RoadVitals

1994 Thomas Mvp Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
8
Newest Jun 30, 2000
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
1 investigation on file

Recall campaigns

8 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

00V174000

EXTERIOR LIGHTING:HEADLIGHTS:SWITCH

Jun 30, 2000
803 units potentially affected
The defect: CERTAIN SCHOOL BUSES WITH WELDON TECHNOLOGIES' 5050-1400 SURFACE MOUNT MARKER LIGHTS HAVE AN OPTION TO REPLACE EACH OF THE TWELVE CLEARANCE/MARKER/IDENTIFICATION LIGHTS WITH FOUR-CANDLEPOWER LIGHTS, TWICE THE CANDLEPOWER NORMALLY USED. THE HIGHER CURRENT DEMAND CREATED BY THESE LIGHTS CAN CAUSE EXCESSIVE HEAT THROUGH THE HEADLIGHT SWITCH CONNECTION IF A RELAY IS NOT INSTALLED BETWEEN THE COMBINATION TAIL/MARKER LIGHT CIRCUIT AND THE HEADLIGHT SWITCH.
The risk: THIS CAN RESULT IN DEFORMATION OF THE PLASTIC CONNECTORS THAT CONNECT THE HEADLIGHT SWITCH TO ITS WIRING HARNESS.
The remedy: DEALERS WILL INSTALL A RELAY TO REDUCE THE CURRENT DRAW THROUGH THE HEADLIGHT SWITCH. OWNER NOTIFICATION BEGAN SEPTEMBER 8, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-881-7219.
FREIGHTLINER LLCView on NHTSA.gov
99V176000

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Jul 2, 1999
1,307 units potentially affected
The defect: VEHICLE DESCRIPTION: TRANSIT AND SCHOOL BUSES EQUIPPED WITH ELECTRONIC ENGINES. THE BOTTOM EDGE OF THE ACCELERATOR PEDAL CAN CATCH ON THE FLOOR MAT WHEN THE PEDAL IS FULLY DEPRESSED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 124, "ACCELERATOR CONTROL SYSTEMS."
The risk: IF THE ACCELERATOR PEDAL CATCHES ON THE FLOOR MAT, ENGINE OVERSPEED COULD OCCUR, INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL INSTALL A NEW ACCELERATOR PEDAL MOUNTING BRACKET TO RAISE THE ACCELERATOR SO THE PEDAL DOES NOT CATCH ON THE FLOOR MAT.
THOMAS BUILT BUSES, INC.View on NHTSA.gov
99V177000

EQUIPMENT:OTHER:LABELS

Jul 2, 1999
1,123 units potentially affected
The defect: VEHICLE DESCRIPTION: TRANSIT AND SCHOOL BUSES EQUIPPED WITH CUMMINS ISB OR CATERPILLAR 3126 ENGINES. A DECAL THAT WARNS OF THE DANGER OF USING ETHER OR OTHER STARTING FLUIDS IN THE ENGINE AIR INTAKE SYSTEM WAS OMITTED. THE LABEL SHOULD BE LOCATED ON THE FIXED HEADLIGHT PANEL ON THE FRONT OF THE BUS.
The risk: THE ELECTRICAL PREHEATER ELEMENT COULD POSSIBLY BE IGNITED BY STARTING FLUID SPRAYED INTO THE AIR INTAKE SYSTEM, RESULTING IN EXPLOSION AND POSSIBLE PERSONAL INJURY TO THOSE IN AND AROUND THE BUS.
The remedy: OWNERS WILL BE PROVIDED WITH A WARNING LABEL AND INSTALLATION INSTRUCTIONS.
THOMAS BUILT BUSES, INC.View on NHTSA.gov
97V133000

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

Aug 22, 1997
8,107 units potentially affected
The defect: VEHICLE DESCRIPTION: SCHOOL AND TRANSIT BUSES EQUIPPED WITH IN-LINE SIX ENGINE,"S" TYPE FRAME RAILS AND SIDE MOUNTED BATTERY BOX. THE BATTERY CABLE ROUTING ALLOWS THE POSITIVE CABLE TO CHAFE RESULTING IN A POSSIBLE SHORT CIRCUIT OF THE CABLE.
The risk: IF AN ELECTRICAL SHORT OCCURS, IT CAN CAUSE LOSS OF POWER TO THE VEHICLE AND A POSSIBLE VEHICLE FIRE.
The remedy: THOMAS BUILT WILL PROVIDE OWNERS WITH REPAIR PARTS AND DETAILED REPAIR PROCEDURES TO SECURE THE CABLE TO PREVENT FURTHER DAMAGE. IF THE OWNER SO DESIRES, THOMAS BUILT WILL PERFORM THE REPAIR FOR THEM.
THOMAS BUILT BUSES, INC.View on NHTSA.gov
96V164000

STRUCTURE:BODY

Sep 5, 1996
2,117 units potentially affected
The defect: AN ITEM WORN BY A CHILD, SUCH AS A LONG DRAWSTRING, SASH, OR BACKPACK/BOOKBAG ACCESSORY, CAN BECOME CAUGHT ON THE FATENERS THAT SECURE THE HANDRAIL SUPPORT TO THE HANDRAIL.
The risk: IF AN ITEM WORN BY A CHILD WERE TO CATCH ON THIS AREA, AND THE DRIVER WERE TO CLOSE THE DOOR AND PUT THE VEHICLE IN MOTION, THIS CAN RESULT IN SERIOUS INJURY OR DEATH.
The remedy: THE EXISTING 1" BOLTS THAT SECURE THE HANDRAIL SUPPORT WILL BE REPLACED WITH 1/2" BOLTS.
THOMAS BUILT BUSES, INC.View on NHTSA.gov
96V139000

STRUCTURE:BODY

Jul 23, 1996
120,371 units potentially affected
The defect: AN ITEM WORN BY A CHILD, SUCH AS A LONG DRAWSTRING, SASH, OR BACKPACK/BOOKBAG ACCESSORY, CAN BECOME CAUGHT IN THE AREA BETWEEN THE SERVICE DOOR AND THE DOOR CONTROL ROD ATTACHING BRACKET.
The risk: IF AN ITEM WORN BY A CHILD WERE TO CATCH ON THIS AREA, AND THE DRIVER WERE TO CLOSE THE DOOR AND PUT THE VEHICLE IN MOTION, THIS CAN RESULT IN SERIOUS INJURY OR DEATH.
The remedy: A MOLDED COVER WILL BE INSTALLED BETWEEN THE MANUALLY OPERATED OUTWARD OPENING ENTRANCE DOOR AND THE DOOR CONTROL ROD ATTACHING BRACKET WHICH WILL ELIMINATE THE OPENING THAT COULD ALLOW AN ITEM OF A CHILD'S CLOTHING TO BECOME SNAGGED.
THOMAS BUILT BUSES, INC.View on NHTSA.gov
95V148000

POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)

Aug 7, 1995
1,413 units potentially affected
The defect: THE AUTOMATIC TRANSMISSION WILL NOT SHIFT INTO LOW GEAR DUE TO A MISALIGNMENT IN THE PRNDL INDICATOR.
The risk: PRNDL MISALIGNMENT CAN CAUSE THE DRIVER TO BE UNAWAREOF THE GEAR POSITION INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
The remedy: DEALERS WILL CORRECT THE MISALIGNMENT OF THE AUTOMATIC TRANSMISSION.
THOMAS BUILT BUSES, INC.View on NHTSA.gov
95V004000

SEAT BELTS:FRONT:RETRACTOR

Jan 11, 1995
3,076 units potentially affected
The defect: THE METAL HOUSING OF THE SAFETY BELT RETRACTORS ON AUTOMATIC LOCKING RETRACTOR/EMERGENCY LOCKING RETRACTOR SAFETY BELTS CAN BECOME DEFORMED PREVENTING EXTENSION AND/OR RETRACTION OF THE BELT.
The risk: PASSENGERS WOULD BE UNABLE TO EXTEND OR RETRACT THEIR SAFETY BELTS AND WOULD BE AT A RISK OF INJURY IN THE EVENT OF AN ACCIDENT.
The remedy: DEALERS WILL INSTALL A HARDENED WASHER WHICH WILL DECREASE THE POSSIBILITY OF DEFORMATION OF THE SAFETY BELT RETRACTOR. DAMAGED RETRACTORS WILL BE REPLACED.
THOMAS BUILT BUSES, INC.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

PE06057ClosedPreliminary Evaluation

SEAT BELTS WEBBING ABRADING ON FRAME

Opened Nov 21, 2006
Closed Mar 30, 2007

THIS INVESTIGATION WAS OPENED AFTER ODI RECEIVED NOTIFICATION FROM TWO FLEETS ALLEGING THEDISCOVERY OFNUMEROUS SEAT BELTS WITH CUT WEBBING AS A RESULT OF THE WEBBING ABRADING AGAINST ANUNDERSEAT METAL BRACKET.THE SUBJECT VEHICLES ARE CLASS A SCHOOL BUSES WEIGHING UNDER 10,000 POUNDS.THEY ARE REQUIRED BY FEDERAL STANDARD FMVSS 208 TO HAVE SEAT BELTS.AS A RESULT OF THIS INVESTIGATION, FREIGHTLINER WILL CONDUCT A SAFETY RECALL TO INSPECT ALL AFFECTED BUSES FOR SEAT BELT ?CHAFING? AND WILL REPLACEDAMAGED BELTS AS NEEDED. ALSO, THE SEAT BELT RETAINER STRIP WILL BE MODIFIED OR REPLACED TO PREVENT FUTURE CHAFING.FREIGHTLINER EXPANDED THE SCOPE OF THE RECALL (BEYOND THE ORIGINAL INVESTIGATION POPULATION) TO INCLUDE APPROXIMATELY 10,251 ADDITIONAL BUSES HAVING GROSS VEHICLE WEIGHT RATINGS GREATER THAN 10,000 LBS.THEY DETERMINED THAT THESE BUSES ARE ALSO SUSCEPTIBLE TO THE CHAFING ACTION.THERE IS NO FEDERALREQUIREMENT FOR SEAT BELTS IN SCHOOL BUSES WEIGHING OVER 10,000 POUNDS.HOWEVER, SOME CUSTOMERS HAVE ORDERED SEAT BELTS AND SOME STATES HAVE REQUIREMENTS FOR SEAT BELTS.THEREFORE, FREIGHTLINER HAS AGREED TO ADDRESS THOSE BUSES EVEN THOUGH THERE IS NO APPLICABLE FEDERAL STANDARD.THE RECALL ACTION TAKEN BY FREIGHTLINER RESOLVES THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.

SEAT BELTSLed to recall 07V142000

Elsewhere on this vehicle

Data sources