Owner-reported complaints naming the interior system, filed with NHTSA
Data refreshed
Reports naming seats, latches, locks, linkages and interior fittings. Every record below is an owner-reported complaint about the 2016 Tesla Model X submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 15 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
Problem: Driver door fails to open The door actuator and latch will intermittently fail and the door will refuse to open. In the event of an accident the driver can fail to exit the vehicle possibly leading to death. An independent party/dealer has not produced the problem. No representative has looked at the problem. No warnings of failure appear.
My 2016 Tesla Model X has a persistent and dangerous issue with the electronic parking brake. The brake frequently fails to disengage properly, and the car becomes jerky when attempting to move. When the vehicle is parked, a warning appears stating: “Parking brake not engaged. Vehicle may roll,” even when the brake is set. This poses a significant safety risk, especially on inclines. Additionally, the driver-side door latch mechanism has failed again. Tesla previously repaired this exact issue and charged me, but the failure has returned. The door sometimes fails to latch securely or does not open and close properly, creating a safety hazard. These issues have made me concerned about the safety of driving or parking the vehicle. I believe these components should be investigated as potential manufacturing or design defects.
The contact owned a 2016 Tesla Model X. The contact stated that while his wife was driving approximately 15 MPH from a traffic light, the vehicle was T-boned by another vehicle attempting to run the red light. The contact stated that the other vehicle crashed into the driver’s side front fender panel of the vehicle. The contact stated that the driver’s door was not impacted in the crash. The contact stated that the air bags deployed as needed. However, the contact’s wife was stuck in the vehicle, and unable to exit the vehicle because the doors failed to unlock. The contact stated that the vehicle had lost all electrical functions, causing the doors to remain closed. The contact stated that his wife was unable to move over to the passenger’s side front or rear to exit the vehicle. The contact stated that some pedestrians nearby were able to unlock the door from outside for his wife to exit the vehicle. The contact was concerned that his wife could have been killed if the vehicle had caught on fire or there was some other form of an emergency. The contact stated that his wife sustained a knee injury. Medical attention was not needed at the scene; however, the contact’s wife had since started receiving physical therapy for pain in her knee. The contact was unsure if the other driver had sustained any injuries. A Police report was filed. The vehicle was towed to a tow lot and was deemed a total loss. The manufacturer was not notified of the failure. The failure mileage was approximately 60,000.
The Rear captain seats (6 seater middle row) are no longer stable. They both have a back and forth motion to them. The passenger side one makes a noticeably bad noise when the car is in motion. This is a sign that the seat is failing and has lost its proper fitment.
The car door propped open as I was driving the vehicle. There have been multiple repeated concerns that I have had with this vehicle. It is unsafe.
The car front passenger side door open while driving and does not close and the car sting in Babson College campus as my daughter cannot close door, cannot drive and Tesla service does not give repair date before two weeks and no one else knows can repair this part . This is third time in 3 months we are having problem and after spending over 3000$ in less than 3 months with full inspection down by Tesla . The service people are rude and does not care for student safety as well. Such a shame
Car sensors don’t seem to work hits other cars and doors close hard on a human before stopping very unsafe for a child
My 2016 model X has been experiencing front passenger and rear passenger safety restraint system faults off and on since we purchased the vehicle in 2019. This notification requires service and the Tesla service center has done a mixture of hardware checks, replacement of parts and keeps blaming the issues on a firmware update that will eventually happen in the future. Tesla says that when the system is tripped the airbags may not deploy and to schedule service when it happens. Because the vehicle is under a used warranty they refuse to address this as a recall or possibly defect.
The second tow captain rear seats are not bolted securely. The seats both rock forward and back. I brought it up to Tedla service and the representative came back with, The car is 6 years old. So does that mean Tesla Model X captain seats begin to fail after 6 years? The other issue is a steering issue. When I steer left or right I hear a clunking noise. It's not related to the control arm as it is a known issue. The odd thing is when it rains the noise goes away which I believe it may be related to a lubrication issue. When the vehicle dries up after a day or two the noise starts again.
The 2nd row seats are loose and Tesla will not help cover the costs of repair citing its normal wear and tear. This is a safety issue that should be covered due to it only being a 6 year old car. This would mean that Tesla seats should be expected to fail after 6 years. That seems like a problem to me.
THERE ARE KEY FOBS, ONE EACH FOR THE TWO DRIVERS IN THE HOUSE. THESE ARE IDENTIFIED IN THE PROFILE SETTINGS. FOR THE PAST FOUR YEARS, AFTER A SPECIFIC UPDATE TO THE FIRMWARE (I CAN’T PINPOINT WHICH OR THE PRECISE MONTH/YEAR), USING A KEY FOB WILL FREQUENTLY, BUT ERRATICALLY CHOOSE THE WRONG PROFILE. BECAUSE OF THE DIFFERENCE IN DRIVER HEIGHTS, THIS MAY MEAN THAT THE SEAT IS ADJUSTING FORWARD CAUSING KNEES TO QUICKLY APPROACH THE AREA OF THE DASHBOARD. AS ONE EXAMPLE WHERE I HAVE PINPOINTED WHEN THIS IS LIKELY TO OCCUR, I WILL HAVE FINISHED CHARGING THE TESLA AT A SUPERCHARGER. I WILL TRY TO REVERSE OUT OF THE SPOT BEFORE NOTICING THAT THE WRONG PROFILE HAS BEEN SELECTED. SO AS THE CAR IS MOVING, MY KNEES ARE PUSHING FORWARD TOWARD THE DASH. BECAUSE I AM ANXIOUS AS THIS HAPPENS, I WILL QUICKLY BRAKE. TESLA FINALLY REPLACED ALL COMPONENTS (KEY FOBS, BUT ALSO THE PART THAT RECEIVES THE TRANSMISSION) WHICH TEMPORARILY CORRECTED THE SITUATION UNTIL IT STARTED UP AGAIN. I AM NOW ON MY FIFTH COMPLAINT TO TESLA AND HAVE YET ANOTHER APPOINTMENT TO HAVE IT FIXED. I THIINK THIS IS A DANGEROUS PROBLEM BECAUSE IT CAN AFFECT THE DRIVER WHILE THE CAR IS MOVING.
I received a letter from Tesla indicating an "Important Safety Recall Notice". The letter indicated that the rear seat did not conform to Federal Motor Vehicle Safety Standard Nos. 207 and 210. The notice suggest that one should avoid sitting in the seat. The repair would only take 10 minutes. When I tried to make an appointment the service representative said 1) that it was NOT a recall, but a Service Notice, 2) since I was out of warranty I would have to pay over $500 for the repair.
The contact owns a 2016 Tesla Model X. The contact stated that while operating the vehicle, the front driver’s side door would not completely close or lock securely. The contact then received a message from the manufacturer’s APP, indicating that the vehicle was not locked securely. Also, a gel-like substance was leaking from the monitor display unit onto the monitor screen posing a visibility hazard while using the backup camera. The cause of the failure was not yet determined. The local service center and manufacturer were notified of the failure. The failure mileage was 31,570.
TL* THE CONTACT OWNS A 2016 TESLA MODEL X. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 5 MPH WHEN THE VEHICLE'S FRONT PASSENGER DOOR SUDDENLY UNLOCKED AND OPENED. THE CONTACT ATTEMPTED TO CLOSE THE DOOR, HOWEVER, THE DOOR FAILED TO LATCH. THE CONTACT STATED THEY HAD TO RETURN HOME HOLDING THE DOOR AS THEY WERE DRIVING. THE VEHICLE'S DOOR NOW FAILS TO LOCK. THE CONTACT DID NOT CONTACT THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THEY WOULD BE ABLE TO SEND A MECHANIC TO FIX THE DOOR WITHIN A MONTH. THE APPROXIMATE FAILURE MILEAGE WAS 28,000.*DT*JB
FALCON DOORS NOT CLOSING, REAR DRIVER SEAT ELECTRICAL DEAD, WARNING LIGHT BLOCKING BACKUP CAMERA READING REAR SEATS NOT IN PLACE, ALL INSULATION PEELING OFF ABOVE TIRES, BUBBLING PAINT, TRUNK AND SIDE PANELS MISALIGNED SO TILTED TRUNK HOOD AND FINGER GOES IN ONE GAP BUT FINGERNAIL ONLY BARELY IN OTHER SIDE GAP, WAVY INSULATION ALONG REAR, FRONT PASSENGER DOOR MOTOR SPINS. PERMANENT SEAT DEPRESSION IN REAR. STATIONARY TO BACKING UP.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .