RoadVitals

2003 Thomas Built Buses Mvp-Ef Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Newest Nov 26, 2008
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
2 investigations on file

Recall campaigns

3 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

08V622000

ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS

Nov 26, 2008
18,198 units potentially affected
The defect: DAIMLER TRUCKS IS RECALLING 18,198 MY 2003-2009 THOMAS BUILT ER, MVP-ER, HDX, AND MVP-EF SCHOOL AND TRANSIT BUSES EQUIPPED WITH A DUAL POWER SWITCH AND MANUFACTURED FROM FEBRUARY 1, 2002 THROUGH OCTOBER 17, 2008. SOLID STATE CIRCUIT BREAKERS MAY TRIP UNNECESSARILY POTENTIALLY RESULTING IN A LOSS OF POWER TO THE BUS CHASSIS AND BODY ELECTRICAL CIRCUITS CAUSING AN UNEXPECTED LOSS OF ENGINE POWER AND EXTERIOR LIGHTING.
The risk: UNEXPECTED LOSS OF ENGINE POWER AND EXTERIOR LIGHTING COULD RESULT IN A VEHICLE CRASH.
The remedy: THOMAS BUILT BUS DEALERS WILL REPLACE THE SOLID STATE DUAL POWER SWITCH WITH A MECHANICAL CIRCUIT PRODUCTION (MEGA FUSE). THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT THOMAS BUILT AT 1-336-889-4871.
DAIMLER TRUCKS NORTH AMERICAManufacturer number FL-539View on NHTSA.gov
08V088000

EQUIPMENT ADAPTIVE/MOBILITY

Feb 26, 2008
760 units potentially affected
The defect: DAIMLER TRUCKS IS RECALLING 760 MY 2003-2007 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 6, 2005 AND JULY 19, 2006, EQUIPPED WITH BRAUN WHEELCHAIR LIFTS, MODELS NL, NCL, OR NVL. THE THRESHOLD WARNING SYSTEMS OF THE SUBJECT MODEL WHEELCHAIR LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES.
The risk: SHOULD THE THRESHOLD WARNING SYSTEM FAIL TO OPERATE, THE LIFT USER CAN FALL FROM THE VEHICLE AND BE SERIOUSLY INJURED.
The remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND PROVIDE A FREE REMEDY WHICH WILL BE PERFORMED BY THOMAS BUILT DEALERSHIPS. THE RECALL BEGAN ON AUGUST 8, 2008. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871.
DAIMLER TRUCKS NORTH AMERICAManufacturer number FL-524View on NHTSA.gov
03V205000

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

Jun 2, 2003
461 units potentially affected
The defect: ON CERTAIN THOMAS SCHOOL BUSES, THE ALTERNATOR CABLE CAN PINCH BETWEEN THE AIR CONDITIONING COMPRESSOR AND ENGINE BLOCK.
The risk: THIS CAN RESULT IN DAMAGE TO WIRE INSULATION AND POTENTIALLY CAUSE A SHORT CIRCUIT.
The remedy: DEALERS WILL RE-ROUTE THE CABLE. OWNER NOTIFICATION BEGAN JULY 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER/THOMAS BUILT AT
FREIGHTLINER CORPORATIONManufacturer number FL-415View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

PE04062ClosedPreliminary Evaluation

TIE ROD TUBE FAILURE

Opened Sep 3, 2004
Closed Feb 2, 2005

THIS INVESTIGATION WAS PROMPTED BY COMPLAINTS FROM TWO SEPARATE SCHOOL BUSFLEETS.BOTH FLEETS ALLEGED THAT WHILE MANEUVERING IN A PARKING AREA, THE TIE-ROD TUBE DISCONNECTED FROM ONE OF THE TIE-RODS.DANA, FREIGHTLINER AND THOMAS BUILT BUSES RECENTLY COMPLETED EXTENSIVE TESING AND DETERMINED THAT A CRACK MAY INITIATE ON THE INTERNAL THREAD ROOT OF THE TIE ROD.THIS CONDITION IS DUE TO INADEQUATE DAMPENING IN THE CHASSIS SYSTEM TO ACCOUNT FOR NORMAL BRAKE-INDUCED VIBRATION.THESE CRACKS MAY LEAD TO SEPARATION OF THE TIE ROD FROM THE ASSEMBLY.APPROXIMATELY 5,839 DANA STEER AXLES EQUIPPED WITH A CERTAIN TRW TIE ROD ASSEMBLY UTILIZING A CUT THREAD DESIGN ARE INVOLVED:A.1320 AXLE APPLICATIONS, THOMAS PART NUMBER 61110702 AND 61110705 INSTALLED ON THOMAS BUSES WITH 6" BRAKES AND 30" AIR CHAMBERS;B.1460 AXLE APPLICATIONS, THOMAS BUS PART NUMBER 61110707 AND 61110708 INSTALLED WITH 6" BRAKES AND 30" AIR CHAMBERS. THOMAS BUILT BUS WILL REPLACE THE EXISTING TIE ROD ASSEMBLIES WHICH CONTAIN THE CUT THREAD DESIGN WITH A NEW TIE ROD ASSEMBLY THAT UTILIZES A ROLLED THREAD DESIGN.A ROLLED THREAD PROVIDES LESS STRESS ON THE CRITICAL AREA OF THE TIE ROD. A COPY OF THE DEFECT REPORT IS ATTACHED. THIS ACTION RESOLVES THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY,THIS INVESTIGATION IS CLOSED.

STEERING:LINKAGES:TIE ROD ASSEMBLY
EA04014ClosedEngineering Analysis

SCHOOL BUS LIGHTING FAILURES

Opened Jun 9, 2004
Closed Dec 20, 2004

SEE ATTACHED FOUR PAGE TECHNICAL REPORT FOR DETAILS.

EXTERIOR LIGHTING:HEADLIGHTS:SWITCH

Elsewhere on this vehicle

Data sources