2016 Thor Palazzo Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2016 Thor Palazzo, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure250.0%
- Other / unspecified125.0%
- Visibility125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
A bracket holding the front fiberglass cap or facia to the frame came loose and fell off on the interstate I-94 in Wisconsin, making a big clunk under our motorcoach causing several cars to swerve avoiding the metal bracket laying in the road. We had to pull over on the busy interstate to assess any damage to our coach. Luckily we came out unscathed. After looking into this further, I noticed that the screws holding the bracket on were broken off in the metal frame. I looked at the other bracket on the driver's side and the screws were broken off in the frame too and being held by one wood screw on the fiberglass facia. It seems that the wrong type of fasteners ate being used causing this failure
THE WOOD FLOORS IN THE CARGO BAYS OF MY CLASS 'A' MOTORHOME WERE NOT SEALED DURING MANUFACTURING, WHICH ALLOWED WATER TO ENTER THE BAYS AND ROTTING THE WOOD FLOORS. THIS RESULTED IN A HAZARDOUS CONDITION WHILE THE VEHICLE IS IN MOTION WHERE ITEMS, IN THE BAYS, COULD FALL UNDER THE TIRES OR JEOPARDIZE THE SAFETY OF OTHER VEHICLES. THIS CONDITION HAS OCCURRED TWICE ON MY VEHICLE AND WAS REPAIRED ONCE BY THOR UNDER WARRANTY, BUT REOCCURRED LESS THAN SIX MONTHS LATER.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
WE ARE VERY CONCERNED THE WINDOWS ON OUR 2016 PALAZZO WITH ONLY 12000 MILES ON IT HAS WINDOWS THAT ARE SEPARATING. THEY STARTED SEPARATING AT 8000. WE HAVE 5 WINDOWS THAT ARE SEPARATING AND ALL OF THE SUDDEN ARE HANGING OFF THE MOTOR HOME. IT WOULD BE DEVASTATING IF THEY FELL OFF AND HIT ANOTHER MOTOR VEHICLE OR MOTORCYCLE. *DT*JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
WE ARE VERY CONCERNED THE WINDOWS ON OUR 2016 PALAZZO WITH ONLY 12000 MILES ON IT HAS WINDOWS THAT ARE SEPARATING. THEY STARTED SEPARATING AT 8000. WE HAVE 5 WINDOWS THAT ARE SEPARATING AND ALL OF THE SUDDEN ARE HANGING OFF THE MOTOR HOME. IT WOULD BE DEVASTATING IF THEY FELL OFF AND HIT ANOTHER MOTOR VEHICLE OR MOTORCYCLE. *DT*JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .