Owner-reported complaints naming the tire or wheel system, filed with NHTSA
Data refreshed
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system. Every record below is an owner-reported complaint about the 2022 Tesla Model S submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 8 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
Back tires are popping in the inner wall I’m on my 6th tires for the years same thing keeps happening. Steering wheel is falling apart Tesla is refusing to fix it.
Vehicle: 2022 Tesla Model S Tire: Goodyear ElectricDrive 2 255/45R19 104W XL Date of incident: October 15, 2025 Location: Chambers Rd., approximately 1.7 miles from Cosmopolitan Rd., Colorado Speed: Approximately 35 mph (speed limit 40 mph) Mileage on tire: Installed October 31, 2024 — approximately 10,000 miles of light local driving Description of the Problem At approximately 1:30 PM on October 15, 2025, while driving my Tesla Model S southbound on Chambers Road at around 35 mph, the driver-side front tire suddenly exploded and detached completely from the vehicle. I heard a loud thump, then saw a tire rolling ahead of me on the road. The car’s display immediately showed “tire pressure 0.” When I stopped and exited the vehicle, I found that the tire had either blown apart or peeled off the rim and separated entirely from the car. Weather was clear and around 70°F, road conditions were normal, and traffic was light. My tire pressures had been checked earlier that day and were all around 42 PSI. I was unable to retrieve the tire because I have limited mobility and use a scooter. My daughter arrived soon after but could not locate the missing tire either. The vehicle was towed by AAA to a tire shop. The technician stated that the tire appeared to have peeled off the wheel, but could not explain why. The tire was less than one year old and had very low mileage. I drive short local trips daily (around 10–15 miles) and had only taken one 700-mile trip earlier this year. Goodyear was contacted, but they declined to investigate because the tire could not be recovered. This incident could have caused a serious crash had it occurred minutes later on I-25, where I planned to drive at 75 mph. I am reporting this because I believe the tire may have suffered a manufacturing defect, and I am concerned other drivers could experience the same failure.
In the time of 2 years of ownership of this vehicle, I have had a blown out tire happen 3 separate times with these particular tires, whether it has been the rear left side or rear right side, leaving me stranded on the street.
Tire sidewall delaminated above the DOT markings. Vehicle purchased new, with only 8500 miles. No tires impacts and tire pressure maintained within recommended PSI (automatically remotely monitored by vehicle). Second rear tire to fail within last 500 miles of driving - failed in exact same way, and exact same place -delaminated above the DOT markings. 295/30ZR21 Michelin Pilot Sport 4 S T2 Acoustic
Tire sidewall delaminated above the DOT markings. Vehicle purchased new, with only 8500 miles. No tires impacts and tire pressure maintained within recommended PSI (automatically remotely monitored by vehicle). Second rear tire to fail within last 500 miles of driving - failed in exact same way, and exact same place -delaminated above the DOT markings.
Rear tires have alarming wear on the inside, where the inside sidewall meets the tread. This is identical to the other complaints that are logged on NHTSA about Michelin Pilot Sport 4S rear tires on Tesla Model S Plaid cars. Tires are: Michelin Pilot Sport 4S 295/30 ZR21 102Y XL BSW. Specifically, the right rear tires loses pressure and needs to be reinflated. The left rear tire, according to inspection, actually looked worse, but is not yet losing pressure. This is impossible to see or know about without removing the tire or putting the car on a lift, since it is on the is inside sidewall/tread of the rear tire. There is high danger of a blowout because of some type of defect (camber/suspension or tire) which cannot be seen by the consumer. I would have never known about this if the tire technician had not alerted me, and probably would have had a high-speed blowout.
Inner tire tread only wears significantly to the point of failure. This may be a factory alignment issue or other but is noted in many forums. I was losing air quickly and based on research saw this was a common issue with these specific cars. The tread appears fine at 8000 miles but when removing the wheel from the car you can notice the inner surface only is worn to the point of failure with the inner belt showing is parts. I was able to remove the wheel and see the issue before experiencing a blowout while driving.
The OEM Michelin rear tire used on the 2021 and 2022+ Tesla Model S has a serious safety defect which results in extreme wear/tread separation at the inner sidewall/tread junction. Numerous defective tires are shown on this thread, among others: https://teslamotorsclub.com/tmc/threads/plaid-21%E2%80%9Drear-tire-woes-factory-defect.269394/ Both Tesla and Michelin report the tires are nationwide backorder (likely due to the number of tire failures in the field). Thus far, Tesla and Michelin have taken NO action on proactive tire replacements, despite repeated requests. (Perhaps they are awaiting accidents with fatalities first?) Please take action to secure a recall as this defect is extremely difficult to note as the tire tread separation occurs most often at the inner sidewall of the rear tires, a nearly impossible area to inspect.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .