2018 Thor Motor Coach Outlaw Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2018 Thor Motor Coach Outlaw, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure562.5%
- Electrical112.5%
- Steering112.5%
- Visibility112.5%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
Windows have detached from adhesive and the window does not shut or seal. There is a recall on the windows for this problem but when I put my vin number in here it does not come up as a recall.
the coach has a know design flaw its in the what the walls are attached to the flooring of the coach....the design was under spec'ed (9) 3" screws over a 55" span approx 9-10" apart) and the hardware used was put under excessive force causing the screws used to hold the walls in place and attached to the floor to sheer and break causing the walls to separate from the floor and the coach structure to become comprimised , with wall sag , wall separations gapping between the walls and floor and excessive dash bouncing while driving once these screws sheered the rest of the structure becomes weak causing other structure concerns... this has been brought to the manufactures attention in multiple emails to the warranty division and in the industry its known as "Thor wall separation" I took it upon myself to do a precautionary inspection as ive recently started to have a bit of dash bouncing upon my inspection I found at least 60% of the screws holding my walls (Driver & Pass) broken I took it upon myself to speak with local dealer whom Thor recommended and got the details on how "they" fix the problem I made the repairs and even took it a level above adding extra structure to support the walls and added extra screws 6" apart for a total of (14 screws over the 55" span approx 6" apart ) the history of this issue is as far back as 2016 and is seen on newer 2020 Thor models outside of the "Outlaw" model
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2018 THOR OUTLAW. THE CONTACT EXPERIENCED SEVERAL ELECTRICAL FAILURES WITH THE VEHICLE. THE CONTACT STATED THAT THE VEHICLE STALLED AND THERE WERE FAILURES WITH THE SINK AND DRAIN. ALSO, SIX OF THE TWELVE BOLTS WERE STRIPPED. THE DEALER (MOTOR HOME SPECIALIST, 5411 S INTERSTATE 35 W, ALVARADO, TX 76009, (817) 790-7771) WHO SOLD THE CONTACT THE VEHICLE INDICATED THAT THE FACTORY OEM BOLTS WERE TOO SHORT ASSOCIATED WITH THE RAMP AND DOOR OF THE GARAGE UNIT AREA WHERE THE MOTORCYCLE WAS HOUSED. THE DEALER PERFORMED SEVERAL REPAIRS, BUT THE CONTACT CONTINUED TO EXPERIENCE MULTIPLE FAILURES. THE VEHICLE WAS ALSO SERVICED BY CAMPING WORLD OF TUCSON (4700 S PALO VERDE RD, TUCSON, AZ 85714, (888) 471-5280) WHO PROVIDED FURTHER DIAGNOSTIC TESTING AND REPAIRS. THE MANUFACTURER WAS CONTACTED NUMEROUS TIMES AND FAILED TO PROVIDE A SOLUTION. THE FAILURE MILEAGE WAS NOT AVAILABLE. *TT *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
It seems that Thor did not install the proper amount of wall screws to the floor. This is causing wall separation the causing the dash to come loose from the walls and cause the steering column to be unstable This is a high rate of failure on these units on the Thor outlaw toy hauler models
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
Windows have detached from adhesive and the window does not shut or seal. There is a recall on the windows for this problem but when I put my vin number in here it does not come up as a recall.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .