RoadVitals

2003 Tiffin Allegro Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
11
Latest Jun 27, 2019
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
4
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
2

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2003 Tiffin Allegro, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes650.0%
  • Engine433.3%
  • Electrical18.3%
  • Fuel system18.3%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

6
reports

From owner reports, verbatim

SUDDEN LOSS OF BRAKES ON A DOWNHILL GRADE. HAD TO PULL TO SHOULDER AND SCRAPE ALONG UNTIL SLOWED ENOUGH TO STOP WITH PARKING BRAKE. CALIPERS FROZE CAUSING BOIL OVER OF FLUIDS THAT BURNED BRAKE HOSES AND SENSORS.

NHTSA ID 11223000 · filed Jun 27, 2019

TL*THE CONTACT OWNS A 2003 TIFFIN ALLEGRO 31DA MOBILE HOME WITH A WORKHORSE CHASSIS W22. WHILE DRIVING APPROXIMATELY 60-65 MPH HE ENGAGED THE BRAKES AND HE COULD SMELL SMOKE. HE STATED THAT WHEN THIS HAPPENED HE HAD TO ALLOW THE BRAKES TO COOL OFF IN ORDER TO CONTINUE DRIVING. HE RECEIVED TWO RECALL NOTICES AND WORKHORSE HAD NOT FOUND A SOLUTION FOR THE RECALL REPAIR. THE FAILURE OCCURRED INTERMITTENTLY. THE CONTACT STATED THAT HE WAS THE SECOND OWNER AND THE FORMER OWNER STATED THAT THE BRAKES WERE PREVIOUSLY REPAIRED. HE REFERENCE RECALL NHTSA CAMPAIGN ID NUMBER: 09V110000, SERVICE BRAKES, HYDRAULIC. THE APPROXIMATE FAILURE MILEAGE WAS 28,000 AND THE CURRENT MILEAGE WAS 37,000.

NHTSA ID 10341010 · filed Jul 1, 2010

Too few reports in this category for a page of its own — they appear in the full complaint list.

Engine

Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.

4
reports

From owner reports, verbatim

TL* THE CONTACT OWNS A 2003 TIFFIN ALLEGRO BAY RV EQUIPPED WITH A WORKHORSE W22 CHASSIS. WHILE DRIVING 65 MPH, THE REDUCE POWER WARNING LIGHT ILLUMINATED AS THE RV STALLED. THE CONTACT WAS ABLE TO RESTART THE RV AFTER SEVERAL MOMENTS. THE CONTACT STATED THAT THE FAILURE WOULD RECUR INTERMITTENTLY ON A REGULAR BASIS. THE RV WAS TAKEN TO A DEALER TWICE AND THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE FAILURE PERSISTED AND THE RV WAS TAKEN BACK TO THE DEALER. THE DEALER THEN REPLACED THE THROTTLE BODY MODULAR BUT TO NO AVAIL. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 28,000. UPDATED 03/07/11*LJ UPDATED 09/16/11

NHTSA ID 10380063 · filed Feb 3, 2011

MOTORHOME LOST POWER ON 4 DIFFERENT OCCASIONS AND SUFFERED A SEVERE JOLT WHILE TRAVELLING 60 - 65 MPH ON 3 DIFFRERENT OCCASIONS.*AK

NHTSA ID 10028746 · filed Jul 21, 2003

Too few reports in this category for a page of its own — they appear in the full complaint list.

Electrical

Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.

1
report

From owner reports, verbatim

HEATER GRID IS PART OF ENGINE COOLING SYSTEM. THIS SYSTEM DIDN'T TURN OFF AND WIRE WAS BURNING. DEALERSHIP IS AWARE OF PROBLEM.*AK

NHTSA ID 8018543 · filed Sep 12, 2002

Too few reports in this category for a page of its own — they appear in the full complaint list.

Fuel system

Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.

1
report

From owner reports, verbatim

DT*: THE CONTACT STATED WHILE DRIVING 15MPH THE VEHICLE STALLED TWICE. BOTH TIMES THE VEHICLE WAS TOWED TO THE DEALER WHERE THE FUEL PUMP WAS REPLACED.

NHTSA ID 10156080 · filed Apr 25, 2006

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .