RoadVitals

1988 Thomas Bus Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
5
Newest Aug 24, 1992
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
1 investigation on file

Recall campaigns

5 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

92V120000

POWER TRAIN:DRIVELINE:DRIVESHAFT

Aug 24, 1992
1 units potentially affected
The defect: THE DRIVESHAFT USED WITH SOME ENGINE/TRANSMISSION COMBINATIONS HAD INSUFFICIENT WELDS JOINING SOME OF THE COMPONENTS.
The risk: THE BAD WELDS CAN DEVELOP CRACKS THAT CAN CAUSE COMPLETESEPARATION OF THE DRIVESHAFT. THIS CAN RESULT IN LOSS OF MOTIVE POWER FOR THEVEHICLE AND POSSIBLE LOSS OF VEHICLE CONTROL.
The remedy: REPLACE DEFECTIVE NORTH AMERICAN DRIVESHAFTS WITH SPICER DRIVESHAFTS.
THOMAS BUILT BUSES, INC.View on NHTSA.gov
92V013000

VISIBILITY:GLASS, SIDE/REAR

Jan 3, 1992
7,500 units potentially affected
The defect: THE CENTER ACTUATOR THAT RELEASES TWO CATCHES VIA TWO PULL RODS CAN BECOME NON-FUNCTIONAL FROM POOR OR IMPROPER MAINTENANCE, LACK OF LUBRICATION, CORROSION, OR A COMBINATION ALL THREE CAUSES.
The risk: WHEN THE CENTER ACTUATOR IS NON-FUNCTIONAL, THE WINDOWIS VERY DIFFICULT TO OPEN, AND WOULD NOT FUNCTION AS AN EMERGENCY EXIT IN CASEOF A VEHICULAR ACCIDENT.
The remedy: REMOVE THE OLD CENTER ACTUATOR AND INSTALL AN IMPROVED ACTUATOR.
THOMAS BUILT BUSES, INC.View on NHTSA.gov
91V006000

VISIBILITY:GLASS, SIDE/REAR

Oct 3, 1991
2,986 units potentially affected
The defect: RELEASE HANDLE FOR REAR PUSH OUT WINDOW IS NOT LOCATED IN AREA REQUIRED BY S5.2.3.1(B) OF FMVSS 217.
The risk: BUSES WOULD NOT COMPLY WITH STANDARDS; IN AN EMERGENCY,EXIT FROM THE PUSH-OUT WINDOW COULD BE HAMPERED.
The remedy: INSTALL NEW INTERIOR HANDLE ASSEMBLY TO MEET SPECIFICATIONS.
THOMAS BUILT BUSES, INC.View on NHTSA.gov
91V169000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Oct 1, 1991
407 units potentially affected
The defect: THE FUEL SHUT-OFF SOLENOID IN THE CUMMINS 6C ENGINE MAY BE FAULTY, CAUSING SPONTANEOUS INTERRUPTION OF FUEL FLOW TO THE ENGINE DURING NORMAL OPERATION. THIS RESULTS IN LOSS OF POWER TO DRIVING WHEELS, POWER STEERING, AND OTHER POWER ASSISTED OPERATING SYSTEMS.
The risk: LOSS OF ENGINE POWER AND SECONDARY LOSS OF POWER ASSISTEDSYSTEMS REDUCES STEERING CONTROL, BRAKING ABILITY, VISUAL SYSTEMS AND OTHERPOWER ASSISTED OPERATING SYSTEMS, RESULTING IN INCREASED RISK OF VEHICLEACCIDENT.
The remedy: WHERE NECESSARY, REPLACE THE SOLENOID SPRING, ADJUST SOLENOID, REPLACE WIRES, AND VERIFY MAXIMUM POWER REQUIREMENTS TO THE SOLENOID.
THOMAS BUILT BUSES, INC.View on NHTSA.gov
90V025000

SEAT BELTS:FRONT:ANCHORAGE

Feb 9, 1990
48 units potentially affected
The defect: UPPER ANCHORAGE OF TYPE 2 SAFETY BELT INSTALLED AT THE DRIVER'S SEATING POSITION IS NOT WITHIN THE SPECIFIED RANGE AS REQUIRED BY FMVSS 210.
The risk: BELTS MAY BE UNCOMFORTABLE AND OBSTRUCT VISION TO THE LEFT; BUSES WOULD NOT COMPLY WITH STANDARD.
The remedy: INSTALL REINFORCING CHANNEL ASSURING THAT BELTS ARE WITHIN SPECIFIED RANGE.
THOMAS BUILT BUSES, INC.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

PE92035ClosedPreliminary Evaluation

AXLE/UNIVER.YOKE FAILURE

Opened Mar 30, 1992
Closed Aug 20, 1992

There is no summary currently available

SUSPENSIONLed to recall 92V120000

Elsewhere on this vehicle

Data sources