2006 Thor California Tahoe Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2006 Thor California Tahoe, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure545.5%
- Electrical218.2%
- Fuel system218.2%
- Interior & seats19.1%
- Other / unspecified19.1%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
FRONT AND REAR FRESH WATER TANKS FELL OUT OF THE TRAILER WHILE TOWING. THE WELDS BROKE ON THE REPLACMENT STRAPS DUE TO THE EXCESSIVE BOWING WHEN THE WATER TANKS WERE FILLED. WHEN THE TANKS FELL THE ELECTRICAL HARNESS WAS ALSO RIPPED OUT. THIS WAS THE SECOND TIME THE WATER TANKS HAVE FALLEN OUT.*AK
FRONT CAP DELAMINATION ON FIFTH WHEEL. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
FRONT AND REAR FRESH WATER TANKS FELL OUT OF THE TRAILER WHILE TOWING. THE WELDS BROKE ON THE REPLACMENT STRAPS DUE TO THE EXCESSIVE BOWING WHEN THE WATER TANKS WERE FILLED. WHEN THE TANKS FELL THE ELECTRICAL HARNESS WAS ALSO RIPPED OUT. THIS WAS THE SECOND TIME THE WATER TANKS HAVE FALLEN OUT.*AK
1.) FRONT CAP DELAMINATION 2.) FRONT LANDING GEAR MOTOR SEIZED 3.) BLACK TANK INSTALLED INCORRECTLY AND CAUSED BACKUP AT 1/4 FILL THIS HAS BEEN A PROBLEM SINCE PURCHASE. 4.) GENERATOR WILL NOT HOLD PRIME AND SHUTS OFF AFTER 2-3 MINUTES OF USE. I HAVE TO DISCONNECT THE FUEL LINE AND THEN PUMP FROM AN EXTERNAL 5 GALLON CAN TO RUN THE GENERATOR. THIS STARTED WHEN THE REPAIR OF PUMP STATION WAS COMPLETED AND I WAS TOLD THAT IT HAD NOTHING TO DO WITH IT. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
FUEL DELIVERY TO GENERATOR. I PICKED UP THE RV FROM THE REPAIR SHOP AND BROUGHT IT HOME AND RAN THE GENERATOR APPROXIMATELY 5 MINUTES UNTIL IT SHUT OFF DUE TO NO FUEL. I REMOVED THE FUEL LINE FROM THE REAR GAS TANK AND FED IT TO A REMOTE GAS CAN AND THE GENERATOR RAN FINE. THIS IS THE SAME PROBLEM I SENT IT TO THE WARRANTY REPAIR SHOP FOR. *NM
REAR PUMP STATION QUIT WORKING AND HAD TO BE REPAIRED WITHIN THE 1ST MONTH OF OWNING THE RV. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
TL*THE CONTACT OWNS A 2006 THOR CALIFORNIA TAHOE. THE CONTACT RECEIVED RECALL NOTICE NUMBER 07V282000 (LATCHES/LOCKS/LINKAGES:DOORS:LATCH). PRIOR TO RECEIVING THE NOTICE, THE FAILURE HAD ALREADY OCCURRED. SHE NOTIFIED NUMEROUS DEALERS IN HER AREA, BUT THEY NO LONGER WORK IN CONJUNCTION WITH THE MANUFACTURER. THE CONTACT NOTIFIED THOR INDUSTRIES AND THEY STATED THAT THEY WOULD FAX HER A COPY OF HOW TO REMEDY THE RECALL. THEREFORE, SHE WOULD BE ABLE TO TAKE THE VEHICLE TO ANY DEALER ON THE REPAIR LIST TO HAVE IT SERVICED. THE CONTACT NEVER RECEIVED THE FAX. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE WAS 600 AND FAILURE MILEAGE WAS 400.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
1.) FRONT CAP DELAMINATION ( YES ANOTHER ONE ) 2.) GENERATOR WILL NOT HOLD PRIME ( YES AGAIN )*JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .