AK

NHTSA ID

884863

Incident

Mar 30, 2001

WHILE DRIVING THE VEHICLE PULLS TO THE RIGHT AND EXPERIENCES CONTINUED VIBRATION, VEHICLE TAKEN TO DEALERSHIP, FRAME ADJUSTED, NEW TIRES PUT ON AND BALANCED, FRONT END ALIGNED, PROBLEM STILL EXISTS, POSSIBLY RELATED TO THE TIRES OR THE FRONT END SUSPENSION. CJ

NHTSA ID

559098

Incident

Jan 1, 1998

SINGLE CAR ROLL-OVER. WIND GUST WAS THOUGHT TO BLOW CAR TO THE RIGHT SHOULDER. DRIVER OVER CORRECTED TRAVELING TO THE LEFT SHOULDER AND THEN ROLLED 6-8 TIMES. DID THIS CARS ROLLOVER TENDENCY CONTRIBUTE TO THE ROLLOVER AND RELATED PROPERTY DAMAGE AND PERSONAL INJURY? *AK

NHTSA ID

725781

RECEIVED RECALL NOTICE 00V008000 IN MAIL & CONTACTED DEALERSHIP FOR AN APPOINTMENT. WAS INFORMED BY SERVICE MANAGER THAT NO PARTS WERE AVAILABLE FOR THE FRONT STRUTS. *AK

NHTSA ID

861887

Incident

Apr 14, 2000

MOUNTING BOLTS BROKE PRIOR TO RECALL NOTICE (00V008) DUE TO INSUFFICIENT STRENGTH. NLM

NHTSA ID

552156

CONSUMER RECEIVED A RECALL CONCERNING LOWER CONTROL ARM FAILURE. AND HAS BEEN IN FOR REPAIRS ON 3 DIFFERENT OCCASIONS. *AK

NHTSA ID

859888

Incident

Mar 20, 1999

CONSUMER RECEIVED RECALL (00V008) LETTER FOR THE FRONT STRUT MOUNTING. DEALER HAS BEEN CONTACTED. *AK THE CONSUMER WAS TOLD BY THE DEALER THAT THEY HAD NO PARTS AVAILABLE TO REPAIR THE RECALLED COMPONENT, IT TOOK ONE MONTH FOR THE DEALER TO RECEIVE THE PART TO MAKE THE NECESSARY REPAIRS. *YH

NHTSA ID

859659

RECALL 00V008000; MANUFACTURER DIDN'T HAVE PARTS TO SEND TO DEALER. THEY WERE ON BACK ORDER. *AK

NHTSA ID

859609

Incident

Apr 3, 2000

THERE IS ONLY 1 DEALER IN ENTIRE STATE, AND DOES NOT MAKE APPOINTMENTS FOR RECALL REPAIRS. ALSO, NO PARTS ARE AVAILABLE. *AK

NHTSA ID

859605

NHTSA RECALL 00V008000 AND MANUFACTURER'S RECALL W2/FRONT STRUTS. NO PARTS WERE AVAILABLE. *AK

NHTSA ID

859524

RECALL200V008000/MCPHERSON STRUTS. PARTS THAT ARE NEEDED TO PERFORM THE RECALL ARE NOT AVAILBALE.*AK

NHTSA ID

859285

Incident

Mar 7, 2000

CONSUMER CALLED DEALER TO SCHEDULE APPOINTMENT FOR RECALL 00V008000/ FRONT STRUTS REPAIRS. PART WAS ON BACK ORDER. CONSUMER IS UPSET BECAUSE DEALER DOESN'T KNOW WHEN PART WILL BE IN. MANUFACTURER ALSO CONTACTED BUT OF NO HELP. PROBLEM STILL REMAINS UNREPAIRED. *AK *ML

NHTSA ID

858945

Incident

Mar 14, 2000

BECAME VERY HARD TO CHANGE GEERS,COULD NOT SHIFT IN INTERSECTIONS, TOOK TWO HANDS CAUSING SHOLDER PAIN! THIS IS THE THIRD TIME THIS HAS HAPPENED. DEALERSHIP WILL ONLY REPLACE PARTS-CLUTCH ROD,PEDAL ROD&CLUTCH LINKAGE PIECES. THOUGH THEY ADMIT THERE IS AN INHERENT PROBLEM/DEFECT IN CLUTCH POWER TRAIN.*AK

NHTSA ID

718276

Incident

Jan 20, 2000

THE FUSE CONTROLLING THE FUEL INJECTION SYSTEM AND ANOTHER FUSE CONROLLING DOME LIHT BLEW OUT. YH

NHTSA ID

550434

Incident

Dec 3, 1999