2025 Thor Motor Coach Vegas Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2025 Thor Motor Coach Vegas, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Steering150.0%
- Tires & wheels150.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
The contact owns a 2025 Thor Motor Coach Vegas RV built on a 2025 Ford E-450 chassis. The contact stated that while placing tire covers on the front tires during a trip across the country, the contact noticed that the steel belt around the interior of one of the front tires was visible, and the steel belt was perfectly smooth in the interior of the other front tire. The contact stated that the front tires were worn to the core after driving 600 miles. The RV was taken to Napa Auto Care, where the front tires were replaced. Additionally, the mechanic informed the contact that the tires failure was due to the clamps and tie rod end on the right side of the steering wheel being loosened, causing damages to the front alignment. The mechanic tightened the clamps, and the RV was repaired. The Ford manufacturer was notified of the failure and referred the contact to a Ford dealer to fill out a form for reimbursement. The dealer later informed the contact that the manufacturer had denied reimbursement because the chassis was sold to the Thor Motor Coach manufacturer. The Thor Motor Coach manufacturer was contacted and informed the contact that the Ford manufacturer was responsible of the Chassis warranty coverage. No further assistance was provided. The failure mileage was approximately 4,837.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
The contact owns a 2025 Thor Motor Coach Vegas RV built on a 2025 Ford E-450 chassis. The contact stated that while placing tire covers on the front tires during a trip across the country, the contact noticed that the steel belt around the interior of one of the front tires was visible, and the steel belt was perfectly smooth in the interior of the other front tire. The contact stated that the front tires were worn to the core after driving 600 miles. The RV was taken to Napa Auto Care, where the front tires were replaced. Additionally, the mechanic informed the contact that the tires failure was due to the clamps and tie rod end on the right side of the steering wheel being loosened, causing damages to the front alignment. The mechanic tightened the clamps, and the RV was repaired. The Ford manufacturer was notified of the failure and referred the contact to a Ford dealer to fill out a form for reimbursement. The dealer later informed the contact that the manufacturer had denied reimbursement because the chassis was sold to the Thor Motor Coach manufacturer. The Thor Motor Coach manufacturer was contacted and informed the contact that the Ford manufacturer was responsible of the Chassis warranty coverage. No further assistance was provided. The failure mileage was approximately 4,837.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .