RoadVitals

1992 Thomas Bus Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
5
Newest Mar 3, 1993
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

5 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

93V029000

SEATS

Mar 3, 1993
188 units potentially affected
The defect: THE SAFETY BELT ANCHORAGE BOLTS DO NOT COMPLY WITH THE REQUIREMENTS OF FMVSS 210, "SEAT BELT ASSEMBLY ANCHORAGES". THE SEAT ANCHORAGES COULD NOT MAINTAIN LOAD OF 5,000 LBS FOR 10 SECONDS.
The risk: THE SAFETY BELTS MIGHT NOT ADEQUATELY PROTECT SEATOCCUPANTS IN THE EVENT OF A SUDDEN STOP OR ACCIDENT.
The remedy: REPLACE THE ANCHORAGE BOLTS WITH BOLTS OF A LARGER DIAMETER, WHICH MEET THE LOAD REQUIREMENTS OF FMVSS 210.
THOMAS BUILT BUSES, INC.View on NHTSA.gov
92V126000

SEATS

Sep 8, 1992
1,526 units potentially affected
The defect: INCORRECT SCREWS WERE USED TO ATTACH THE PLYWOOD SEAT BACK TO THE SEAT FRAME.
The risk: THE DRIVER'S SEAT BACK DOES NOT MEET THE STRENGTHREQUIREMENTS OF FMVSS 207, "SEATING SYSTEM". SHOULD THE SEAT BACK FAIL WHILETHE BUS IS IN MOTION, THE OPERATOR COULD LOSE CONTROL OF THE BUS.
The remedy: REMOVE INCORRECT SCREWS ATTACHING THE PLYWOOD BACK TO THE SEAT FRAME AND INSTALL PROPER SCREWS.
THOMAS BUILT BUSES, INC.View on NHTSA.gov
92V120000

POWER TRAIN:DRIVELINE:DRIVESHAFT

Aug 24, 1992
1 units potentially affected
The defect: THE DRIVESHAFT USED WITH SOME ENGINE/TRANSMISSION COMBINATIONS HAD INSUFFICIENT WELDS JOINING SOME OF THE COMPONENTS.
The risk: THE BAD WELDS CAN DEVELOP CRACKS THAT CAN CAUSE COMPLETESEPARATION OF THE DRIVESHAFT. THIS CAN RESULT IN LOSS OF MOTIVE POWER FOR THEVEHICLE AND POSSIBLE LOSS OF VEHICLE CONTROL.
The remedy: REPLACE DEFECTIVE NORTH AMERICAN DRIVESHAFTS WITH SPICER DRIVESHAFTS.
THOMAS BUILT BUSES, INC.View on NHTSA.gov
92V078000

SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS

May 19, 1992
24 units potentially affected
The defect: A BRAKE AIR LINE PLUMBING ERROR CAUSES THE SPRING BRAKES TO BE APPLIED WITHOUT BRAKE APPLICATION WHEN THE AIR PRESSURE IN THE PRIMARY TANK DROPS TO A LEVEL WHICH AUTOMATICALLY ACTIVATES THE SPRING BRAKE SYSTEM.
The risk: ACTIVATION OF THE SPRING BRAKE SYSTEM WITHOUT OPERATORBRAKE APPLICATION WILL CAUSE THE SPRING BRAKE TO BE APPLIED, LOCKING THE BRAKESWITHOUT ANY WARNING TO THE OPERATOR.
The remedy: REPLACE AND REROUTE AIR BRAKE HOSE TO COMPLY WITH FMVSS 121.
THOMAS BUILT BUSES, INC.View on NHTSA.gov
92V013000

VISIBILITY:GLASS, SIDE/REAR

Jan 3, 1992
7,500 units potentially affected
The defect: THE CENTER ACTUATOR THAT RELEASES TWO CATCHES VIA TWO PULL RODS CAN BECOME NON-FUNCTIONAL FROM POOR OR IMPROPER MAINTENANCE, LACK OF LUBRICATION, CORROSION, OR A COMBINATION ALL THREE CAUSES.
The risk: WHEN THE CENTER ACTUATOR IS NON-FUNCTIONAL, THE WINDOWIS VERY DIFFICULT TO OPEN, AND WOULD NOT FUNCTION AS AN EMERGENCY EXIT IN CASEOF A VEHICULAR ACCIDENT.
The remedy: REMOVE THE OLD CENTER ACTUATOR AND INSTALL AN IMPROVED ACTUATOR.
THOMAS BUILT BUSES, INC.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources