Owner-reported complaints naming the body or structure system, filed with NHTSA
Data refreshed
Reports naming the vehicle structure, frame, body panels, doors, hood and trim. Every record below is an owner-reported complaint about the 2022 Tesla Model 3 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 9 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
My wife had a collission on June 25th at 2 30PM CST while she was parking her vehicle in her office parking spot. The car suddenty sped and hit a tree. We suspect it be a misfire in Tesla.
The vehicle has a manufacturing defect in the charge port body seal allowing water intrusion into the vehicle cabin and near high-voltage charging components. This has resulted in dampness and potential mold growth, posing a respiratory health hazard to occupants.
The 2022 Model 3 Tesla does not have readily available emergency rear door release. Tesla's automated response to me was to locate the bolts and screws on the underside of the door armrest, then I need to remove the bolts and screw. Once that is done I can then remove the panel under the armrest so I can then reach inside and pull on the manual release cable. This could not be done during an emergency, you would need to have tools and in an emergency people panic and they would have to do everything by feel if they are trapped in the backseat of the Model 3 Tesla. This is a life safety hazard and needs to be addressed by Tesla to provide a fix that will allow easy access and not require tools to open the door if there is no power to the door release. This needs to investigated and corrective actions taken to make Tesla comply with changes for safety.
The power lift‑gate strut PN 1551489‑00‑B failed, bent inward, and shattered the rear glass on 16 May 2025. A known defect: Tesla superseded the part to PN 1551488‑00‑C in Oct 2023. Local Tesla Service center declined goodwill coverage to resolve the issue.
Dear NHTSA, I am filing a formal complaint regarding Tesla's refusal to properly address a critical safety recall on my vehicle (Recall Number 24V554). This recall involves a significant safety issue that Tesla is legally obligated to remedy free of charge under the National Traffic and Motor Vehicle Safety Act. The required over-the-air software update associated with this recall repeatedly fails to install, getting stuck at 50% completion. I scheduled a service appointment and took the vehicle to Tesla for assistance. However, Tesla informed me that they will not diagnose the issue or investigate why their software update fails to install unless I agree to pay $255.00 for a general diagnosis. Additionally, they require me to pre-approve a total of $2,658.28, including the diagnostic fee, in case the computer needs to be replaced. This approach leaves me unable to proceed with a mandatory safety recall and directly contradicts Tesla’s legal obligation to repair safety-related defects at no cost to the consumer. I urge the NHTSA to investigate Tesla's practices concerning this recall and their apparent refusal to adhere to their obligations under the law. This situation raises concerns about Tesla’s commitment to addressing safety-critical issues in a manner that ensures public safety and compliance with federal regulations. Thank you for your attention to this matter.
The vehicle was sitting in my driveway during a lower than normal temperature (18 defrees f). The car ha d ot moved at all due to snow fall around the area. The car was warmed up with the automatic function and a U shaped crack appeared in the windshield almost fully closing on itself and there was a crack along the bottom of the windshield. There were no prior chips or issues. The window was since fixed but I feel this is a warranty issue. The windshield shouldn't just crack like that in cold weather.
I was pulling into parking lot at REI car suddenly accelerated and jumped pavement and hit a wall.
As I was driving the car today, I had a car ahead of me at a full stop, so in order to slow down the car I lifted my foot off the acceleration pedal. However, instead of slowing down it sped up. My car has regenerative breaking (and it was turn on) which usually applies break when the pressure is lifted from acceleration pedal. However in this instant my car started speeding up. I then applied pressure on breaks, however it didn’t work. Fortunately the car ahead of me moved ahead and an accident was averted. My break and accelerator started working as expected moments later. But this can cause accident anytime. I have booked service request with Tesla. Also note that the car was not on Autopilot.
Tesla model 3 2022 rear side windows shattered all of a sudden with no other accidents. My 6 year old girl was sitting in the car next to it and we are all in a shock . We are trying to find the right way to report to Tesla . We checked online and saw more blog posts with same issue . Please help.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .