2013 Tesla Model S Problems

The vehicle has suffered a catastrophic, intermittent low-voltage network crash caused by a failing Body Control Module (BCM), resulting in multiple dangerous safety-critical failure modes. On a previous occasion, the vehicle woke up with severe network faults and automatically forced itself into Neutral. When the driver stepped out to get the child and shut the door, the system crashed entirely and the exterior electronic door handles failed to present, trapping an infant child inside the running vehicle. Most recently, while driving in a rainstorm, the vehicle suffered a complete failure of the windshield wipers, a total loss of the high-beam headlights, a total loss of the horn, and a total loss of electronic communication to the electronic parking brake system. Most critically, the vehicle experienced an uncommanded propulsion hazard where it hard-locked itself in the 'Drive' gear and absolutely refused to shift into 'Park' or 'Neutral,' forcing the driver to physically maintain heavy hydraulic brake pressure to keep the vehicle from creeping forward. Because the horn failed and the parking brake was disabled, the driver was trapped in the driver's seat holding the brakes and was forced to call 911 for emergency first responders to come and physically block the wheels so the driver and infant could safely exit. Tesla Service has diagnosed the issue as a failed central Body Control Module (Part #1010906-00-D), but the cascading network failure modes present an extreme, life-threatening hazard regarding vehicle control and child entrapment.

While driving my 2013 Tesla Model S at normal road speed, the vehicle suddenly lost all propulsion without any warning. I had to coast and maneuver across traffic to avoid being hit before the car came to a stop. After shifting into Park, the vehicle displayed DI_w072 and DI_f072 gate‑drive faults, which indicate inverter/drive‑unit failure and match a pattern reported by other early‑model‑year Tesla owners. This sudden loss of motive power created a serious safety hazard, including risk of rear‑end collision and exposure to oncoming traffic while disabled. • No alerts appeared before the failure • Fault codes appeared only after the vehicle stopped • Vehicle required towing • Incident occurred under normal driving conditions • Tesla has denied responsibility or involvement It was serviced by Tesla a couple days before. During servicing they stated on one side the drive axle was not completely installed upon arrival. They stated they "popped it in for free but the drive unit will likely need replacement soon." Prior to this visit i have had no issues or alerts with these parts or systems, I declined any work to these areas. The next day after receiving my vehicle back, I discovered the coolant reservoir was completely empty. No warning was provided that the coolant system had been left unfilled, and the lack of coolant may have contributed to thermal damage in the drive unit or inverter. They denied any work they did involve these parts and denied any responsibility. They denied my request to have the car towed to their service center and diagnose it unless i paid for it. They also estimated the repair to cost me 6k without any further investigation. I request that NHTSA evaluate whether this failure mode represents a broader defect affecting 2012–2015 Model S drive units/inverter electronics and whether further investigation or recall is warranted.

Driver's side rear control arm failure. The outside knuckle of the control arm cracked and is missing a portion. Tesla agrees this is SB-19-31-001 and will not repair without payment, due to the age of the vehicle. Vehicle has been serviced by Tesla multiple times without comment that this should be replaced.

When driving my vehicle the rear axle snapped causing the vehicle to fishtail. When checked by insurance company for repairs they found the Air suspension and rear axle snapped. It took out the air ride suspension, and bent 2 rims. It caused damage to the front fender as well as both interior wheel wells on the driver's side. Due to the suspension issue it caused a rock to come up and cracked windshield. The issue caused my vehicle to leave the road as I could not control the vehicle.

On [XXX], at approximately [XXX], I was driving my 2013 Tesla Model S (VIN: [XXX] ) on [XXX] in Barrow County, Georgia when the instrument cluster/speedometer display went completely blank while driving. This is an intermittent issue that occurs without warning - the display turns off and sometimes freezes. Because the speedometer was not displaying, I had no way to know my actual speed. I was pulled over by Barrow County Sheriff’s Office and cited for speeding. I explained the instrument cluster malfunction to the officer at the scene and showed him the blank display. I took my vehicle to Tesla Service Center in Duluth, GA (3380 Satellite Blvd) on November 4, 2025 - as soon as I could get an appointment after the incident. Tesla cleared the filesystem caches but did NOT inform me about the existing eMMC recall (SB-21-21-001) that affects my vehicle, nor did they perform the recall repair. My 2013 Model S is equipped with the MCU1 with the 8GB eMMC that is subject to NHTSA Recall 21V-119. This is a known defect that NHTSA determined to be a safety issue because it affects critical displays including the speedometer, backup camera, and turn signal indicators. I have video evidence of the malfunction occurring and the Tesla service receipt documenting the issue. The fact that Tesla’s service center did not notify me of the applicable recall or perform the free recall repair. This defect directly resulted in me receiving a traffic citation because I could not see my speedometer while driving INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

November 20, 2025 To the National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation Subject: Safety Defect Complaint – Tesla Model S I am submitting this complaint regarding a serious and dangerous safety defect involving my Tesla Model S. Safety Defect Summary:    •   After the high-voltage battery failed, the vehicle would not enter Neutral.    •   I had to use Tow Mode in the middle of a street on a hill to avoid blocking traffic.    •   Once in Tow Mode, the car could not enter Park and the emergency/parking brake would not engage.    •   The car became completely free-rolling, posing danger to myself, other drivers, and pedestrians.    •   When Tesla returned the car to my home, their technicians also could not get the vehicle into Park or activate any emergency braking system.    •   The car is currently stuck in Tow Mode in my driveway with physical objects placed behind the wheels to prevent it from rolling. Why This Is a Safety Hazard: A vehicle that cannot shift into Park, cannot use its emergency brake, and remains free-moving after a failure represents a serious safety defect. This occurred without warning and left the vehicle unsafe to operate or even store. Request: I respectfully request that NHTSA investigate this as a potential safety defect affecting the Tesla Model S when the high-voltage battery fails. A car should never lose all ability to secure itself.

The vehicle has suffered a catastrophic, intermittent low-voltage network crash caused by a failing Body Control Module (BCM), resulting in multiple dangerous safety-critical failure modes. On a previous occasion, the vehicle woke up with severe network faults and automatically forced itself into Neutral. When the driver stepped out to get the child and shut the door, the system crashed entirely and the exterior electronic door handles failed to present, trapping an infant child inside the running vehicle. Most recently, while driving in a rainstorm, the vehicle suffered a complete failure of the windshield wipers, a total loss of the high-beam headlights, a total loss of the horn, and a total loss of electronic communication to the electronic parking brake system. Most critically, the vehicle experienced an uncommanded propulsion hazard where it hard-locked itself in the 'Drive' gear and absolutely refused to shift into 'Park' or 'Neutral,' forcing the driver to physically maintain heavy hydraulic brake pressure to keep the vehicle from creeping forward. Because the horn failed and the parking brake was disabled, the driver was trapped in the driver's seat holding the brakes and was forced to call 911 for emergency first responders to come and physically block the wheels so the driver and infant could safely exit. Tesla Service has diagnosed the issue as a failed central Body Control Module (Part #1010906-00-D), but the cascading network failure modes present an extreme, life-threatening hazard regarding vehicle control and child entrapment.

While driving my 2013 Tesla Model S at normal road speed, the vehicle suddenly lost all propulsion without any warning. I had to coast and maneuver across traffic to avoid being hit before the car came to a stop. After shifting into Park, the vehicle displayed DI_w072 and DI_f072 gate‑drive faults, which indicate inverter/drive‑unit failure and match a pattern reported by other early‑model‑year Tesla owners. This sudden loss of motive power created a serious safety hazard, including risk of rear‑end collision and exposure to oncoming traffic while disabled. • No alerts appeared before the failure • Fault codes appeared only after the vehicle stopped • Vehicle required towing • Incident occurred under normal driving conditions • Tesla has denied responsibility or involvement It was serviced by Tesla a couple days before. During servicing they stated on one side the drive axle was not completely installed upon arrival. They stated they "popped it in for free but the drive unit will likely need replacement soon." Prior to this visit i have had no issues or alerts with these parts or systems, I declined any work to these areas. The next day after receiving my vehicle back, I discovered the coolant reservoir was completely empty. No warning was provided that the coolant system had been left unfilled, and the lack of coolant may have contributed to thermal damage in the drive unit or inverter. They denied any work they did involve these parts and denied any responsibility. They denied my request to have the car towed to their service center and diagnose it unless i paid for it. They also estimated the repair to cost me 6k without any further investigation. I request that NHTSA evaluate whether this failure mode represents a broader defect affecting 2012–2015 Model S drive units/inverter electronics and whether further investigation or recall is warranted.

The vehicle has suffered a catastrophic, intermittent low-voltage network crash caused by a failing Body Control Module (BCM), resulting in multiple dangerous safety-critical failure modes. On a previous occasion, the vehicle woke up with severe network faults and automatically forced itself into Neutral. When the driver stepped out to get the child and shut the door, the system crashed entirely and the exterior electronic door handles failed to present, trapping an infant child inside the running vehicle. Most recently, while driving in a rainstorm, the vehicle suffered a complete failure of the windshield wipers, a total loss of the high-beam headlights, a total loss of the horn, and a total loss of electronic communication to the electronic parking brake system. Most critically, the vehicle experienced an uncommanded propulsion hazard where it hard-locked itself in the 'Drive' gear and absolutely refused to shift into 'Park' or 'Neutral,' forcing the driver to physically maintain heavy hydraulic brake pressure to keep the vehicle from creeping forward. Because the horn failed and the parking brake was disabled, the driver was trapped in the driver's seat holding the brakes and was forced to call 911 for emergency first responders to come and physically block the wheels so the driver and infant could safely exit. Tesla Service has diagnosed the issue as a failed central Body Control Module (Part #1010906-00-D), but the cascading network failure modes present an extreme, life-threatening hazard regarding vehicle control and child entrapment.

When driving my vehicle the rear axle snapped causing the vehicle to fishtail. When checked by insurance company for repairs they found the Air suspension and rear axle snapped. It took out the air ride suspension, and bent 2 rims. It caused damage to the front fender as well as both interior wheel wells on the driver's side. Due to the suspension issue it caused a rock to come up and cracked windshield. The issue caused my vehicle to leave the road as I could not control the vehicle.

While driving my 2013 Tesla Model S at normal road speed, the vehicle suddenly lost all propulsion without any warning. I had to coast and maneuver across traffic to avoid being hit before the car came to a stop. After shifting into Park, the vehicle displayed DI_w072 and DI_f072 gate‑drive faults, which indicate inverter/drive‑unit failure and match a pattern reported by other early‑model‑year Tesla owners. This sudden loss of motive power created a serious safety hazard, including risk of rear‑end collision and exposure to oncoming traffic while disabled. • No alerts appeared before the failure • Fault codes appeared only after the vehicle stopped • Vehicle required towing • Incident occurred under normal driving conditions • Tesla has denied responsibility or involvement It was serviced by Tesla a couple days before. During servicing they stated on one side the drive axle was not completely installed upon arrival. They stated they "popped it in for free but the drive unit will likely need replacement soon." Prior to this visit i have had no issues or alerts with these parts or systems, I declined any work to these areas. The next day after receiving my vehicle back, I discovered the coolant reservoir was completely empty. No warning was provided that the coolant system had been left unfilled, and the lack of coolant may have contributed to thermal damage in the drive unit or inverter. They denied any work they did involve these parts and denied any responsibility. They denied my request to have the car towed to their service center and diagnose it unless i paid for it. They also estimated the repair to cost me 6k without any further investigation. I request that NHTSA evaluate whether this failure mode represents a broader defect affecting 2012–2015 Model S drive units/inverter electronics and whether further investigation or recall is warranted.

Explained to Tesla service center immediately upon purchasing vehicle while it was still under warranty that the vehicle range was unacceptable using TESLA's warranty guideline for requirements for a battery replacement while under warranty. TELSA refused to changed the battery even though I took the vehicle to TESLA several times while the Battery was still under warranty. A month after the warranty expired the motor died, it had been showing signs wear but TESLA failed to property inform me of the issue and charged me over $6000 for the repair due to my lack of knowledge on what the symptoms are for a failing motor. Shortly after the warning for "Charging - Maximum battery charge level reduced" has come on and TESLA is trying to charge me about $21,000 for a replacement battery.

The contact owns a 2013 Tesla Model S. The contact stated that the parking brake seized while leaving a charging station, and the vehicle screeched into oncoming traffic and stalled. The parking brake warning light was illuminated. The local dealer was contacted, and an appointment was scheduled. The vehicle had not been charged prior to a snowstorm, and the battery became fully drained. The vehicle was taken to the local dealer, where it was determined that the main battery and 12-Volt battery needed to be replaced before the diagnostic test. The vehicle was repaired, but the failure reoccurred. The vehicle failed to shift into drive or move. The jack mode was disengaged. While driving, the rear wheels were screeching. The contact stated that the failure was related to TSB: SB-21-33-002). The vehicle was towed to another local dealer, Tesla Service Arlington-Glebe Rd (2710 S Glebe Rd, Arlington, VA 22206). The vehicle was not diagnosed or repaired. The battery was at 19 percent. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 108,000.

- Vehicle accelerated while I was pressing the brake on my 2013 Model S Tesla Car - My vehicle rammed into another vehicle waiting at the traffic light resulting in damage to both the cars as well trauma for the female driver in the other car - I see exact complaints have been filed by many others - Tesla has rejected these complaints and blamed it on the driver - There were no warning indications

The contact owns a 2013 Tesla Model S. The contact stated that while driving at an undisclosed speed, the center display screen malfunctioned, causing the rearview camera to intermittently fail. Additionally, the failure caused a delay while switching gears to drive(D) and to park(P). The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and determined through the Tesla App that the VCM daughterboard needed to be replaced with one containing an enhanced eMMC controller. The contact related the failure to NHTSA Campaign Number: 21V035000 (Back Over Prevention, Visibility, Exterior Lighting) however, the VIN was not included in the recall. The failure mileage was approximately 95,500.

The contact owns a 2013 Tesla Model S. The contact received notification of NHTSA Campaign Number: 21V035000 (Back Over Prevention, Visibility, Exterior Lighting). The contact stated that the recall repair was performed twice however, the vehicle experienced an unknown computer failure. The contact stated while driving at various speeds, the seats moved independently. The contact was unaware of a warning light being illuminated. The contact stated that the driver’s side seat would revert to the seat settings of the second driver independently while the vehicle was in motion. The contact had taken the vehicle to a dealer, where it was diagnosed and determined that the eMMC controller needed to be replaced. The vehicle was repaired; however, the failure occurred again and the eMMC controller was replaced a second time. The failure persisted. The failure mileage was 123,864.

The contact owns a 2013 Tesla Model S. The contact stated that the parking brake seized while leaving a charging station, and the vehicle screeched into oncoming traffic and stalled. The parking brake warning light was illuminated. The local dealer was contacted, and an appointment was scheduled. The vehicle had not been charged prior to a snowstorm, and the battery became fully drained. The vehicle was taken to the local dealer, where it was determined that the main battery and 12-Volt battery needed to be replaced before the diagnostic test. The vehicle was repaired, but the failure reoccurred. The vehicle failed to shift into drive or move. The jack mode was disengaged. While driving, the rear wheels were screeching. The contact stated that the failure was related to TSB: SB-21-33-002). The vehicle was towed to another local dealer, Tesla Service Arlington-Glebe Rd (2710 S Glebe Rd, Arlington, VA 22206). The vehicle was not diagnosed or repaired. The battery was at 19 percent. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 108,000.

Complete engine failure. Car became disabled and unable to move. Upon investigation, this was drive unit failure due to coolant leaking past the seal. A common issue of Tesla Model S and X with the large drive unit. I believe that this is a design flaw and should be a class action type situation. Can you help?

Front impact bumper separated from mount on one side due to rust. Noticed a noise from front of car when going over small bumps in the road. If we had been in an accident, the impact bumper would not have provided adequate protection for the passengers or vehicle components near the drivers front where the mount had separated from the bar. No other inspections have occurred. Pictures and info can also be found here: [XXX] Issue found during replacement of upper control arms. (image has an upper control arm that was removed from the same car at the same time with little/no rust) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

When parked and opening the drivers door or rear passenger doors, the front passenger door will unlatch. Something is setting off the relay to open the front door when other doors open. Does not happen 100% of the time, but 50%+

Vehicle lights turned off while driving home with my family. Pulling over and turning off and on the car reset the problem. When lights turned off I received a warning light identifying a faulty right headlight and faulty left headlight. No accident and vehicle is currently outside manufacture warranty.

The contact owns a 2013 Tesla Model S. The contact received notification of NHTSA Campaign Number: 21V035000 (Back Over Prevention, Visibility, Exterior Lighting). The contact stated that the recall repair was performed twice however, the vehicle experienced an unknown computer failure. The contact stated while driving at various speeds, the seats moved independently. The contact was unaware of a warning light being illuminated. The contact stated that the driver’s side seat would revert to the seat settings of the second driver independently while the vehicle was in motion. The contact had taken the vehicle to a dealer, where it was diagnosed and determined that the eMMC controller needed to be replaced. The vehicle was repaired; however, the failure occurred again and the eMMC controller was replaced a second time. The failure persisted. The failure mileage was 123,864.

The contact owns a 2013 Tesla Model S. The contact stated upon attempting to remove the charger from the vehicle charging port, the charger remained plugged in. The manufacturer was notified of the failure and sent a certified technician who assisted in releasing the charger. The certified technician diagnosed that the charging port and the charger cord had melted and needed to be replaced. The manufacturer informed the contact that he would be responsible for the cost of repair. The contact became aware of NHTSA Campaign Number: 14V006000 (Equipment). The vehicle was not repaired. The failure mileage was approximately 120,350.

2019, 2020, 2021, 2022 Prior 2022 I shared with Tesla several times about my tires constant notification on the dashboard for low air. Tires were constantly being checked due to the dashboard display. I was told by Tesla it was covered, but no repair was done. When Tesla mobile or service only air was placed into the tires. Then I was told by Tesla mobile & calling 1800 when service, then when recall was performed it should fix the problem. Vehicle was not driven often due to black screen and tire issues/dashboard display. 2022 eMMC is finally replaced but now the warning on the dashboard reads 'Tire pressure monitoring system fault. Pressure sensor fault 'MAY' CLEAR NEXT DRIVE. This is negligent for Tesla to say IT MAY CLEAR NEXT DRIVE (see pic). Tesla service had the vehicle in shop several times and refused to repair/correct this SAFETY issue. I have complained and Tesla has blocked me from messaging Tesla. What if there is a blow out, low pressure, faulty system and an accident occurs causing hurt, harm, or death?

This issue appears to be related to a known MCU failure affecting early Tesla Model S vehicles. The touchscreen exhibits screen melting/discoloration and eventually goes blank or becomes inoperative. When this occurs, critical functions including occupant detection indicators, seatbelt warnings, and windshield defrost controls may become unavailable. The loss of these functions creates potential safety risks involving visibility, occupant protection, and driver awareness while operating the vehicle."

This issue appears to be related to a known MCU failure affecting early Tesla Model S vehicles. The touchscreen exhibits screen melting/discoloration and eventually goes blank or becomes inoperative. When this occurs, critical functions including occupant detection indicators, seatbelt warnings, and windshield defrost controls may become unavailable. The loss of these functions creates potential safety risks involving visibility, occupant protection, and driver awareness while operating the vehicle."

The contact owns a 2013 Tesla Model S. The contact stated that while driving at 70 MPH, the vehicle inadvertently lost motive and electrical power. A warning message stating that the vehicle was about to shut off was illuminated. The contact swerved to the right, attempting to veer to the side of the road on the right lane; however, the vehicle stopped midway and a semi-truck almost crashed into the rear passenger’s side of the vehicle. The contact pushed the vehicle into a nearby parking lot with assistance. The vehicle was towed to the dealer who diagnosed that the battery had failed and needed to be replaced. The dealer advised the contact that they had replaced the battery with a new battery; however, the failure reoccurred, and the battery was replaced for a second time. The Department of Auto Motor Repair of California investigated and informed the contact that the dealer had kept his original battery and the third battery that the dealer installed in the vehicle was not new. The contact stated that the vehicle was taken to the dealer who replaced the third battery with the original one; however, the failure reoccurred. The dealer replaced the original battery with an upgraded battery. The contact also stated that the hood would not close securely. The vehicle was taken to the dealer but was not repaired. The vehicle was towed to a second dealer; Tesla (7077 W Sahara Ave, Las Vegas, NV 89117) who repaired the vehicle. The contact stated that the rear passenger’s side door would fail to close. The vehicle was towed twice to the second dealer and was finally repaired. The contact stated that the center display of the vehicle would inadvertently turn off while driving. The contact stated that the failure had prevented him from using the rearview camera or have control of the door switches and some features of the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 45,000.

DOOR HANDLE PROBLEMS THE HANDLE FAILS EVERY 6MONTHS SHOULD BE A RECALL DRIVE TRAIN ISSUES

This issue appears to be related to a known MCU failure affecting early Tesla Model S vehicles. The touchscreen exhibits screen melting/discoloration and eventually goes blank or becomes inoperative. When this occurs, critical functions including occupant detection indicators, seatbelt warnings, and windshield defrost controls may become unavailable. The loss of these functions creates potential safety risks involving visibility, occupant protection, and driver awareness while operating the vehicle."

This issue appears to be related to a known MCU failure affecting early Tesla Model S vehicles. The touchscreen exhibits screen melting/discoloration and eventually goes blank or becomes inoperative. When this occurs, critical functions including occupant detection indicators, seatbelt warnings, and windshield defrost controls may become unavailable. The loss of these functions creates potential safety risks involving visibility, occupant protection, and driver awareness while operating the vehicle."

I purchased a 2013 Tesla Model S P85+ in March of 2022 and by April of 2022 the rear left tire separated at the corner of the side wall ( side facing underneath the vehicle). By July of 2022, I had another incident with the same problem. After repairing that problem, it happened again the following week. I took it for repair and two days later, it happened again. I have come to learn from other Tesla owners that the vehicle is heavy and that the tires can not adequately support the tires which is leading to this defect. It is a safety issue to have tires blowing out on the highway when one is traveling at higher speeds.

TL THE CONTACT OWNS A 2013 TESLA MODEL S EQUIPPED WITH LIONHART LH-FIVE TIRES, SIZE: 245/35/R21 (NA). WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE PULLED TO THE LEFT. THE VEHICLE WAS TAKEN TO AN UNKNOWN TESLA DEALER IN TORRANTE, CA WHERE IT WAS DIAGNOSED THAT THE REPLACEMENT TIRES WERE FAULTY. THE TIRES WERE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE TIRE FAILURE MILEAGE VARIED. THE VEHICLE FAILURE MILEAGE WAS APPROXIMATELY 107,000. THE DOT NUMBER AND VIN WERE NOT AVAILABLE.