RoadVitals

2001 Thomas Saf-T-Liner Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Newest Nov 1, 2001
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
1 investigation on file

Recall campaigns

2 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

01V341000

SEATS

Nov 1, 2001
708 units potentially affected
The defect: VEHICLE DESCRIPTION: CERTAIN SCHOOL BUSES EQUIPPED WITH SYNTEC SEATS FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION." SOME SEATS (1) FAIL TO MEET THE REQUIRED FOUR INCH CLEARANCE DURING THE TEST PROCEDURE, WHILE STILL MEETING THE POST TEST CONDITION; (2) FAIL TO MEET THE REQUIRED FRONTAL PRE-LOAD WHEN TESTING UNDER CERTAIN CONDITIONS; OR (3) WHILE STILL MEETING THE REQUIRED FORCE/DEFECTION, EXPERIENCE WELD BREAKAGE.
The risk: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY PROTECTED.
The remedy: DEALERS WILL REPLACE THE SEAT FRAME AND THE SEAT BACK CUSHION ON THESE VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 13, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 336-889-4871.
FREIGHTLINER CORPORATIONView on NHTSA.gov
01V103000

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Mar 27, 2001
146 units potentially affected
The defect: VEHICLE DESCRIPTION: SCHOOL BUSES. THE ACCELERATOR PEDAL CAN POSSIBLY HANG UP ON THE FLOOR RUBBER.
The risk: THE DRIVER WOULD BE EXPECTING THE VEHICLE'S SPEED TO DECREASE, INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL INSTALL A STAINLESS STEEL PLATE UNDER THE ACCELERATOR PEDAL. OWNER NOTIFICATION BEGAN JUNE 8, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-889-4871.
FREIGHTLINER CORPORATIONView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

EA04014ClosedEngineering Analysis

SCHOOL BUS LIGHTING FAILURES

Opened Jun 9, 2004
Closed Dec 20, 2004

SEE ATTACHED FOUR PAGE TECHNICAL REPORT FOR DETAILS.

EXTERIOR LIGHTING:HEADLIGHTS:SWITCH

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .