2022 Thor Motor Coach Windsport Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2022 Thor Motor Coach Windsport, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure250.0%
- Other / unspecified125.0%
- Visibility125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
While driving on a crowded freeway a wooden structure fell from the ceiling of my motorhome and landed on the dashboard inches from my steering wheel. If it had hit my steering wheel or my hands, I would have been involved in a multiple vehicle collision. Thank God, I was able to safely pull over to the shoulder to check for damage. The beam was too heavy for me to move it. I drove it to a Camping World repair facility. The repair technician inspected the damage. He told me the support structure fell because it was held up by only one screw. Please note the comments for Job#4 in the repair invoice I hope to attach. I tried to upload some photos of the fallen structure, but I couldn't upload them. There were no warnings or symptoms of the defects. The damage was inspected and confirmed by the service technician of the New Braunfels, Texas Camping World. They reinforced the structure by mounting it with more screws, I do not know the size or number of screws installed. ( their is a typo in the job order document notes. I typed "Please Not comments for Job#4", it should be "Please note comments for Job#4". I anticipate a negative reaction by Thor Industries as I filed a Texas Lemon Law complaint because of many other defects and equipment failures in the motorhome. Part of the invoice includes a windshield wiper motor and gears that fell apart
The contact owns a 2022 Thor Motor Coach Windsport RV built on a 2020 Ford F-53 chassis. The contact stated that while driving at 65 MPH, a wooden beam used to deflect airflow from the outer venting fell from the ceiling of the RV. The heavy beam fell inches away from the contact's hands that were on the steering wheel. The contact pulled over after the failure but could not move the beam due to the weight. Despite the failure, the contact was able to drive the vehicle to the RV dealer where it remained. The manufacturer was notified of the failure but offered no assistance. The beam was reinstalled, and the RV was repaired. The contact expressed concerns that the failure might reoccur, and cause a severe crash. The failure mileage was approximately 14,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
I’m concerned about the bbq propane compartment getting hairline cracks and the brass shut off valve that’s made of brass and dropping down to the road and getting road rash till it grinds through the shut off valve. I just read on a Thor Facebook forum that this happened to a 2016 Thor Windsport 34P. I have the pictures he posted. I asked AI Gemini, apparently this is a known and well documented safety issue. I can forward the link to the AI report. Will link here if this works. The pictures are mine (intact) and the other two are his 2016 motorhome. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
While driving on a crowded freeway a wooden structure fell from the ceiling of my motorhome and landed on the dashboard inches from my steering wheel. If it had hit my steering wheel or my hands, I would have been involved in a multiple vehicle collision. Thank God, I was able to safely pull over to the shoulder to check for damage. The beam was too heavy for me to move it. I drove it to a Camping World repair facility. The repair technician inspected the damage. He told me the support structure fell because it was held up by only one screw. Please note the comments for Job#4 in the repair invoice I hope to attach. I tried to upload some photos of the fallen structure, but I couldn't upload them. There were no warnings or symptoms of the defects. The damage was inspected and confirmed by the service technician of the New Braunfels, Texas Camping World. They reinforced the structure by mounting it with more screws, I do not know the size or number of screws installed. ( their is a typo in the job order document notes. I typed "Please Not comments for Job#4", it should be "Please note comments for Job#4". I anticipate a negative reaction by Thor Industries as I filed a Texas Lemon Law complaint because of many other defects and equipment failures in the motorhome. Part of the invoice includes a windshield wiper motor and gears that fell apart
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .