RoadVitals

2003 Tiffin Allegro

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
11
Latest Jun 27, 2019
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
7
Latest Feb 8, 2011
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
2

Overview

Our database contains 11 NHTSA owner-reported complaints for the 2003 Tiffin Allegro, most frequently naming the brakes, engine and electrical categories. 7 safety recalls have been issued covering this model year; and 9 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Brakes650.0%
  • Engine433.3%
  • Electrical18.3%
  • Fuel system18.3%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

7 campaigns cover this model year

View all 7

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
11V082000

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Feb 8, 2011
10,683 units potentially affected
The defect: TIFFIN MOTORHOMES IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.
The risk: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.
The remedy: TIFFIN MOTORHOMES IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE SAFETY RECALL BEGAN ON FEBRUARY 17, 2011. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101.
TIFFIN MOTORHOMES, INC.View on NHTSA.gov
10V585000

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Nov 22, 2010
2,717 units potentially affected
The defect: TIFFIN IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.
The risk: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.
The remedy: TIFFIN IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN ON FEBRUARY 17, 2011. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR TIFFIN AT 1-256-356-8661.
TIFFIN MOTORHOMES, INC.View on NHTSA.gov
09V443000

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Nov 17, 2009
528 units potentially affected
The defect: TIFFIN IS RECALLING CERTAIN RECREATIONAL VEHICLE EQUIPPED WITH NORCOLD MODEL 1200LR AND 1200LRIM REFRIGERATORS, MANUFACTURED FROM DECEMBER 1, 2001, WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.
The risk: IF A LEAK OCCURS AND THE UNIT IS CONTINUES TO OPERATE, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.
The remedy: TIFFIN IS WORKING WITH NORCOLD AND TIFFIN WILL NOTIFY OWNERS AND THE VEHICLE'S REFRIGERATOR WILL BE REPAIRED FREE OF CHARGE BY NORCOLD. PLEASE SEE NORCOLD'S DEFECT REPORT 09E-027. OWNERS MAY CONTACT NORCOLD'S RECALL CENTER AT 1-800-767-9101.
TIFFIN MOTORHOMES, INC.View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 11
Brakes
Filed Jun 27, 2019
Fire reported

SUDDEN LOSS OF BRAKES ON A DOWNHILL GRADE. HAD TO PULL TO SHOULDER AND SCRAPE ALONG UNTIL SLOWED ENOUGH TO STOP WITH PARKING BRAKE. CALIPERS FROZE CAUSING BOIL OVER OF FLUIDS THAT BURNED BRAKE HOSES AND SENSORS.

NHTSA ID
11223000
Incident
May 24, 2019
Mileage
14,000 mi
Engine
Filed Feb 3, 2011

TL* THE CONTACT OWNS A 2003 TIFFIN ALLEGRO BAY RV EQUIPPED WITH A WORKHORSE W22 CHASSIS. WHILE DRIVING 65 MPH, THE REDUCE POWER WARNING LIGHT ILLUMINATED AS THE RV STALLED. THE CONTACT WAS ABLE TO RESTART THE RV AFTER SEVERAL MOMENTS. THE CONTACT STATED THAT THE FAILURE WOULD RECUR INTERMITTENTLY ON A REGULAR BASIS. THE RV WAS TAKEN TO A DEALER TWICE AND THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE FAILURE PERSISTED AND THE RV WAS TAKEN BACK TO THE DEALER. THE DEALER THEN REPLACED THE THROTTLE BODY MODULAR BUT TO NO AVAIL. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 28,000. UPDATED 03/07/11*LJ UPDATED 09/16/11

NHTSA ID
10380063
Incident
Oct 15, 2008
Mileage
28,000 mi
Brakes
Filed Jul 1, 2010
Fire reported

TL*THE CONTACT OWNS A 2003 TIFFIN ALLEGRO 31DA MOBILE HOME WITH A WORKHORSE CHASSIS W22. WHILE DRIVING APPROXIMATELY 60-65 MPH HE ENGAGED THE BRAKES AND HE COULD SMELL SMOKE. HE STATED THAT WHEN THIS HAPPENED HE HAD TO ALLOW THE BRAKES TO COOL OFF IN ORDER TO CONTINUE DRIVING. HE RECEIVED TWO RECALL NOTICES AND WORKHORSE HAD NOT FOUND A SOLUTION FOR THE RECALL REPAIR. THE FAILURE OCCURRED INTERMITTENTLY. THE CONTACT STATED THAT HE WAS THE SECOND OWNER AND THE FORMER OWNER STATED THAT THE BRAKES WERE PREVIOUSLY REPAIRED. HE REFERENCE RECALL NHTSA CAMPAIGN ID NUMBER: 09V110000, SERVICE BRAKES, HYDRAULIC. THE APPROXIMATE FAILURE MILEAGE WAS 28,000 AND THE CURRENT MILEAGE WAS 37,000.

NHTSA ID
10341010
Incident
Dec 18, 2008
Mileage
28,000 mi
Brakes
Filed Apr 27, 2010

IN 2008 FULL LOSS OF BRAKE FUNCTIONING IN OUR 2003 ALLEGRO MOTORHOME WITH A WORKHORSE CHASSIS GOING UP HILL. WE HAD MOTORHOME TOWED TO SERVICE CENTER. WORKHORSE REFUSED TO TAKE RESPONSIBILITY CLAIMING IT WAS MY HUSBAND WHO HELD THE BRAKES ON TO LONG. HE IS A PROFESSIONAL CEMENT TRUCK DRIVER AND THIS IS NOT THE CASE. THE BRAKE PADS SHOW NO WEAR THEY WERE JUST BURNED WHEN THE BRAKE SYSTEM FAILED. WE PAID TO HAVE ALL BRAKE SYSTEMS REPLACED, BUT NOW ARE AFRAID TO DRIVE THE COACH BECAUSE AFTER RECEIVING THE RECALL NOTICE IT MAY HAPPEN AGAIN AND WE ARE IN FEAR OF OUR FAMILIES SAFETY. WE CONTINUE TO MAKE PAYMENTS ON A MOTORHOME WE ARE UNABLE TO USE DUE TO SAFETY ISSUES WORKHORSE IS UNABLE TO REPAIR. *TR

NHTSA ID
10327796
Incident
Oct 17, 2008
Mileage
9,221 mi
Brakes
Filed Jun 1, 2009

TL*THE CONTACT OWNS A 2003 TIFFIN ALLEGRO RECREATIONAL VEHICLE. WHILE DRIVING LESS THAN 60 MPH, THE BRAKES FAILED. THE CONTACT DEPRESSED THE BRAKE PEDAL AND IT EXTENDED TO THE FLOOR. HE WAS ABLE TO MANEUVER THE VEHICLE OFF THE ROAD AND CONTINUED TO PUMP THE BRAKES. THE BRAKES FINALLY BECAME OPERABLE AFTER SEVERAL ATTEMPTS. HE LATER RECEIVED A RECALL NOTICE STATING THAT THERE WAS A RECALL ON HIS UNIT. THE REMEDY OFFERED A NEW DESIGN ON THE BRAKING UNIT; HOWEVER, THE PARTS WOULD NOT BE IMMEDIATELY AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 10,000. UPDATED 06/23/09. *LJ THE CONSUMER STATED THE BRAKES ON THE RV HAVE FAILED TWICE. UPDATED 06/23/09.*JB

NHTSA ID
10272530
Incident
Apr 10, 2006
Mileage
10,000 mi
Brakes
Filed May 25, 2009

BRAKE LOCKUP AFTER HARD STOP BEING REQUIRED. BRAKES WORKED CORRECTLY AND SMOOTHLY FOR OVER 100 MILES, BUT I HAD A SITUATION WHERE HAD I TRIED AND FINISH MY LEFT TURN (TWO LANE HIGHWAY) I WOULD HAVE BEEN HIT IN THE SIDE BY A SEMI-TRUCK THAT DECIDED TO PASS. I HAD THE LEFT TURN SIGNAL ON AND WAS DRIVING SLOW IN ORDER TO MAKE MY TURN WHEN I SAW THE SEMI, AT WHICH TIME I PULLED OVER TO THE RIGHT AND HIT MY BRAKES. I THEN DROVE APPROX. 2-3 MILES TO MY DESTINATION AND THAT IS WHEN THE BRAKES HEATED UP, AS YOU COULD SMELL THEM. *TR

NHTSA ID
10269886
Incident
May 21, 2009
Mileage
24,500 mi
Brakes
Filed Dec 8, 2008

TL*THE CONTACT OWNS A 2003 TIFFIN ALLEGRO RV. WHILE DRIVING APPROXIMATELY 40 MPH ON NORMAL ROAD CONDITIONS, THE VEHICLE FAILED TO SLOW DOWN WHEN THE BRAKE PEDAL WAS DEPRESSED. SUDDENLY, AFTER PUMPING THE BRAKES SEVERAL TIMES, THE VEHICLE CAME TO A COMPLETE STOP. THE ABS WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AND REMAINED LIT UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION AND THEY STATED THAT THERE WAS BRAKE FAILURE. THE TECHNICIAN REPLACED THE BRAKE SYSTEM; HOWEVER, THE FAILURE RECURRED. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 03V149000 (SERVICE BRAKES, HYDRAULIC;SWITCHES:BRAKE WARNING), ALTHOUGH THE FAILURES WERE IDENTICAL. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 1,800 AND CURRENT MILEAGE WAS 9,600.UPDATED 01/09/09. *LJ UPDATED 01/12/09. *JB

NHTSA ID
10251084
Incident
May 3, 2006
Mileage
1,800 mi
Fuel system
Filed Apr 25, 2006

DT*: THE CONTACT STATED WHILE DRIVING 15MPH THE VEHICLE STALLED TWICE. BOTH TIMES THE VEHICLE WAS TOWED TO THE DEALER WHERE THE FUEL PUMP WAS REPLACED.

NHTSA ID
10156080
Incident
Oct 25, 2005
Mileage
21,207 mi

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

Letter to dealer

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This was a letter to our dealers we sent out when we first heard of the Kidde fire extinguisher recall, even though it was still unofficial. We knew our coaches on the dealers' lots contained Kidde and could not be sold unreplaced.

SB-36

EQUIPMENT:APPLIANCE:AIR CONDITIONER

TIFFIN MOTORHOMES: TSB CONTAINS NOTIFICATION OF OWNER LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. TWO SCREWS WAS NOT INSTALLED ON THE AIR CONDITION UNITS ON THE ROOF. *TA UPDATED 11/24/15. *PE

16AWG

ELECTRICAL SYSTEM:STARTER ASSEMBLY:SOLENOID; ELECTRICAL SYSTEM:WIRING; ELECTRICAL SYSTEM:WIRING: REAR COMPARTMENT/TRUNK

RV: INSTRUCTIONS ON HOW TO INSTALL THE CHARGE SOLENOID WIRING IN A RV OR VEHICLE. *TA

C85-C86AC

EQUIPMENT

TIFFIN MOTORHOMES: TSB CONTAINS NOTIFICATION OF OWNER LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. ALL TIFFIN MOTORHOMES WILL BE INSTALLING 2 BACK SCREWS OF THE C85 AND C86 A/C'S TO THE ROOF OF ALL TIFFIN MOTORHOMES. *TA.

SB-41

STRUCTURE

TIFFIN MOTORHOMES: TSB CONTAINS NOTIFICATION OF OWNER LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. THE PROCEDURE TO SEAL UNDER THE F-TRIM ON ALL ALLEGROS. *JS UPDATED 6/29/15. *TA

WI-196

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

TIFFIN MOTORHOMES: TSB CONTAINS NOTIFICATION OF OWNER LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. SOME TIFFIN MOTORHOMES NEED DRIVER/PASSENGER SEATBELTS TIGHTENED ON THE MOUNTING BRACKETS LOCATED ON THE DRIVER/PASSENGER SIDEWALL. *TA

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Tiffin Allegro by model year
YearComplaintsRecallsInvestigationsIssue Index
2025000—
2024200—
2023520—
2022350—
2021550—
2020120—
2019220—
2018430—
2017330—
2016530—
2015050—
2014250—
2013440—
2012430—
2011680—
20103100—
2009070—
2008270—
2007280—
2006260—
2005270—
2004180—
2003Viewing1170—
20021050—
20011060—
20001050—
1999440—
1998430—
1997320—
1996200—
1995400—
1994300—
1993200—
1992100—
1991100—
1990100—
1988100—
1986101—
1985100—
1984100—
1983100—
1980010—
1979010—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.