RoadVitals

1997 Thomas Mvp Er Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
6
Newest Jul 30, 2008
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
1 investigation on file

Recall campaigns

6 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

08V356000

ENGINE AND ENGINE COOLING

Jul 30, 2008
3,773 units potentially affected
The defect: DAIMLER TRUCKS IS RECALLING 3,773 MY 1996 THROUGH 2002 THOMAS BUILT MVP ER SCHOOL BUSES MANUFACTURED FROM JUNE 8, 1995 THROUGH FEBRUARY 16, 2001, EQUIPPED WITH CATERPILLAR 3116 AND 3126 ENGINES. UN-FUSED POWER CABLES WERE TIE-WRAPPED TO A WIRE BRAID ENGINE FUEL RETURN HOSE. OVER TIME THESE CABLES MAY CHAFE, WEARING THROUGH THE WIRE LOOM AND EVENTUALLY THROUGH THE CABLE INSULATION AND FUEL LINE COVERING IN AN AREA NOT EASILY DETECTABLE DURING NORMAL MAINTENANCE WITHOUT REMOVING THE TIE WRAPS AND OPENING THE WIRE LOOM. UN-FUSED AND UN-SWITCHED POWER CABLES WHICH WEAR THROUGH AND CONTACT THE FUEL LINE WIRE BRAID MAY SHORT CIRCUIT.
The risk: IN THE EVENT OF A SHORT CIRCUIT, A VEHICLE FIRE CAN OCCUR.
The remedy: THOMAS BUILT WILL NOTIFY OWNERS AND INSPECT AND REPLACE THE CABLES AS NECESSARY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 28, 2008. OWNERS MAY CONTACT THOMAS BUILT AT 1-336-889-4871.
DAIMLER TRUCKS NORTH AMERICAManufacturer number FL-534View on NHTSA.gov
08V087000

STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS

Feb 26, 2008
243,435 units potentially affected
The defect: DAIMLER TRUCKS IS RECALLING 243,435 MY 1995-2008 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 1994, AND MARCH 10, 2008. (ADDITIONAL BUSES HAVE BEEN ADDED TO THIS RECALL CAMPAIGN. PLEASE SEE SUPPLEMENTAL REPORT NO. 4) THE EMERGENCY EXIT DOOR HANDLE BEGINS CORRODING AROUND THE SECURING ROLL PIN AND SQUARE DRIVE MECHANISM CAUSING THE PROTECTIVE FINISH TO CHIP AND FLAKE. CONTINUED CORROSION AND PITTING WEAKENS THE HANDLE. HANDLES WEAKENED BY CORROSION MAY BREAK WHILE TRYING TO OPEN THE DOOR FROM THE EXTERIOR.
The risk: IN THE EVENT OF AN EMERGENCY, A PERSON ON THE OUTSIDE OF THE BUS MAY BREAK THE DOOR HANDLE TRYING TO OPEN THE EMERGENCY EXIT POTENTIALLY DELAYING EVACUATION AND INCREASING THE RISK OF PERSONAL INJURY TO THE VEHICLE'S OCCUPANTS.
The remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND WILL REPLACE THE HANDLES WITH A MORE ROBUST HANDLE FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY THOMAS BUILT BUSES DEALERSHIPS. THE RECALL BEGAN ON AUGUST 18, 2008, AND NOTIFICATION FOR THE REVISED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT APRIL 29, 2009. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871.
DAIMLER TRUCKS NORTH AMERICAManufacturer number FL-525View on NHTSA.gov
02V085000

ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

Mar 20, 2002
4,800 units potentially affected
The defect: ON CERTAIN SCHOOL BUSES, MISALIGNMENT OF THE FAN DRIVE SYSTEM COMPONENTS CAN CAUSE PREMATURE BELT AND PULLEY BEARING WEAR.
The risk: IF THE SCHOOL BUS IS DISABLED BY A COOLING SYSTEM FAILURE AND IS STALLED ON THE SIDE OF THE ROAD, AN INCREASED RISK OF A CRASH RESULTING IN INJURY TO A SCHOOL BUS OCCUPANT COULD OCCUR.
The remedy: DEALERS WILL REPLACE THE FAN BELT, IDLER PULLEY, AND BELT TENSIONER AND THE PULLEY'S LASER WILL BE ALIGNED. OWNER NOTIFICATION BEGAN JUNE 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
FREIGHTLINER CORPORATIONManufacturer number VON 49View on NHTSA.gov
00V362000

SEATS

Nov 3, 2000
6,500 units potentially affected
The defect: VEHICLE DESCRIPTION: CERTAIN SCHOOL BUSES AND TRANSIT BUSES EQUIPPED WITH NATIONAL SEATING'S SERIES 93B-SB DRIVER SEAT. A BRACKET ATTACHING THE GAS SPRING SHOCK TO THE HEIGHT ADJUSTER OF THE SEAT CAN DEFORM AND BREAK. THIS BRACKET IS LOCATED AT THE TOP OF THE HEIGHT ADJUSTER.
The risk: IF THE BRACKET IS NOT REPLACED AFTER DEFORMING, AND IS ALLOWED TO BREAK, ITS BREAKING WILL RESULT IN A SUDDEN DROP OF THE DRIVER'S SEAT, INCREASING THE RISK OF LOSS OF CONTROL OF THE VEHICLE AND A CRASH.
The remedy: DEALERS WILL REPLACE THE SEAT BASE AND ADD REINFORCEMENT TO THE SEAT ASSEMBLY
THOMAS BUILT BUSES, INC.View on NHTSA.gov
00V232002

SERVICE BRAKES, AIR:ANTILOCK

Aug 7, 2000
35,405 units potentially affected
The defect: VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS AND SCHOOL BUS CHASSIS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.
The risk: THIS CONDITION COULD CAUSE THE ABS ECU TO EXHAUST THE AIR AT THE AIR BRAKE MODULATORS FOR ONE OR MORE OF THE WHEELS. THIS COULD RESULT IN EXTENDED BRAKING DISTANCES AND A POSSIBLE CRASH.
The remedy: DEALERS WILL REPLACE THE ABS ECU.
FREIGHTLINER CORPORATIONManufacturer number FL-266View on NHTSA.gov
00V232011

SERVICE BRAKES, AIR:ANTILOCK

Aug 7, 2000
4,780 units potentially affected
The defect: VEHICLE DESCRIPTION: SCHOOL BUS CHASSIS AND EMERGENCY VEHICLES BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.
The risk: THIS CONDITION COULD CAUSE THE ABS ECU TO EXHAUST THE AIR AT THE AIR BRAKE MODULATORS FOR ONE OR MORE OF THE WHEELS. THIS COULD RESULT IN EXTENDED BRAKING DISTANCES AND A POSSIBLE CRASH.
The remedy: DEALERS WILL REPLACE THE ABS ECU.
THOMAS BUILT BUSES, INC.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

PE02023ClosedPreliminary Evaluation

FAN DRIVE UPDATE

Opened Feb 12, 2002
Closed Mar 25, 2002

IN OCTOBER 2001, THOMAS BUILT BUSES SENT OUT A VEHICLE OWNER NOTIFICATION (VON) TO BUS OWNERS OUTLINING PROCEDURES FOR THE PROPER ALIGNMENT AND REPLACEMENT OF THE ENGINE'S FAN DRIVE COMPONENTS.DIRECTIONS IN THE COMMUNICATION REQUIRE THAT THE IDLER PULLEY, BELT TENSIONER, AND THE FAN BELT WILL NEED TO BE REPLACED.PRESUMABLY, THIS ACTION WAS BEING RECOMMENDED TO ELIMINATE FAN BELT SEPARATIONS WHILE THE BUSES ARE IN SERVICE.A FAN BELT SEPARATION WOULD RESULT IN THE NGINE OVERHEATING AND ULTIMATELY STALLING.AS A RESULT OF THIS ACTION, ODI CONTACTED TWO FLEETS AND DETERMINED THAT THEY HAD SUFFERED DISABLED BUSES ON THE SHOULDER OF THE ROAD AS A RESULT OF A FAN BELT FAILURE.ON FEBRUARY 12, 2001, ODI OPENED THIE PRELIMINARY EVALUATION TO UNDERSTAND THE EXTENT OF THE FAILURES AND THE RATIONALE FOR CONDUCTING AN OWNER NOTIFICATION PROGRAM IN LIEU OF A SAFETY RECALL CAMPAIGN.ON MARCH 15, 2002, THOMAS BUILT FILED A DEFECT REPORT OUTLINING THEIR PLANS TO CONDUCT A SAFETY RECALL TO NOTIFY THE REMAINING OWNERS AND REMEDY THE AFFECTED SCHOOL BUSES.THIS INVESTIGATION IS CLOSED.

ENGINE AND ENGINE COOLINGLed to recall 02V085000

Elsewhere on this vehicle

Data sources