2017 Thor Motor Coach Tuscany Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2017 Thor Motor Coach Tuscany, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure250.0%
- Fuel system125.0%
- Visibility125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
The contact owns a 2017 Thor Motor Coach Tuscany 45AT built on a 2017 Freightliner XC-R Chassis. The contact stated that while driving 50 MPH, two of the passenger's side windows detached and started flapping against the RV wall. The contact veered to the side of the road, and duct taped the windows to the side of the RV. The contact drove to the Camping lot; however, while the RV was parked, he heard an abnormal sound. The contact noticed that one of the windows that was duct taped had separated and fell onto the ground. The vehicle was taken a local dealer, where it was determined that the windows needed to be replaced. The RV was not repaired. The Freightliner manufacturer was notified of the failure and referred the contact to the Thor manufacturer. The Thor manufacturer was notified and informed the contact that there was no recall related to the failure. The failure mileage was approximately 56,000.
FLOORS IN BOTTOM STORAGE BAYS ARE SAGGING AND BOWING ARE AT RISK OF FAILING OUT ON HIGH WAY. NEED TO BE REPLACED WITH BETTER MATERIAL .
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
WHILE STATIONARY AND ENGINE COOL, I STARTED THE MOTOR COACH AND WHEN I STEPPED OUTSIDE I NOTICED THE SMELL OF DIESEL FUEL. UPON INVESTIGATION, IT WAS REVEALED THAT FLEETGUARD FUEL FILTER (RESIN CONSTRUCTION) MODEL FF63009 HAD A HAIR LINE CRACK IN THE SIDE OF THE HOUSING. A FINE SPRAY OF RAW FUEL WAS SPRAYING DIRECTLY ONTO THE DIESEL PARTICULATE FILTER (DPF). THE DPF WHEN IN REGENERATION MODE CAN REACH TEMPERATURES OF UP TO 500 DEGREE F. FORTUNATELY, THE EXHAUST SYSTEM WAS COLD AT START UP, BUT HAD IT BEEN IN RUNNING FOR A WHILE AND WENT INTO IN REGENERATION MODE, A FIRE COULD HAVE RESULTED CONSIDERING THE FINE MIST THAT WAS BEING SPRAYED ONTO THE EXHAUST. I IMMEDIATELY REMOVE AND REPLACED THE FILTER THE NEXT DAY. UNFORTIONATELY I DID NOT RETAIN THE DEFECTIVE FILTER. I UNDERSTAND THERE WAS A SIMILAR RECALL (QRMA FTDM-9M5HB6) BUT WAS NOT FOR A SPLIT IN THE SIDE OF THE HOUSING.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
The contact owns a 2017 Thor Motor Coach Tuscany 45AT built on a 2017 Freightliner XC-R Chassis. The contact stated that while driving 50 MPH, two of the passenger's side windows detached and started flapping against the RV wall. The contact veered to the side of the road, and duct taped the windows to the side of the RV. The contact drove to the Camping lot; however, while the RV was parked, he heard an abnormal sound. The contact noticed that one of the windows that was duct taped had separated and fell onto the ground. The vehicle was taken a local dealer, where it was determined that the windows needed to be replaced. The RV was not repaired. The Freightliner manufacturer was notified of the failure and referred the contact to the Thor manufacturer. The Thor manufacturer was notified and informed the contact that there was no recall related to the failure. The failure mileage was approximately 56,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .