RoadVitals

2009 Thomas School Bus Owner Complaints

Reports submitted to NHTSA by owners and drivers, shown in full

Data refreshed

Complaints on fileComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
3
Latest Jun 10, 2014
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1
Filed in the last 12 monthsReports filed with NHTSA in the trailing 365 days. Recent volume reflects attention and vehicle age as much as anything else.
0
Reports on file since Nov 27, 2012

What this page shows

Our database holds 3 NHTSA owner-reported complaints for the 2009 Thomas School Bus. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Complaints, most recent first

Showing 1–3 of 3

Interior & seats
Filed Jun 10, 2014

STUDENT SEATS BROKEN. FIVE OUT OF FIFTEEN OF THE SEATS ON THIS BUS HAVE BROKEN SEAT BACKS. THE SHEET METAL BACKING IN THE INTERIOR CONSTRUCTION OF THE FRAME IS BREAKING AROUND THE SPOT WELDS WHERE IT IS WELDED TO THE STEEL TUBE FRAME. THERE IS A SERIOUS PROBLEM WITH THESE SEATS MANUFACTURED BY SYNTEC INC. MOST BUSSES RUNNING DOWN THE ROAD HAVE BROKEN SEAT BACKS IF THEY HAVE NOT ALREADY BEEN REPAIRED. THE SEATS ARE THE SAFETY BARRIER FOR THE STUDENTS IN THE EVENT OF A CRASH AND THIS COULD BE AFFECTING THE STUDENT SAFETY. *TR

NHTSA ID
10597385
Incident
Jun 10, 2014
Mileage
42,677 mi
Interior & seats
Filed May 30, 2014

SEAT BACKS BROKEN, SHEET METAL BACKING BREAKING AROUND THE SPOT WELDS WHERE IT IS SECURED TO THE TUBE FRAME. SYNTEC SEAT - MANUFACTURER. *TR

NHTSA ID
10595064
Incident
May 29, 2014
Mileage
46,558 mi
Electrical
Filed Nov 27, 2012
Fire reported

BUS WAS IN SERVICE AND ON ROUTE WITH STUDENTS ON BOARD. BUS INTERIOR STARTED FILLING WITH SMOKE. DRIVER PULLED OVER AND DID AN EMERGENCY EVACUATION OF STUDENTS. SUBSEQUENT INVESTIGATION REVEALED THE A/C 24 VOLT ALT HAD FULL FIELDED AND CAUSED THE WIRING TO COMPLETELY MELT THE SHEATHING ON THE ALT POWER WIRE. BACKFEED THROUGH THE SYSTEM CAUSED THE CONTROLLER TO BURN UP INSIDE THE BUS. CARRIER HAS TOLD US THEY KNOW OF THIS PROBLEM AND THEY HAVE A FIX FOR IT. THIS IS ONE OF AT LEAST 10 WE HAVE HAD HAPPEN. SOMETIME IT BURNS UP THE CONDENSER MOTORS AND THE EVAP MOTORS AS WELL. *TR

NHTSA ID
10486190
Incident
Nov 1, 2012
Mileage
72,354 mi

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Data sources

Data on this page last refreshed .